Prorack K585 Bedienungsanleitung
K585
Fitting Kit
EN Fitting Instructions for Basic Carrier
x 4 x 4 x 4 x 4
x 1 x 1 x 2 x 4
Revision No: 7G 1
Fitting Kit K585
MAX kgs (lbs)
W/P WHD
Volkswagen
Amarok (Mexico), 4dr Truck 10-+ US 75 kgs (165 lbs) 75 kgs (165 lbs)
Amarok Double Cab, 4dr Ute 10-+ NZ 75 kgs (165 lbs) 75 kgs (165 lbs)
Amarok Double Cab, 4dr Ute 10-+ AU 75 kgs (165 lbs) 75 kgs (165 lbs)
Amarok Double Cab, 4dr Ute 10-+ EU 75 kgs (165 lbs) 75 kgs (165 lbs)
Amarok Double Cab, 4dr Ute 10-+ ZA 75 kgs (165 lbs) 75 kgs (165 lbs)
Amarok Double Cab, 4dr Ute 10-+ CN 75 kgs (165 lbs) 75 kgs (165 lbs)
Amarok Single Cab, 2dr Ute 10-+ EU 35 kgs (77 lbs) 35 kgs (77 lbs)
Amarok Single Cab, 2dr Ute 10-+ AU 35 kgs (77 lbs) 35 kgs (77 lbs)
Amarok Single Cab, 2dr Ute 10-+ ZA 35 kgs (77 lbs) 35 kgs (77 lbs)
2
Fitting Kit K585
X
A B C 1 2 3
Amarok (Mexico), 4dr Truck 10-+ (US) -270mm 500mm - 970mm 955mm -
-10 -5/8ths" 19 11/16ths" - 38 3/16ths" 37 5/8ths" -
Amarok Double Cab, 4dr Ute 10-+ (NZ) -270mm 500mm - 970mm 955mm -
-10 -5/8ths" 19 11/16ths" - 38 3/16ths" 37 5/8ths" -
Amarok Double Cab, 4dr Ute 10-+ (AU) -270mm 500mm - 970mm 955mm -
-10 -5/8ths" 19 11/16ths" - 38 3/16ths" 37 5/8ths" -
Amarok Double Cab, 4dr Ute 10-+ (EU) -270mm 500mm - 970mm 955mm -
-10 -5/8ths" 19 11/16ths" - 38 3/16ths" 37 5/8ths" -
Amarok Double Cab, 4dr Ute 10-+ (ZA) -270mm 500mm - 970mm 955mm -
-10 -5/8ths" 19 11/16ths" - 38 3/16ths" 37 5/8ths" -
Amarok Double Cab, 4dr Ute 10-+ (CN) -270mm 500mm - 970mm 955mm -
-10 -5/8ths" 19 11/16ths" - 38 3/16ths" 37 5/8ths" -
Amarok Single Cab, 2dr Ute 10-+ (EU) -270mm - - 960mm - -
-10 -5/8ths" - - 37 13/16ths" - -
Amarok Single Cab, 2dr Ute 10-+ (AU) -270mm - - 960mm - -
-10 -5/8ths" - - 37 13/16ths" - -
Amarok Single Cab, 2dr Ute 10-+ (ZA) -270mm - - 960mm - -
-10 -5/8ths" - - 37 13/16ths" - -
3
Fitting Kit EN
K585
First Time Installation
●Remove parts from inside the package and
check. Contact your dealer if any parts are
missing or damaged.
●This kit fits type A, B, C and D.
●These instructions show type A crossbar
fitted. They also apply to type B, C and D.
●Use keys to remove covers.
4
Fitting Kit EN
K585
●Use hex screwdriver to reverse adjusting
screw 10 turns.
●Press adjusting screw and pull crossbar
legs out. Refer to the crossbar instructions
for crossbar adjustment method.
●Ensure each end of the crossbar is
adjusted equally.
●Set bars to length (revert to rear of these
instructions).
●Please check the front of this manual for
information relating specifically to your
vehicle.
5
Fitting Kit EN
K585
●Tighten adjusting screw to 5 Nm (3.7 ft lb)
hand tight.
●Remove plastic clamp block by gripping bar
leg with fingers and push firmly with
thumbs until clamp block drops out behind
leg.
●Select plastic internal block (from fitting kit)
and insert into foot.
●Repeat for all legs.
6
Fitting Kit EN
K585
●Refer to the underside of the pad for the
part number.
●It is important to put the pads in the correct
position on the vehicle.
●Letters refer to the pad part numbers and
position.
●Pad Part Number:
A = 11-04-220
B = 11-04-224
C = 11-04-225
●Fit rubber pads (supplied with fitting kit) to
foot. Pad may vary in shape to that shown.
●Make sure the pad fits into the holes
underneath the foot.
7
Fitting Kit EN
K585
Fitment
●Open or remove fixed-point covers.
●Store items away in a safe place.
●Remove screws from the vehicle's fixed
points
●Remove rubber washer from screw and re-
install onto fixed point.
8
Fitting Kit EN
K585
●Assemble as shown.
●Ensure rubber sleeve is installed as far
onto the bolt as possible.
●Place crossbar foot over fixed-point mount.
●Ensure bolt engages with rubber washer
and fixed-point thread.
●Tighten the plastic knob.
9
Fitting Kit EN
K585
●Ensure the plastic knob is in the position
shown when fully tightened.
●Repeat for all four positions.
●Check crossbar is securely attached to the
vehicle.
●Use keys to fit and lock covers
CAUTION: Recheck all fasteners immediately after
a load is applied to the crossbars.
Regularly check screws are tight.
10
Andere Handbücher für K585
1
Inhaltsverzeichnis
Andere Prorack Autozubehör Handbücher
Prorack
Prorack K993 Bedienungs- und Installationshandbuch
Prorack
Prorack K473 Bedienungsanleitung
Prorack
Prorack K602 Bedienungsanleitung
Prorack
Prorack K448 Bedienungs- und Installationshandbuch
Prorack
Prorack J-Cradle Bedienungsanleitung
Prorack
Prorack K162 Bedienungsanleitung
Prorack
Prorack K781 Bedienungsanleitung
Prorack
Prorack K983 Bedienungsanleitung
Prorack
Prorack K949 Bedienungsanleitung
Prorack
Prorack K495 Bedienungsanleitung
Prorack
Prorack K124 Bedienungsanleitung
Prorack
Prorack K820 Bedienungsanleitung
Prorack
Prorack K890 Bedienungsanleitung
Prorack
Prorack K083 Bedienungsanleitung
Prorack
Prorack K877 Bedienungs- und Installationshandbuch
Prorack
Prorack K931 Bedienungsanleitung
Prorack
Prorack K646 Bedienungsanleitung
Prorack
Prorack K153 Bedienungsanleitung
Prorack
Prorack K758 Bedienungsanleitung
Prorack
Prorack Whispbar Q20 Bedienungsanleitung
