Scotsman ACM 85 Bedienungsanleitung

SERVICE MANUAL

ACM 85

AC 125

AC 175

AC 225

R 134 A / R 404 AVERSIONS

Electronic cubers

with storage

MS 1000.08 REV. 03/98

Table of contents page

Specifications ACM 85

Specifications AC 125

Specifications AC 175

Specifications AC 225

GENERAL INFORMATION AND INSTALLATION

Introduction

Unpacking and Inspection

Location and levelling

Electrical connections

Water supply and drain connections

Final check list

Installation practice

OPERATING INSTRUCTIONS

Start up

Operational checks

OPERATING PRINCIPLES (How it works)

Freezing cycle

Harvest cycle

Control sequence

Component description

ADJUSTMENT, REMOVAL AND REPLACEMENT PROCEDURES

Adjustment of the cube size

Replacement of evaporator temperature sensor

Replacement of condenser temperature sensor

Replacement of ambient temperature sensor

Replacement of ice level light control

Replacement of P.C. Board

Replacement of the water pump (ACM 85)

Replacement of the water pump (AC 125 & AC 175 )

Replacement of the water pump (AC 225)

Replacement of water inlet solenoid valve

Replacement of hot gas valve coil

Replacement of water drain solenoid valve

Replacement of fan motor

Replacement of plastic curtain (ACM 85 & AC 125-175)

Replacement of spray platform and chute (ACM 85 & AC 125-175)

Replacement of spray bar (AC 225)

Replacement of drier

Replacement of hot gas valve body

Replacement of evaporator platen

Replacement of air cooled condenser

Replacement of water cooled condenser

Replacement of water regulating valve (water cooled models)

Replacement of compressor

Wiring diagram (ACM 85)

Wiring diagram (AC 125-175 & AC 225)

Service diagnosis

MAINTENANCE AND CLEANING INSTRUCTIONS

General

Icemaker

Cleaning instructions of water system

Page 01

TABLE

OF CONTENTS

SPECIFICATIONS

ELECTRONIC CUBER MODEL ACM 85

Important operating requirements:

MIN MAX

Air temperature 10°C (50°F) 40°C (100°¯F)

Water temperature 5°C (40°F) 40°C (100°F)

Water pressure 1 bar (14 psi) 5 bar (70 psi)

Electr. voltage

variations from

voltage rating

specified on

nameplate -10% +10%

ice making capacity

NOTE.

With the unit in “built-in” conditions, the ice production is gradually reduced in respect to the

levels shown in the graf, up to a maximum of 10% at room temperatures higher than 32

The daily ice-making capacity is directly related to the condenser air inlet temperature, water

temperature and age of the machine.

To keep your SCOTSMAN CUBER at peak performance levels, periodic maintenance checks

must be carried out as indicated on page 38 of this manual.

Page 02

Kg.

32 °C

AIR COOLED MODELS

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

Kg.

°C

WATER COOLED MODELS

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

27 21 15 10 32 27 21 15 10

Basic electr. Amps. Start Amps Watts No of Wires Amp. Fuse

Page 03

SPECIFICATIONS (CONT'D)

Electr. power cons.

Kwh per 24 Hrs

230/50/1 3.2 17 500 10 3 x 1 m/m 10

Cubes per harvest: 24 medium

* At 15°C (60°F) water temperature

ACM 85 - CUBER MACHINE SPECIFICATION

Model Cond. Finish Comp. HP Ice bin cap. Water requirem

Kgs. LTx24 HR

ACM 85 AS Air S/Steel 140*

3/8 14

ACM 85 WS Water S/Steel 380*

FRONT VIEW

HEIGHT (without legs) 790 mm.

HEIGHT (with legs) 930 mm.

WIDTH 457 mm.

DEPTH 523 mm.

WEIGHT 44 Kgs.

SPECIFICATIONS

ELECTRONIC CUBER MODEL AC 125

Important operating requirements:

MIN MAX

Air temperature 10°C (50°F) 40°C (100°¯F)

Water temperature 5°C (40°F) 40°C (100°F)

Water pressure 1 bar (14 psi) 5 bar (70 psi)

Electr. voltage

variations from

voltage rating

specified on

nameplate -10% +10%

ice making capacity

NOTE.

