SportsPlay 511-115 Bedienungsanleitung

511-115 Chain Ring Ladder Page 1 of 1

Rev 04/07/03

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

* IMPORTANT *

PLEASE RETAIN THIS INSTRUCTION SHEET IN YOUR FILES. IT CONTAINS IMPORTANT REPLACEMENT

PARTS INFORMATION. ALL EQUIPMENT SHOULD BE INSTALLED IN ACCORDANCE WITH THESE

INSTRUCTIONS.

IT IS IMPORTANT TO USE AND MAINTAIN ALL PUBLIC PLAYGROUND EQUIPMENT PROPERLY. PLAYGROUND

EQUIPMENT, WHICH IS IMPROPERLY MAINTAINED, CAN CAUSE SERIOUS INJURY. PERIODICAL

INSPECTIONS, MAINTENANCE, REPAIR AND/OR REPLACEMENT OF DAMAGED PARTS IS NECESSARY FOR

SAFE OPERATION OF EQUIPMENT AND SAFETY OF USERS. RESILIENT SURFACING SHOULD BE USED

UNDER ALL PLAYGROUND EQUIPMENT. APPROPRIATE PUBLICATIONS, AVAILABLE AT NO CHARGE, FROM

THE CONSUMER PRODUCT SAFETY COMMISSION, INCLUDE “A HANDBOOK FOR PUBLIC PLAYGROUND

SAFETY.” YOU CAN RECEIVE YOUR FREE COPY BY CALLING 1-301-504-7908.

PACKING LIST HARDWARE BAG

1 CTN 1 Hardware Bag 8 196-86 ½” x ¾” Socket Set Screw

4 513-203 Ring & Chain Assy 1 416-400 Socket Key

1 BDL 2 513-202 Net Bars 1 805-532 Warning Label

1 WF 1 513-505 End Fitting 1 805-534 SportsPlay Label

1 WF 1 513-505 End Fitting 1 Maintenance Checklist

2 BDL 2 513-618 Legs

1 CTN 3 BDL 2 WF 6 TOTAL PCS WT 225# CLASS 70

511-115 Chain Ring Ladder Page 2 of 2

Rev 04/07/03

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

GENERAL USE/FALL ZONE & FOOTING RECOMMENDATIONS

STATIONARY & PORTABLE EQUIPMENT – USE/FALL ZONES SHOULD EXTEND A MINIMUM OF 6 FEET IN ALL

DIRECTIONS FROM THE PERIMETER OF THE EQUIPMENT GROUND SPACE. THIS AREA SHOULD BE COVERED

WITH THE REQUIRED AMOUNT OF RESILIENT SAFETY SURFACING MATERIAL. FOR SOME EQUIPMENT –

USE/FALL ZONES CAN OVERLAP. SEE CONSUMER PRODUCT SAFETY COMMISSION GUIDELINES.

DIAMETER & DEPTH OF FOOTING ILLUSTRATED ARE SATISFACTORY IN MOST APPLICATIONS FOR PIPE

SIZES UP TO 2 3/8” DIAMETER. VARYING SOIL & CLIMATIC CONDITIONS MAY REQUIRE DEEPER &

HEAVIER FOOTINGS IN SOME AREAS. CHECK LOCAL BUILDING CODES.

* If resilient surfacing is to be less than 12”, then additional pipe should be put in

concrete to maintain proper finish grade for equipment.

511-115 Chain Ring Ladder Page 3 of 3

Rev 04/07/03

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

GENERAL ASSEMBLY INSTRUCTIONS:

Check all the parts and hardware with the packing list to be sure you have received

everything needed to assemble this product. CONTACT YOUR LOCAL DISTRIBUTOR NOTIFICATION

OF ANY MISSING OR DAMAGED PARTS. Contact must be made within ten days of receipt of your

order.

Only hand-tighten nuts & bolts on initial assembly. Final tightening should be done

EVENLY after final assembly when unit has been plumbed & leveled.

After assembly is complete, ANY ENDS OF BOLTS PROTRUDING BEYOND NUTS SHOULD BE CUT OFF

AND/OR PEENED OVER TO REMOVE ANY SHARP EDGES. Go over entire unit to file smooth any

sharp edges or projections that may have been caused by rough handling in shipping or

installation. T-Clamps are designed for both one and two bolt connections. In many

situations only one bolt is required. See specific assembly instructions.

On products with platforms install 1 – 2 degrees off level to facilitate water drainage.

GENERAL MAINTENANCE INSTRUCTIONS:

Check MONTHLY for loose bolts, damaged or broken parts. Tighten and/or replace

immediately.

