PEERLESS PANA-85WM Leitfaden

1 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

Model: PANA-85WM

Installation and Assembly:

Wall Mount for Panasonic TH-85PF12U and TH-85VX200U

Landscape

Portrait

Maximum Load Capacity:

270 lb (122 kg)

2 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

Table of Contents

Parts List.................................................................................................................................................................................3

Installation to Triple Wood Stud Wall......................................................................................................................................4

Installation to Solid Concrete or Cinder Block ........................................................................................................................5

Installing Tilt Brackets.............................................................................................................................................................7

Mounting and Removing Flat Panel Screen...........................................................................................................................8

IMPORTANT! Read instruction sheet before you start installation and assembly.

• DonotbegintoinstallyourPeerlessproductuntilyouhavereadandunderstoodtheinstructionsandwarnings

containedinthisInstallationSheet.Ifyouhaveanyquestionsregardinganyoftheinstructionsorwarnings,forUS

customerspleasecallPeerlesscustomercareat1-800-865-2112,forallinternationalcustomers,pleasecontact

yourlocaldistributor.

• Thisproductshouldonlybeinstalledbysomeoneofgoodmechanicalaptitude,hasexperiencewithbasicbuilding

construction,andfullyunderstandstheseinstructions.

• Makesurethatthesupportingsurfacewillsafelysupportthecombinedloadoftheequipmentandallattached

hardwareandcomponents.

• NeverexceedtheMaximumLoadCapacity.Seepageone.

• Ifmountingtowoodwallstuds,makesurethatmountingscrewsareanchoredintothecenterofthestuds.Useof

an"edgetoedge"studnderishighlyrecommended.

• Alwaysuseanassistantormechanicalliftingequipmenttosafelyliftandpositionequipment.

• Tightenscrewsrmly,butdonotovertighten.Overtighteningcandamagetheitems,greatlyreducingtheirholding

power.

• Thisproductisintendedforindooruseonly.Useofthisproductoutdoorscouldleadtoproductfailureandpersonal

injury.

• Thisproductwasdesignedtobeinstalledonthefollowingwallconstructiononly;

WALL CONSTRUCTION HARDWARE REQUIRED

 •Wood Stud Included

•Wood Beam Included

•Solid Concrete Included

•Cinder Block Included

•MetalStud   ContactQualiedProfessional

•Brick    ContactQualiedProfessional

•Otherorunsure?   ContactQualiedProfessional

WARNING

3 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

AB C

E JH KG I L

Description Qty. Part #

wallplate 1 201-1697

Btilt plate 1 201-1695

Csupport tube 2 201-1693

Dadapter bracket 2 201-1692

Erectangle cap 4 590-1334

FM8x15mmphillipsscrew 18 520-9257

GM5x8mmphillipsscrew 2 570-0005

H8mmanchor 9 590-0320

I#14x2.5woodscrew 9 5S1-015-CO3

J5/16splitwasher 18 540-9405

K5/16washer 18 540-9406

Llock bracket 2 201-1698

Parts List

4 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

Installation to Triple Wood Stud Wall

Useastudndertolocatetheedgesofthestuds.Useofanedge-to-edgestudnderishighlyrecommended.

Basedontheiredges,drawaverticallinedowneachstud’scenter.Placewallplate(A)onwallasatemplate.

Levelplate,andmarkthecenteroftheninemountingholes.Makesurethatthemountingholesareonthestud

centerlines.Drillnine5/32"(4mm)dia.holes2.5"(64mm)deep.Makesurethatthewallplateislevel,secureit

usingnine#14x2.5"woodscrews(I)asshown.

Skip to step 2.

• Installermustverifythatthesupportingsurfacewillsafelysupportthecombinedloadoftheequipmentandall

attachedhardwareandcomponents.

• Tightenwoodscrewssothatwallplateisrmlyattached,butdonotovertighten.Overtighteningcandamagethe

screws,greatlyreducingtheirholdingpower.

• Nevertighteninexcessof80in.•lb(9N.M.).

