Sunjoy L-GZ604PCO-C3 Bedienungsanleitung

www.sunjoydirect.com

1-866-578-6569

MONDAY-FRIDAY 11:30 AM TO 8:30 PM PACIFIC STANDARD TIME

MONDAY-FRIDAY 8:30 AM TO 5:30 PM EASTERN STANDARD TIME

SUNJOY INDUSTRIES GROUP LIMITED

619 Slack Street

Steubenville, Ohio 43952 USA

ASSEMBLY INSTRUCTIONS

ITEM# L-GZ604PCO-C3

SKU# 125626

THIS UNIT IS HEAVY!

NEWPORT GAZEBO 10’x12’

WARNING:

In order to reduce the risk of personal injury and damage to equipment, basic safety precautions should

always be followed when assembling and using this product. Read all instructions carefully before assembly

and use.

All you will need is a screwdriver, a hammer and two ladders.

NOTE: DO NOT ASSEMBLE THIS ITEM ALONE FOR SAFETY.

DO NOT REMOVE THE PROTECTIVE FILM ON THE POLYCARBONATE ROOF PANELS UNTIL

INSTALLATION (STEP 15). MAKE SURE TO PUT THE UV PROTECTED SIDE FACING UP. IT IS

A VERY IMPORTANT PROCEDURE, IF NOT FOLLOWED AS DESCRIBED, YOUR ROOF WILL

NOT BE COVERED BY THE GUARANTY.

IMPORTANT:

1. Keep all children and pets away from assembly area. Children and pets should be supervised when they

are in the area of gazebo construction.

2. The area for assembly should not be less than 6 feet from any obstruction such as fence, garage, house,

overhanging branches, laundry line or electrical wires.

3. This unit is heavy. Do not assemble this item alone. Four people are recommended for safe assembly.

4. Some parts may contain sharp edges. Wear protective gloves if necessary during assembly.

5. When assembling and using this product, basic safety precautions should always be followed to reduce the

risk of personal injury and damage to equipment. Please read all instructions before assembly and use.

6. For outdoor use only. Install on level ground. Stakes are provided to secure the gazebo in grass ground. If

you wish to secure the gazebo to a wood deck or concrete surface, you will need to purchase fasteners

appropriate for these surfaces. These are readily available at your local hardware store or home center.

7. Check all bolts for tightness before and during usage.

8. Please check your state and local regulations prior to purchasing. Some jurisdictions may require permits

for, or otherwise regulate, installation and use.

9. In areas subject to frequent severe weather, securing the gazebo to a deck, concrete patio or footings is

recommended.

10. Removal of accumulated snow on the gazebo roof with a roof rake is recommended. In areas that are

regularly subject to blizzard conditions however, removal of the roof panel is suggested. The assembled roof

structure can simply be left in tact until warmer conditions return.

USE & CARE:

1. This Gazebo is not a permanent structure and should be disassembled & stored away after use.

2. Do not repack your gazebo until completely dry.

3. This Gazebo must not be left erect in windy conditions.

WARNINGS:

1. Assembly Instructions must be followed.

2. Pegs supplied must be used to hold this gazebo in place when upright.

Post A 4

Base cover B 4

Base C 4

Triangle support D 8

Decorative slot 1 E1 2



Decorative slot 2 E2 2



Decorative slot 3 E3 2



Parts List

Decorative slot 4 E4 2



Corner Support F 4

F shape panel 1 G1 4

F shape panel 2 G2 4

F shape panel 3 G3 2

Slot 1 H1 4

Slot 2 H2 4

Slot 3 H3 2

Slanting Bar Connector I1 4

Bean Connector I2 6

Top Bar J1 6

Top Slanting Bar J2 4

Upside left PC top K1 4

Upside right PC top K2 4

Bottom left PC top K3 4

Bottom right PC top K4 4

Middle PC top K5 4

Upside top roof L1 1

AA M6X15 Bolt 64PCS

BB M6 Washer 82PCS

CC M6X15 Bolt 18PCS

WW M6 Wrench 2PCS

Hardware Pack 1

Bottom top roof L2 1

Cover 1 M1 4

Cover 2 M2 6

Hook N 1

Long mosquito netting

pipe O1 4

Short mosquito netting

pipe O2 4

Mosquito netting P 1

Fig.1: Insert decorative slot (E1 & E3) into decorative slot (E2 & E4), tighten by bolt (AA) and washer (BB).

Fig.2: Attach Bean Connector (I2) to the middle of decorative slot 3 (E3) and decorative slot 4 (E4) by bolt (AA)

and washer (BB).

Fig.2-1: Attach Bean Connector (I2) to decorative slot (E1 & E2) by bolt (AA) and washer (BB).

Fig.3: Firstly, insert assembled decorative slot without corner into decorative slot with corner, then fix the top

slanting bar connector (I1) at the corner of decorative slot, secure them with blot (AA) and washer (BB).

Fig.4: Attach corner support (F) to the corner of the decorative slot by bolt (AA) and washer (BB).

Fig.5: Attach long mosquito netting pipe (O1) to the long decorative slot by bolt (CC) and washer (BB).

Fig.5-1: Attach short mosquito netting pipe (O2) to the short decorative slot by bolt (CC) and washer (BB).

Fig.6: Attach hook (N) to Bottom top roof (L2).

Fig.7: Attach one end of Top Slanting Bar (J2) to Slanting Bar Connector (I1) by bolt (AA) and washer (BB).

Fig.7-1: Attach the other end of Top Slanting Bar (J2) to Bottom top roof (L2) by bolt (AA) and washer (BB).

Fig.8: Attach one end of Top Bar (J1) to Bean Connector (I2) by bolt (AA) and washer (BB).

Fig.8-1: Attach the other end of Top Bar (J1) to Bottom top roof (L2) by bolt (AA) and washer (BB).

