SportsPlay 511-102 Bedienungsanleitung

511-102 Stall Bar Fence Page 1

Rev 05/29/2020

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

www.sportsplayinc.com

IMPORTANT

PLEASE READ THESE INSTRUCTIONS BEFORE COMMENCING ASSEMBLY. All equipment must be

installed in accordance with these instructions. Check your shipment against Bill of

Lading and Parts list. Any missing or broken parts must be reported to your distributor

within 10 days of receipt of your order. When properly installed and maintained,

equipment will give many years of Safe, Trouble-Free use. Periodically check for loose

or broken parts. Loose bolts must be tightened and broken parts must be replaced as they

can possibly create dangerous situations leading to unnecessary accidents. Resilient

Surfacing should be used under all playground equipment. Appropriate publications,

available at no charge, from the Consumer Product Safety Commission, include “A Handbook

for Public Playground Safety”. You can receive your free copy by calling 1-301-504-7908.

PACKING LIST HARDWARE BAG

1 CTN - 1 Hardware Bag 18 - 196-802 ½” x ½’ Socket Set Screw

1 PIPE - 1 123-608 Post 1 7/8” OD x 6’ Long 1 - 416-400 ¼” Socket Key

2 PIPE - 2 103-669 Pole 1 - 805-532 Warning Label

1 BDL 1 503-210 Turning Bar 1 - 805-534 SportsPlay Label

1 503-211 Turning Bar 1 - Maintenance Checklist

1 503-203 Turning Bar

1 BDL 6 503-203 Turning Bar

1 CTN 2 BDL 3 PIPE 6 TOTAL PCS WT 100# CLASS 70

511-102 Stall Bar Fence Page 2

Rev 0/21/2008

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

www.sportsplayinc.com

GENERAL USE/FALL ZONE & FOOTING RECOMMENDATIONS

Use/Fall Zones should extend a minimum of 6 Feet in All Directions from the Perimeter of

the Equipment Ground Space. This are should be covered with the required amount of

Resilient Safety Surfacing Material. For Some Equipment Use/Fall Zone can overlap. See

Consumer Product Safety Commission Guidelines.

Diameter and Depth of Footing Illustrated are Satisfactory in Most Applications for pipe

sizes Up to 2-3/8” Diameter. Varying Soil and Climatic conditions may require Deeper and

Heavier Footings in Some Areas. Check Local Building Codes.

DETAIL: Permanent Installation Suggested Bracing Method

* If resilient surfacing is to be less than 12”, then additional pipe should be put in

concrete to maintain proper finish grade for equipment.

FOOTING LAYOUT AND USE AREA

511-102 Stall Bar Fence Page 3

Rev 08/21/2008

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

www.sportsplayinc.com

GENERAL ASSEMBLY INSTRUCTIONS

Check all the parts and hardware with the packing list to be sure you have received

everything needed to assemble this product. CONTACT YOUR LOCAL DISTRIBUTOR NOTIFICATION

OF ANY MISSING OR DAMAGED PARTS. Contact must be made within ten days of receipt of your

order.

Only hand-tighten nuts & bolts on initial assembly. Final tightening should be done

EVENLY after final assembly when unit has been plumbed & leveled.

After assembly is complete, ANY ENDS OF BOLTS PROTRUDING BEYOND NUTS SHOULD BE CUT OFF

AND/OR PEENED OVER TO REMOVE ANY SHARP PROJECTIONS. Go over entire unit to file smooth

any sharp edges or projections that may have been caused by rough handling in shipping or

installation.

GENERAL MAINTENANCE INSTRUCTIONS

Check MONTHLY for loose bolts, damaged or broken parts. Tighten and/or replace

immediately.

SPECIFIC ASSEMBLY INSTRUCTIONS

NOTE: All threaded ends of bolts protruding beyond nuts must be cut off and/or

peened to eliminate sharp edges. No more than two threads should extend

beyond face of nut. All washers, “T” nuts, and other fastener hardware used

on round pipe or tubing must be hammered down to conform to the curved

underlying surface to eliminate catch points.