With the unit in “built-in” conditions, the ice production is gradually reduced in respect to the

levels shown in the graf, up to a maximum of 10% at room temperatures higher than 32

The daily ice-making capacity is directly related to the condenser air inlet temperature, water

temperature and age of the machine.

To keep your SCOTSMAN CUBER at peak performance levels, periodic maintenance checks

must be carried out as indicated on page 38 of this manual.

Production charts shown indicate the production of ACM models; ice production of ACL and

ACS models is 10% lower.

Page 04

Kg.

32 °C27 21 15 10

AIR COOLED MODELS

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

Kg.

°C

WATER COOLED MODELS

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

10 21

32 27 21 15 10

Basic electr. Amps. Start Amps Watts No of Wires Amp. Fuse

Page 05

SPECIFICATIONS (CONT'D)

Electr. power cons.

Kwh per 24 Hrs

230/50/1 3.8 20 670 13 3 x 1 m/m 10

Cubes per harvest: 36 large / 48 medium / 84 small

* At 15°C (60°F) water temperature

Ice bin cap. Water requirem

Kgs. LTx24 HR

AC 125 AS Air S/Steel 160*

1/2 28

AC 125 WS Water S/Steel 680*

AC 125 - CUBER MACHINE SPECIFICATIONS

Model Cond. Finish Comp. HP

FRONT VIEW

HEIGHT (without legs) 900 mm.

HEIGHT (with legs) 1020 mm.

WIDTH 675 mm.

DEPTH 520 mm.

WEIGHT 75 Kgs.

SPECIFICATIONS

ELECTRONIC CUBER MODEL AC 175

Important operating requirements:

MIN MAX

Air temperature 10°C (50°F) 40°C (100°¯F)

Water temperature 5°C (40°F) 40°C (100°F)

Water pressure 1 bar (14 psi) 5 bar (70 psi)

Electr. voltage

variations from

voltage rating

specified on

nameplate -10% +10%

ice making capacity

NOTE.

With the unit in “built-in” conditions, the ice production is gradually reduced in respect to the

levels shown in the graf, up to a maximum of 10% at room temperatures higher than 32

The daily ice-making capacity is directly related to the condenser air inlet temperature, water

temperature and age of the machine.

To keep your SCOTSMAN CUBER at peak performance levels, periodic maintenance checks

must be carried out as indicated on page 38 of this manual.

Production charts shown indicate the production of ACM models; ice production of ACL and

ACS models is 10% lower.

Page 06

87,5

Kg.

32 10 °C

AIR COOLED MODELS

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

WATER COOLED MODELS

27 21 15

82,5

77,5

72,5

67,5

62,5

57,5

87,5

Kg.

32 10 °C

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

27 21 15

82,5

77,5

72,5

67,5

92,5

Basic electr. Amps. Start Amps Watts No of Wires Amp. Fuse

SPECIFICATIONS (CONT'D)

Electr. power cons.

Kwh per 24 Hrs

230/50/1 5.3 29 850 18 3 x 1 m/m 16

Cubes per harvest: 36 large / 48 medium

* At 15°C (60°F) water temperature

Ice bin cap. Water requirem

Kgs. LTx24 HR

AC 175 AS Air S/Steel 0160*

3/4 28

AC 175 WS Water S/Steel 1000*

AC 175 - CUBER MACHINE SPECIFICATIONS

Model Cond. Finish Comp. HP

FRONT VIEW

HEIGHT (without legs) 900 mm.

HEIGHT (with legs) 1020 mm.

WIDTH 675 mm.

DEPTH 520 mm.

WEIGHT 75 Kgs.

Page 07

SPECIFICATIONS

ELECTRONIC CUBER MODEL AC 225

Important operating requirements:

MIN MAX

Air temperature 10°C (50°F) 40°C (100°¯F)

Water temperature 5°C (40°F) 40°C (100°F)

Water pressure 1 bar (14 psi) 5 bar (70 psi)

Electr. voltage

variations from

voltage rating

specified on

nameplate -10% +10%

ice making capacity

NOTE.

With the unit in “built-in” conditions, the ice production is gradually reduced in respect to the

levels shown in the graf, up to a maximum of 10% at room temperatures higher than 32

The daily ice-making capacity is directly related to the condenser air inlet temperature, water

temperature and age of the machine.

To keep your SCOTSMAN CUBER at peak performance levels, periodic maintenance checks

must be carried out as indicated on page 38 of this manual.