Fig.9: Put Upside top roof (L1) onto Bottom top roof (L2), tighten by bolt (CC) and washer (BB).

AA M6X15 Bolt 16PCS

BB M6 Washer 56PCS

CC M6X15 Bolt 22PCS

DD M6X25 Bolt 32PCS

GG Smaller M6 Washer 16PCS

Fig.10: Insert base cover (B) into post (A), then attach base (C) to post (A) by bolt (CC) and washer (BB).

Fig.11: Raise up the assembled top, then attach post (A) to the corner of the decorative slot by blot (AA) and

washer (GG).

Fig.12: Attach triangle support (D) to post (A) by bolt (DD) and washer (BB).

Hardware Pack 2

Fig.13: Insert middle PC top (K5) into top bar (J1), then insert slot 3 (H3) into top bar (J1). Finally, insert middle

PC top (K5) into top bar (J1) and slot 3 (H3). Make sure they are completely inserted in the roof bar’s track.

Fig.14: Insert upside left PC top (K1)/ Upside right PC top (K2) into top bar (J1) and top slanting bar (J2), then

insert slot 1(H1) / Slot 2 (H2) into top bar (J1) and top slanting bar (J2), finally, insert Bottom left PC top (K3)/

Bottom right PC top (K4) into top bar (J1), top slanting bar (J2) and slot 1(H1)/ Slot 2 (H2). Notice: Please adjust

the PC panel position to align all panels.

Fig.15: Insert F shape panel (G1, G2, G3) into Top Bar (J1), Top Slanting Bar (J2) and the outside PC top (K3,

K4, K5).

Fig.16: Attach cover 2 (M2) to top bar (J1) by bolt (CC) and washer (BB).

Fig.16-1: Attach cover 1 (M1) to top slanting bar (J2) by bolt (CC) and washer (BB).

EE Plastic ring 52PCS

FF Φ8*180mm Stake 12 PCS

Hardware Pack 3

Made in China

Fig.17: Hanging the mosquito netting (P) on mosquito netting pipe (O1 & O2) by plastic ring (EE).

Fig.18: Lift up the base cover (B), fix the gazebo on the ground by stake (FF).

Now, your gazebo is ready for use.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sunjoy Gartenmöbel Handbücher

Sunjoy

Sunjoy D-GZ339PAL-A Bedienungsanleitung

Sunjoy

Sunjoy Elworth L-GZ236PAL Bedienungsanleitung

Sunjoy

Sunjoy 169193 Bedienungsanleitung

Sunjoy

Sunjoy L-GZ605PST-A1 Bedienungsanleitung

Sunjoy

Sunjoy A103002201 Bedienungsanleitung

Sunjoy

Sunjoy South Bay L-GZ793PST-A-PK Bedienungsanleitung

Sunjoy

Sunjoy 10'X10' OPP Gazebo L-GZ322PST Bedienungsanleitung

Sunjoy

Sunjoy L-GZ215PST-1E Bedienungsanleitung

Sunjoy

Sunjoy L-GZ120PST-3 Bedienungsanleitung

Sunjoy

Sunjoy A207000702 Bedienungsanleitung

Sunjoy

Sunjoy Royal Hardtop Gazebo Bedienungsanleitung

Sunjoy

Sunjoy A111500500 Bedienungsanleitung

Sunjoy

Sunjoy South Hampton L-GZ215PST-A-MN Bedienungsanleitung

Sunjoy

Sunjoy L-GZ339PAL Bedienungsanleitung

Sunjoy

Sunjoy A102007900 Beilage

Sunjoy

Sunjoy S-DN012-T Bedienungsanleitung

Sunjoy

Sunjoy A101012300 Bedienungsanleitung

Sunjoy

Sunjoy L-GZ717PST-E-GB Bedienungsanleitung

Sunjoy

Sunjoy A102001703 Bedienungsanleitung

Sunjoy

Sunjoy MANHATTAN L-GZ1138PST-A Bedienungsanleitung

Sunjoy

Sunjoy L-GG067PST Bedienungsanleitung

Sunjoy

Sunjoy A102003701 Bedienungsanleitung

Sunjoy

Sunjoy L-DN1210SST-E-T Bedienungsanleitung

Sunjoy

Sunjoy A103002000 Bedienungsanleitung

Beliebte Gartenmöbel Handbücher anderer Marken

Belleze

Belleze 014-HG-20074 Bedienungsanleitung

Hatteras Hammocks

Hatteras Hammocks DCA1-K-HH Bedienungsanleitung

Kozyard

Kozyard Morgan Aluminum Pergola Bedienungsanleitung

Lemeks

Lemeks Palmako PA120-5959 Installationshandbuch

OLT

OLT 24 Bedienungsanleitung

forest-style

forest-style HACIENDA 2354 Bedienungsanleitung

Courtyard Creations

Courtyard Creations RUS0188-WM Bedienungsanleitung

RPR

RPR OLLIE CHAIR Bedienungsanleitung

kingsley-bate

kingsley-bate MC-55 Bedienungsanleitung

Weltevree

Weltevree Carrier Bedienungsanleitung

Grange Fencing

Grange Fencing Elite Arch Bedienungsanleitung

Grosfillex

Grosfillex AUVENT YR14 Bedienungsanleitung

X-METAL

X-METAL EAGLE 33511 Bedienungsanleitung

Anova

Anova FBW6R Bedienungsanleitung

Outsunny

Outsunny 84A-090 Bedienungsanleitung

Ivy Terrace

Ivy Terrace IVTD212 Bedienungsanleitung

Breezesta

Breezesta FANBACK ADIRONDACK AD-0101 Bedienungsanleitung

hanit

hanit SUTTON 1 Bedienungsanleitung