• Makesurethatmountingscrewsareanchoredintothecenterofthestud.Theuseofan"edgetoedge"studnder

ishighlyrecommended.

• Hardwareprovidedisforattachmentofmountthroughstandardthicknessdrywallorplasterintowoodstuds.Install-

ersareresponsibletoprovidehardwareforothertypesofmountingsituations.

WARNING

5 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

solid concrete

cinder block

Installation to Solid Concrete or Cinder Block

• WheninstallingPeerlesswallmountsoncinderblock,verifythatyouhaveaminimumof1-3/8"(35mm)ofactual

concretethicknessintheholetobeusedfortheconcreteanchors.Donotdrillintomortarjoints!Besuretomount

inasolidpartoftheblock,generally1"(25mm)minimumfromthesideoftheblock.CinderblockmustmeetASTM

C-90specications.Itissuggestedthatastandardelectricdrillonslowsettingisusedtodrilltheholeinsteadofa

hammerdrilltoavoidbreakingoutthebackoftheholewhenenteringavoidorcavity.

• Concretemustbe2000psidensityminimum.Lighterdensityconcretemaynotholdconcreteanchor.

• Makesurethatthewallwillsafelysupportfourtimesthecombinedloadoftheequipmentandallattachedhardware

and components.

WARNING

CUTAWAY VIEW

INCORRECT CORRECT

wall

plate

wall

plate

plaster/

drywall

plaster/

drywall

concrete concrete

Drillholesandinsertanchors(H).

Place plate (A)overanchors(H)andsecurewithscrews(I).

Tightenallfasteners.

concrete

surface

• Tightenscrewssothatwallplateisrmlyattached,

but do not overtighten.Overtighteningcandamage

screws,greatlyreducingtheirholdingpower.

• Nevertighteninexcessof80in.•lb(9N.M.).

• Alwaysattachconcreteexpansionanchorsdirectly

to load-bearing concrete.

• Neverattachconcreteexpansionanchorsto

concretecoveredwithplaster,drywall,orother

nishingmaterial.Ifmountingtoconcretesurfaces

coveredwithanishingsurfaceisunavoidable,

thenishingsurfacemustbecounterboredas

shownbelow.Besureconcreteanchorsdonot

pullawayfromconcretewhentighteningscrews.If

plaster/drywallisthickerthan5/8"(16mm),custom

fastenersmustbesuppliedbyinstaller.

WARNING

Makesurethatwallplate(A)islevel,useitasa

templatetomarkninemountingholes.Drillnine5/16"

(8mm)dia.holestoaminimumdepthof2.5"(64mm).

Insertanchors(H)inholesushwithwallasshownin

gure1.1.Placewallplateoveranchorsandsecure

withnine#14x2.5"screws(I).Level,thentightenall

fastenersasshowning.1.2.

Fig. 1.1

Fig. 1.2

6 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

Securetwosupporttubes(C) to tilt plate (B)usingfourM8x15mmphillipsscrews(F),four5/16splitwashers(J),

andfour5/16washers(K).

Securefourrectanglecaps(E) to support tubes (C)asshown.

Landscape Portrait

FJK

Securetwoadapterbrackets(D) to support tubes (C)usingeightM8x15mmphillipsscrews(F),eight5/16split

washers(J),andeight5/16washers(K)tocreatebracketassembly.

NOTE:Besurekeyholespointdown.

FJK

Keyhole

7 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

Tomakesurebracketassemblykeyholeareproperlyalignedwithstandoffs,positionbracketassembly

ontodisplaystandoffs.

Removebracketassemblyfrombackofdisplay.

Secure tilt plate (B)ofbracketassemblytowallplate(A)atdesiredtiltangleusingsixM8x15mmphillipsscrews

(F),six5/16splitwashers(J),andsix5/16washers(K).SecureoneM8x15mmphillipsscrews(F),5/16split

washer(J),and5/16washer(K)intoslotoftiltplate(B)asshowninDetail1.