STEP #1: Mark & dig footing holes per Diagram on PAGE #2.

STEP #2: Align & position all Turning Bars per the dimensions & location on Page 1.

Position & brace in footing holes. Attach braces to legs to hold proper

height. Length of pipe legs below intended level of resilient surfacing

should be 24”. Two long braces holding 2 legs each are recommended.

STEP #3: Plumb & level. Tighten all nuts & bolts so that lock washers are flat.

Pour concrete. Let stand 48 hours before removing braces, installing

resilient surfacing and using equipment.

STEP #4: Attach Warning Label and Manufacturer’s Identification Label to a clean

surface. The labels should be attached in a location where they are clearly

visible and legible and away from normal hand and foot placement areas. The

labels must be replaced if they become illegible, destroyed or removed.

Contact your distributor for replacement labels.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere SportsPlay Spielgeräte und Spielplatzausstattung Handbücher

SportsPlay

SportsPlay 581-638M Bedienungsanleitung

SportsPlay

SportsPlay 581-438H Bedienungsanleitung

SportsPlay

SportsPlay 581-638H Bedienungsanleitung

SportsPlay

SportsPlay 581-240HD Bedienungsanleitung

SportsPlay

SportsPlay 902-706 Gebrauchsanweisung

SportsPlay

SportsPlay Value Series Bedienungsanleitung

SportsPlay

SportsPlay 581-440HD Bedienungsanleitung

SportsPlay

SportsPlay 301-147 Bedienungsanleitung

SportsPlay

SportsPlay 581-630M Bedienungsanleitung

SportsPlay

SportsPlay 581-830-8F Bedienungsanleitung

SportsPlay

SportsPlay 581-638F Bedienungsanleitung

SportsPlay

SportsPlay SUPER SLIDE Bedienungsanleitung

SportsPlay

SportsPlay Zack 911-131 Bedienungsanleitung

SportsPlay

SportsPlay Mega Series Bedienungsanleitung

SportsPlay

SportsPlay 511-115 Bedienungsanleitung

SportsPlay

SportsPlay 581-630-8M Bedienungsanleitung

SportsPlay

SportsPlay 581-643H Bedienungsanleitung

SportsPlay

SportsPlay Ray 911-110 Bedienungsanleitung

SportsPlay

SportsPlay 581-442HD Bedienungsanleitung

SportsPlay

SportsPlay 511-152 Bedienungsanleitung

SportsPlay

SportsPlay Seth Mega Installations- und Betriebshandbuch

SportsPlay

SportsPlay Vault Bar Bedienungsanleitung

SportsPlay

SportsPlay 601-695S Bedienungsanleitung

SportsPlay

SportsPlay 902-293 6' IND. SECTIONAL SLIDE Bedienungsanleitung

Beliebte Spielgeräte und Spielplatzausstattung Handbücher anderer Marken

FUNormous

FUNormous Disney Junior MICKEY MOUSE Bedienungsanleitung

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Bedienungsanleitung

PoolMaster

PoolMaster 72775 Bedienungsanleitung

Palmako

Palmako 4743142009857 Installationshandbuch

BOERPLAY

BOERPLAY PSTE000.019 Bedienungsanleitung

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Benutzerhandbuch

stilum

stilum Erika Bedienungsanleitung

Costway

Costway NP10816 Bedienungsanleitung

Trigano

Trigano VABI Bedienungsanleitung

Outward

Outward OUT116 Bedienungsanleitung

GALOPIN

GALOPIN ARC02 Bedienungsanleitung

stilum

stilum levis Technische Daten

Ledon

Ledon BASIC Bai LB012 Bedienungsanleitung

BOERPLAY

BOERPLAY PSTE115.002 Bedienungsanleitung

Europlay

Europlay S306 Programmierhandbuch

SportsPlay Equipment

SportsPlay Equipment 361-509H Bedienungsanleitung

Ledon

Ledon 302250 Bedienungsanleitung

Costway

Costway NP10441 Bedienungsanleitung