Production charts shown indicate the production of ACM models; ice production of ACL and

ACS models is 10% lower.

Page 08

150

145

140

135

130

125

120

115

110

105

100

Kg.

32 °C

AIR COOLED MODELS

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

WATER COOLED MODELS

27 21 15 10

160

155

150

145

140

135

130

125

120

115

110

105

100

Kg.

32 °C

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

27 21 15 10

Basic electr. Amps. Start Amps Watts No of Wires Amp. Fuse

Page 09

SPECIFICATIONS (CONT'D)

Electr. power cons.

Kwh per 24 Hrs

230/50/1 5.3 29 1100 22 3 x 1.5 m/m 16

Cubes per harvest: 72 large / 102 medium / 198 small.

* At 15°C (60°F) water temperature

FRONT VIEW

HEIGHT (without legs) 1006 mm.

HEIGHT (with legs) 1126 mm.

WIDTH 1078 mm.

DEPTH 660 mm.

WEIGHT 115 Kgs.

AC 225 - CUBER MACHINE SPECIFICATIONS

Model Cond. Finish Comp. HP Ice bin cap. Water requirem

Kgs. LTx24 HR

AC 225 AS Air S/Steel 0250*

170

AC 225 WS Water S/Steel 1500*

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Scotsman Eiswürfelbereiter Handbücher

Scotsman

Scotsman BC0530 Bedienungsanleitung

Scotsman

Scotsman FDE474 Bedienungsanleitung

Scotsman

Scotsman NDE550 Bedienungsanleitung

Scotsman

Scotsman NME1250 Bedienungsanleitung

Scotsman

Scotsman SCE275 Bedienungsanleitung

Scotsman

Scotsman DICE NU Series Bedienungsanleitung

Scotsman

Scotsman SLE300 Bedienungsanleitung

Scotsman

Scotsman NH2030 Bedienungsanleitung

Scotsman

Scotsman CME1056 Bedienungsanleitung

Scotsman

Scotsman HID Service-Handbuch

Scotsman

Scotsman DC33 Bedienungsanleitung

Scotsman

Scotsman MC 45 Bedienungsanleitung

Scotsman

Scotsman SCCG30 Bedienungsanleitung

Scotsman

Scotsman EC 106 Bedienungsanleitung

Scotsman

Scotsman HD356 Bedienungsanleitung

Scotsman

Scotsman SCN60 Bedienungsanleitung

Scotsman

Scotsman Enodis DCE33 Installationsanleitung

Scotsman

Scotsman AC 125 Konfigurationshandbuch

Scotsman

Scotsman HID312 Bedienungsanleitung

Scotsman

Scotsman SLC300 Bedienungsanleitung

Scotsman

Scotsman Air and Water Cooled C1448 Bedienungsanleitung

Scotsman

Scotsman NM650 Bedienungsanleitung

Scotsman

Scotsman NH0422 Bedienungsanleitung

Scotsman

Scotsman CME1386 Bedienungsanleitung

Beliebte Eiswürfelbereiter Handbücher anderer Marken

Hoshizaki

Hoshizaki KMD-460MWJ Bedienungsanleitung

Sub-Zero

Sub-Zero 315I Gebrauchsanweisung

Unold

Unold 48945 Bedienungsanleitung

Kenmore

Kenmore 2217402A Bedienungsanleitung

Cornelius

Cornelius WM600 Betriebsanleitung

GE XPIO43SCSS Bedienungsanleitung

Hoshizaki

Hoshizaki KMD-901MAH Bedienungsanleitung

Whynter

Whynter FIM-450HA Bedienungsanleitung

U-Line

U-Line UMCR014-SC01A Installationshandbuch

Andrew James

Andrew James AJ000522 Bedienungsanleitung

Kärcher

Kärcher IP 120 Bedienungsanleitung

U-Line

U-Line SS1095 Bedienungsanleitung

Maytag

Maytag MIM1554WRS - Ice Maker Bedienungsanleitung

Hoshizaki

Hoshizaki KM-630MAH Bedienungsanleitung

Princess

Princess Yonanas Bedienungsanleitung

Unold

Unold 48946 Bedienungsanleitung

Electrolux

Electrolux E15IM60GP Bedienungsanleitung

Cornelius

Cornelius UC150 ICE ONLY Bedienungsanleitung