Oneida Air Systems 10 Gallon Bedienungsanleitung

Rev: 12/09/2021 Doc. # ZBM000036DEL10A

Appearance may vary slightly

Dust Deputy Deluxe

10 Gallon

10 Gallon SD

# AXD000010

# AXD000010SD

U.S. Pat.

6833016

RE40048

7282074

10 Gallon SD

Oneida Air Systems2

System Start-Up Information

1. Do not vacuum anything that is burning or smoking, such as cigarettes,

matches, hot ashes, or any hot substance!

2. Do not vacuum (or use this cyclone near) ammable or combustible

liquids, gases, or explosive dusts, such as gasoline or other fuels,

lighter uid, cleaners, oil-based paints, natural gas, hydrogen, coal dust,

magnesium dust, grain dust, aluminum dust, sugar dust, our dust or

gun powder.

3. To reduce the risk of health hazards from vapors or dusts, do not

vacuum toxic materials unless a HEPA lter is used. Do not use or store

near hazardous materials.

4. Dust can be ammable and explosive. Some dust can be toxic or cause

allergic reactions.

5. Wood dust mixtures are highly ammable and can be explosive.

NEVER introduce sparks or sources of ignition into collector.

a. Empty drum after each use.

b. Ground system.

6. NEVER leave wood dust in a building or vehicle.

7. Keep re extinguishers handy at all times.

8. Can be used for collecting non-ammable liquids.

9. Dispose of waste in a FIRE SAFE AREA.

READ THE SAFETY PRACTICES INSTALLATION

AND MAINTENANCE INSTRUCTIONS AND YOUR

WET/ DRY VACUUM’S OWNER’S MANUAL BEFORE

ASSEMBLING AND USING THE DUST DEPUTY

SOME DUSTS ARE HIGHLY FLAMMABLE OR

EXPLOSIVE. LEARN/ KNOW WHAT YOU ARE

DEALING WITH. FOLLOW ALL LOCAL, STATE,

FEDERAL & NFPA CODES AND GUIDELINES.

3oneida-air.com

Tapered Inlet

and Outlet

2" O.D.

1-7/8" I.D.

51 mm O.D.

48 mm I.D.

System Dimensions

Nominal dimensions shown. Dimensions subject to slight

variations in manufacturing.

203 mm

6-3/4"

171 mm

19"

483 mm

2-1/2"

64 mm

13-1/4"

337 mm

9-5/8"

244 mm

32-1/8"

815 mm

28 -7/16"

721 mm

19 -7/16"

493 mm

Oneida Air Systems4

System Contents

ID Part number Part description Qty

A VXC110002 Anti- Static Cyclone 1

B AXG000004A Cyclone Gasket 1

C AHX000016 Cyclone Hardware Pack 1

C1 AFS015920 1/4" - 20 x 3/4" Hex Head Bolt 6

C2 AFW025000 1/4" Flat Washer 6

C3 AFT000005 1/4" Whiz-Lock Nut 6

D SEX100000 Steel Lid for 10 Gallon Drum 1

E SES100000 10 Gallon Steel Drum with Clamp 1

F SDD000004 Dolly Legs 3

G AFS015800 1/4"-20 x 1/2" Hex Head Bolt 3

H AFT000005 1/4" Whiz-Lock Nut 3

I RBB000010 Retainer Clips Pack of 6 1

J AHK000012 Caster Hardware Pack 2

J1 ———— Nylock Nuts 3

J2 ———— Washers 6

J3 ———— 38mm Polypropylene Casters 3

K VFA050015 Metal Grounding Tape 24"

INCLUDED ONLY WITH AXD000010

L AXD250066 2.5" x 5.5' Wire-Reinforced Vacuum Hose 1

INCLUDED ONLY WITH AXD000010SD

A VXC110009 Static Dissipative Cyclone 1

M AXD200055 2.5" x 55" Static Conductive Raw Hose 1

N AXD600103 2" Elbow 2

O AHA000004 2.5"Vacuum Hose Elbow 1

P AHA990250 2" to 1-1/2" Reducer, 2" to 1-1/4" Reducer, and Coupler 1

5oneida-air.com

Please unpack the parts carefully and conrm you have received

each item listed here.