SPECIFIC ASSEMBLY INSTRUCTIONS:

NOTE: All threaded ends of bolts protruding beyond nuts must be cut off and/or

peened to eliminate sharp edges. No more than two threads should extend

beyond face of nut.

All washers, “T” nuts, and other fastener hardware used on round pipe or

tubing must be hammered down to conform to the curved underlying surface to

eliminate catch points.

STEP #1: Mark & dig footing holes per SKETCH on PAGE #2.

STEP #2: Assemble frame on ground using eight ½” x ¾” Socket Set Screws

STEP #3: Stand Frame upright onto legs and brace in Footing Holes so that 24” of pipe

will be under intended level of resilient surfacing.

NOTE: When installed as shown, the distance from the bottom of the rings to

the surface will be approximately 78”. You may wish to adjust this distance

depending on the age group using the equipment. Do this by lowering or

raising the legs in the footing holes. Maximum height from surface to

bottom rings per CPSC is 84”.

STEP #4: Attach Ring & Chain Assemblies. Close S-Hooks to within .034” (1/32”) using

S-Hook pliers or Hammer.

STEP #5: Plumb and level unit. Pour concrete. Wait 48 hours before removing braces,

applying resilient surfacing and or equipment.

STEP #6: Attach Warning Label and Manufacturer’s Identification Label to a clean

surface. The labels should be attached in a location where they are clearly

visible and legibl3e and away from normal hand and foot placement areas.

The labels must be replaced if they become illegible, destroyed or removed.

Contact your distributor for replacement labels.

Inhaltsverzeichnis

Andere SportsPlay Spielgeräte und Spielplatzausstattung Handbücher

SportsPlay

SportsPlay 581-438H Bedienungsanleitung

SportsPlay

SportsPlay 581-630M Bedienungsanleitung

SportsPlay

SportsPlay 581-638H Bedienungsanleitung

SportsPlay

SportsPlay 511-111 Bedienungsanleitung

SportsPlay

SportsPlay 382-404H Bedienungsanleitung

SportsPlay

SportsPlay 511-102 Bedienungsanleitung

SportsPlay

SportsPlay MODERN BIPOD ADA SWING Bedienungsanleitung

SportsPlay

SportsPlay 581-638M Bedienungsanleitung

SportsPlay

SportsPlay 902-290 Bedienungsanleitung

SportsPlay

SportsPlay 511-109 Bedienungsanleitung

SportsPlay

SportsPlay Seth Mega Installations- und Betriebshandbuch

SportsPlay

SportsPlay 511-107 Bedienungsanleitung

SportsPlay

SportsPlay 581-230-8F Bedienungsanleitung

SportsPlay

SportsPlay 301-147 Bedienungsanleitung

SportsPlay

SportsPlay 902-289 Bedienungsanleitung

SportsPlay

SportsPlay 581-830-8F Bedienungsanleitung

SportsPlay

SportsPlay 581-630F Bedienungsanleitung

SportsPlay

SportsPlay Mega Series Bedienungsanleitung

SportsPlay

SportsPlay HERCULES CLIMBER VII Bedienungsanleitung

SportsPlay

SportsPlay 581-838H Bedienungsanleitung

SportsPlay

SportsPlay Zack 911-131 Bedienungsanleitung

SportsPlay

SportsPlay 601-695S Bedienungsanleitung

SportsPlay

SportsPlay 581-842HD Bedienungsanleitung

SportsPlay

SportsPlay Miss Abby Installations- und Betriebshandbuch

Beliebte Spielgeräte und Spielplatzausstattung Handbücher anderer Marken

FUNormous

FUNormous Disney Junior MICKEY MOUSE Bedienungsanleitung

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Bedienungsanleitung

PoolMaster

PoolMaster 72775 Bedienungsanleitung

Palmako

Palmako 4743142009857 Installationshandbuch

BOERPLAY

BOERPLAY PSTE000.019 Bedienungsanleitung

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Benutzerhandbuch

stilum

stilum Erika Bedienungsanleitung

Costway

Costway NP10816 Bedienungsanleitung

Trigano

Trigano VABI Bedienungsanleitung

Outward

Outward OUT116 Bedienungsanleitung

GALOPIN

GALOPIN ARC02 Bedienungsanleitung

stilum

stilum levis Technische Daten

Ledon

Ledon BASIC Bai LB012 Bedienungsanleitung

BOERPLAY

BOERPLAY PSTE115.002 Bedienungsanleitung

Europlay

Europlay S306 Programmierhandbuch

SportsPlay Equipment

SportsPlay Equipment 361-509H Bedienungsanleitung

Ledon

Ledon 302250 Bedienungsanleitung

Costway

Costway NP10441 Bedienungsanleitung