Razor XLR8R Bedienungsanleitung
©2002 Copyright Razor USA LLC. All rights reserved. Rev 7.15.02 RAH
Specifications subject to change without notice.
Photos by Arthur Cambridge.
Razor USA LLC
Cerritos, California 90703
www.razor.com
IMPORTANT NOTICES
The Razor electric scooter must reach a speed of three miles per hour before the motor
will engage.
Ride only on smooth hard and dry surfaces. The Razor was not intended for off-road or
hilly terrain. Use caution when approaching curbs, uneven pavement, potholes or
similar conditions. Avoid water. The tires are extremely slippery when wet. You could
lose traction and fall.
The Razor is designed for only one rider. Do not attempt to ride with more than one person
or attempt to tow anything behind your scooter.
Not recommended for children under 16 without adult supervision.
Maximum weight capacity on flat and level ground: 120 pounds.
WARNING: Intermittent motor operation is an indication of low charge. When this occurs,
turn the unit off and charge the battery.
Be sure to read and understand this manual thoroughly before operating your scooter.
Additional warnings enclosed.
To obtain service under this warranty you must, within the warranty period, contact Razor
USA LLC directly by e-mail at warranty@ razorusa.com. Razor will provide repair parts
and or replacement at its sole discretion. Authorized warranty service is ONLY available
from Razor USA LLC or its authorized Repair Center(s).
Owner’s Manual
+ Safety Handbook
The Razor electric scooter must reach a
speed of 3 miles per hour before the motor
will engage.
Read and understand this manual prior to use
Make sure the XLR8R battery is fully charged. DO NOT CHARGE
FOR MORE THAN 15 HOURS.
Make sure the XLR8R is properly installed. (See the Attaching the
XLR8R Motor to Your Scooter section in this manual).
Make sure the scooter is in good working condition and the rear-
wheel brake is functional.
Use only in accordance with local laws.
Never exceed the maximum weight of 120 pounds on a XLR8R-
powered scooter.
Never let more than one child at a time on a XLR8R-powered
scooter.
Never tow anything with a XLR8R-powered scooter.
Never apply pressure to the rear brake while the XLR8R motor is
engaged.
DO NOT use an XLR8R-powered scooter in wet, snowy, or icy
conditions.
Avoid spraying the XLR8R Motor with water to clean it. Moisture
inside the XLR8R case could cause electrical shorts and/or
corrosion to electrical components.
KEEP WHEELS FRESH, IF WORN OUT, REPLACE
IMMEDIATELY.
Worn wheels directly affect the performance of your drive system.
Attaching the XLR8R Motor to Your Scooter
Attaching the XLR8R Motor to your scooter involves two steps: (1)
installing the Mounting Bracket and (2) attaching the XLR8R
Motor to the Mounting bracket.
Installing the Mounting Bracket
To install the Mounting Bracket, Use only with Scooters without
shocks or suspension springs.
1. Slip the Mounting Bracket's fork slot onto the front of the
scooter's fork
Note: If your scooter has a strap ring on the leading edge of its
front fork, you should be able to see the ring through the small
window in the mounting bracket
Aligning the fork to the bracket
2. Using the screws and plate provided, securely fasten the
Mounting Bracket to the scooter's steering tube. Note that it is
helpful to alternately tighten each screw a little at a time so that
the plate is square with the bracket.
Installing the screws and tightening the clamps.
Attaching the XLR8R Motor
To attach the XLR8R Motor to the Mounting bracket,
1. Grasp the scooter's handle with one hand and the XLR8R's
handle in the other hand, and place one foot on the scooter's
deck.
3
2
2. Slip the peg slots, which are located on either side of the
XLR8R Motor, onto the mounting pegs, which are located on
either side of the mounting bracket.
Attaching the motor
3. Insert the handle hooks into the mounting slots and press the
handle downward until it comes in contact with the XLR8R Motor
housing.
4. Attach the Power Control to the scooter's handlebars by first
placing the steerer tube clip around the steering tube and then
sliding the Power Control up until the handlebar clip attaches onto
the handlebar. Then plug the power cord into the XLR8R Motor
cord. Make sure the plug is fully inserted. A partially inserted plug
may cause erratic operation.
5
4
Attaching the power control
Final connection of the wiring (right)
Charging the Battery
The XLR8R Motor comes with a 12V battery. The unit can be
charged on the scooter or it can be removed from the scooter
during the recharging process.
warranty and may damage the battery or cause a fire hazard. Do
not use the XLR8R charger to charge anything other than the
XLR8R battery. Stop using the charger if its wires become worn or
damaged in any way. Replace the charger with a new XLR8R
battery charger.
To operate the XLR8R motor
1. Turn the XLR8R's power switch to the On position.
2. Grasp the scooter's handlebars firmly.
3. Position one foot on the scooter's deck.
4. Pull the XLR8R trigger switch. DO NOT USE THE BRAKE
AND TRIGGER AT THE SAME TIME.
5. Using your other foot, give a strong push so as to propel the
scooter at a rate of 3 mph.
Note that the XLR8R motor will not engage until the scooter is
traveling 3 mph. This approach extends battery run time, prolongs
motor life, and enables children to learn to start off on a XLR8R
powered scooter more easily.
Note: If the XLR8R does not turn on,
1. Check to see that the battery is charged
2. Check to make sure the battery is connected inside the case.
3. Check to make sure the power switch is in the on position.
WARNING: Do not allow the XLR8R to “run on” if the drive
system slips on the wheel and forward speed has slowed or
stopped. Release the trigger before you come to a stop when
slowiing down. DO NOT USE THE BRAKE AT THE SAME TIME
AS THE TRIGGER.