Landscape Portrait

F,J, and K

0°

5°

10°

Slot

Display

MountingSurface

NotShownforClarity

Detail 1

8 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

Hookdisplaystandoffsintokeyholeslotsonadapterbrackets(D)ofbracketassembly.

NOTE:Makesurethatstandoffsrestatthebottomofkeyholeslotsasshownindetail2.

Securedisplaystandoffsinkeyholeusingtwolockbrackets(L)andM5x8mmphillipsscrews(G)

asshownindetail3.

Detail 2

Keyhole

DisplayStandoff

Detail 3

Display

MountingSurface

NotShownforClarity

Landscape

Portrait

Detail 2

Detail 3

MountingSurface

NotShownforClarity

Display

Keyhole

DisplayStandoff

Inhaltsverzeichnis

Andere PEERLESS Rack & Stand Handbücher

PEERLESS

PEERLESS MIS 213 Leitfaden

PEERLESS

PEERLESS RTPLA 50 Leitfaden

PEERLESS

PEERLESS A100IWBMOUNT Leitfaden

PEERLESS

PEERLESS Slimline OP-LWB 530 Leitfaden

PEERLESS

PEERLESS ACC951 Leitfaden

PEERLESS

PEERLESS WSP 716 Bedienungsanleitung

PEERLESS

PEERLESS PWMT300 Bedienungsanleitung

PEERLESS

PEERLESS HL4UN-002 Leitfaden

PEERLESS

PEERLESS SGLS01 Leitfaden

PEERLESS

PEERLESS Smartmount Leitfaden

PEERLESS

PEERLESS DS246 Leitfaden

PEERLESS

PEERLESS SmartMount ST 635 Leitfaden

PEERLESS

PEERLESS WSP700 Bedienungsanleitung

PEERLESS

PEERLESS SMARTMOUNT SCS221 Leitfaden

PEERLESS

PEERLESS WBK100-W Leitfaden

PEERLESS

PEERLESS A100IWBMOUNT Leitfaden

PEERLESS

PEERLESS MIS488 Leitfaden

PEERLESS

PEERLESS SmartMount SA750P Leitfaden

PEERLESS

PEERLESS Solid-Point PLCM 1 CP Leitfaden

PEERLESS

PEERLESS LWB375 Leitfaden

PEERLESS

PEERLESS COL 510P Leitfaden

PEERLESS

PEERLESS LDM233K Leitfaden

PEERLESS

PEERLESS LCT Series Leitfaden

PEERLESS

PEERLESS Vision Point LCFS 100 Leitfaden

Beliebte Rack & Stand Handbücher anderer Marken

Salamander

Salamander Acadia AC/W/L400/WH Bedienungsanleitung

Fohhn

Fohhn VAT-09 Benutzerhandbuch

ricoo

ricoo FS0522 Bedienungsanleitung

AMSOIL

AMSOIL BMK-22 Kurzanleitung

Kargo Master

Kargo Master 48220 Bedienungsanleitung

Milestone AV Technologies

Milestone AV Technologies SIMPLICITY SLF2 Bedienungsanleitung

ricoo

ricoo S1222 Bedienungsanleitung

Ready-Set-Mount

Ready-Set-Mount RSMCM602 Bedienungsanleitung

VidaBox

VidaBox VB MNT FFS2 Bedienungsanleitung

Welch Allyn

Welch Allyn 48960 Bedienungsanleitung

Arkon

Arkon CM035-ST-2 Bedienungsanleitung

PROEL

PROEL PLWIN60C Bedienungsanleitung

Agilent Technologies

Agilent Technologies E2609B Bedienungsanleitung

Mustang

Mustang MV-ARM4 Bedienungsanleitung

Mounting Solutions

Mounting Solutions WRM-320 Bedienungsanleitung

Pyle

Pyle PMKSPAD1 Bedienungsanleitung

ShelterIt

ShelterIt 21208 Bedienungsanleitung

SPL

SPL RackPack?4 1040 Bedienungsanleitung