System Contents (Cont.)

CC1 C2

L M N

×2

Oneida Air Systems6

You will need the following:

• 7/16" Open End Wrench

• Wet/Dry Vacuum

• Vacuum Hose

• Vacuum hose adapters

• 1/2" Nut Driver

Assembly Instructions

FIG. 1a

FIG. 1b

Arrange the Dolly Legs (F) in a descending stack as shown

in [FIG. 1a] and [FIG. 1b].

7oneida-air.com

Assembly Instructions (Cont.)

FIG. 2a

FIG. 2b

Secure Dolly Legs (F) together using three Bolts (G) and

three Whiz-Lock Nuts (H) as shown in [FIG. 2a] and [FIG.

2b].

Oneida Air Systems8

Assembly Instructions (Cont.)

Thread each of the six Casters (J3) through the Dolly Leg

Assembly (F) and a Retainer Clip (I). Secure together

using six Nylock Nuts (J1) [FIG. 3a] [FIG. 3b].

Note: For ease of assembly, hardware should be nger

tightened. when connecting the Drum (D).

FIG. 1a

FIG. 1b

9oneida-air.com

Assembly Instructions (Cont.)

Place the Drum (E) onto the Assembled Dolly [FIG. 4a],

then slide the Retainer Clips (I) into position over the

bottom lip of the drum to securely hold the container in

place. [FIG. 4b] Start by tightening two opposing Nylock

Nuts (J1) until the lip of the drum is fully secured. [FIG.

4c] Then repeat the process for the next two opposing pairs,

making sure that the drum is centered as you go.

FIG. 4a

FIG. 4b

FIG. 4c

Oneida Air Systems10

Turn Cyclone (A) upside-down. Place Gasket (B) on the

base of Cyclone and the topside of the Lid (D) against

Gasket (B) and align all the holes. Secure Cyclone, Gasket,

and Lid together using six Bolts (C1), six Washers (C2), and

six Whiz-Lock Nuts (C3) as shown in [FIG. 5].

Note: oroughly tighten hardware to eliminate air leaks.

FIG. 5

Assembly Instructions (Cont.)

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Oneida Air Systems Staubsauger Handbücher

Oneida Air Systems

Oneida Air Systems CC500 Bedienungsanleitung

Oneida Air Systems

Oneida Air Systems Ultimate Dust Deputy Bedienungsanleitung

Oneida Air Systems

Oneida Air Systems Dust Cobra Bedienungsanleitung

Oneida Air Systems

Oneida Air Systems Ultimate Dust Deputy Bedienungsanleitung

Oneida Air Systems

Oneida Air Systems Dust Cobra - XCK010000 Bedienungsanleitung

Oneida Air Systems

Oneida Air Systems AXD000009 Bedienungsanleitung

Beliebte Staubsauger Handbücher anderer Marken

Bissell

Bissell LittleGreen Proheat 1425 Series Bedienungsanleitung

Panasonic

Panasonic MC-YL637S147-AE Bedienungsanleitung

LG A9 Series Bedienungsanleitung

Oreck

Oreck Cordless Captura BK51700 Series Bedienungsanleitung

Kogan

Kogan KAVACROBVWA Bedienungsanleitung

Kränzle

Kränzle VENTOS 50 ID Benutzerhandbuch

NEFF

NEFF N17XH10 0 Series Bedienungsanleitung

EVVO

EVVO Ai35 Bedienungsanleitung

DeWalt

DeWalt DWH200D Bedienungsanleitung

Pontec

Pontec Pondomatic Vacuum Cleaner Bedienungsanleitung

Cleanmaxx

Cleanmaxx PC-P007E Bedienungsanleitung

RIDGID

RIDGID WD1685AU0 Bedienungsanleitung

Ezviz

Ezviz RE4P Bedienungsanleitung

STG global

STG global TANVAC HDV3000 Bedienungsanleitung

Shark

Shark ROTATOR PRO COMPLETE NV550 Series Bedienungsanleitung

Factory

Factory M3340 Bedienungsanleitung

Shop-Vac

Shop-Vac VN92 SERIES Bedienungsanleitung

Nobles

Nobles 608669 Produkthandbuch