7
6
Charger port and on/off switch
The battery must be fully charged before initial use.
Initial charging time on the XLR8R battery may be a few minutes
to up to 8 hours. Only charge the battery indoors in a dry location.
WARNING: The battery charger is not intended for use by
children. The XLR8R battery should always be charged by an
adult. Children should be kept away from the battery and charger
during the charging process. Only use XLR8R-brand battery
packs. Do not disassemble, incinerate or dispose of the battery in
fire. Dispose of used battery properly. There is a danger of
explosion if battery is incorrectly replaced. The battery may
present a risk of fire or chemical burn if mistreated.
CAUTION: Do not charge the XLR8R battery in wet
conditions. Only use the battery charger that accompanies your
XLR8R Motor. Use of any other charger voids the XLR8R
9
8
WARNING: Intermittent motor operation is an indication of
low charge. When this occurs, turn the unit off and charge the
battery.
Maintenance of Your XLR8R Motor
Your XLR8R Motor contains no user-serviceable parts. Never
attempt to service your XLR8R by yourself. Servicing or modifying
any of the XLR8R's internal components by yourself may damage
the XLR8R and will void your warranty. Service by anyone other
than the XLR8R service center will void the warranty agreement.
WARNING: Intermittent motor operation may be an
indication of low charge. When this occurs, turn the unit off and
charge the battery.
Removing the XLR8R
PUSH THE RELEASE BUTTON AS SHOWN IN THE PHOTO
BELOW TO RELEASE THE LATCH MECHANSIM. FAILURE
TO USE THE RELEASE BUTTON MAY DAMAGE THE LATCH.
LATCH DAMAGE DUE TO IMPROPER USE IS NOT
COVERED UNDER THE XLR8R WARRANTY.
Push button to release the lever (arrow)
XLR8R Motor Limited Warranty
General Terms
Commencing on the date of purchase, your XLR8R Motor has a
60-day (the "Warranty Period") Limited Warranty, which covers the
XLR8R against defects in materials, components, and
workmanship. This Limited Warranty applies only to the original
consumer and is not transferable to any other person. This
warranty gives you specific legal rights, and you may also have
other rights, which may vary from state to state.
Exclusive Remedies
This Limited Warranty is limited to the repair or replacement of any
components of the XLR8R Motor found to be defective within the
Warranty Period. Some states do not allow limits on how long an implied
warranty lasts so the above limit may not apply to you.
The manufacturer is not liable for incidental or consequential loss or
damage due directly or indirectly from the use of this product. Some
states do not allow exclusions or limitations of incidental or consequential
damages, so the above limitation or exclusion may not apply to you.
This Limited Warranty is the only warranty for your XLR8R Motor. No
other warranties exist that extend beyond the description on the face
hereof.
Limitations
The XLR8R Motor is designed for recreational use only. This warranty
does not cover ordinary wear and tear or maintenance. Any damage,
failure or loss caused by improper assembly, maintenance, use, or
storage of the XLR8R Motor by an party voids this Limited Warranty.
Failure to comply with the instructions and safety information in the
owner's manual voids this Warranty. Any evidence of consumer repair
voids this Warranty.
11
10
Warranty Service
If your XLR8R Motor requires service due to a defect in material or
workmanship during the Limited Warranty period, contact Razor USA via
If you require Warranty service, you will be responsible for paying for the
entire cost of shipping your XLR8R to the service center. You must
include within the package your name, address, daytime telephone
number, and a receipt showing the date of purchase.
SB 1918 (California) declaration:
YOUR INSURANCE POLICIES MAY NOT PROVIDE COVERAGE FOR ACCIDENTS
INVOLVING THE USE OF THIS SCOOTER. TO DETERMINE IF COVERAGE IS
PROVIDED, YOU SHOULD CONTACT YOUR INSURANCE COMPANY ORAGENT.
Inhaltsverzeichnis
Andere Razor Roller Handbücher
Razor
Razor E Prime Bedienungsanleitung
Razor
Razor Espark 13111290 Bedienungsanleitung
Razor
Razor E Prime Bedienungsanleitung
Razor
Razor TEKNO Bedienungsanleitung
Razor
Razor El Dorado Bedienungsanleitung
Razor
Razor Powerwing Black 20036060 Bedienungsanleitung
Razor
Razor pocket mad Bistro 15130638 Bedienungsanleitung
Razor
Razor PowerWing DLX Bedienungsanleitung
Razor
Razor deltawing Bedienungsanleitung
Razor
Razor E300 Series Bedienungsanleitung
Razor
Razor E100 series Bedienungsanleitung
Razor
Razor A5 AIR Bedienungsanleitung
Razor
Razor E300 Series Bedienungsanleitung
Razor
Razor eSpark Bedienungsanleitung
Razor
Razor Powerwing Bedienungsanleitung
Razor
Razor Sportmod Bedienungsanleitung
Razor
Razor E250A Bedienungsanleitung
Razor
Razor Ground force Drifter 25143400 Bedienungsanleitung
Razor
Razor Sport Model Bedienungsanleitung
Razor
Razor A5 DLX Bedienungsanleitung
Beliebte Roller Handbücher anderer Marken
First Choice Mobility
First Choice Mobility Roma Medical Corella S741 Bedienungsanleitung
Carrera
Carrera impel Bedienungsanleitung
Afikim
Afikim Superlight SL-3 Bedienungsanleitung
CareCo
CareCo ZOOM Bedienungsanleitung
Douglas
Douglas Vespa G.S. Bedienungsanleitung
Gazelle
Gazelle with BOSCH System Bedienungsanleitung