TJERNLUND HS-5 Bedienungsanleitung

IN-FORCER OR HS-5 WHEEL REPLACEMENT KIT

WARNING: Disconnect power from IN-FORCERTM and equipment before installing new wheel.

OPTION 1 FOR IN-FORCER WHEEL REMOVAL (PREFERRED)

1. Remove access door screws on rear of IN-FORCER,

(See Diagram A).

2. Remove screws from wheel housing inlet collar

and remove inlet collar.

3. Loosen set screw(s) on wheel with allen wrench. If

set screw(s) can not be loosened this way, remove

pipe on discharge side of IN-FORCER if necessary

and loosen set screw(s) through neck of blower hous-

ing. Install new wheel making sure it is centered in

blower housing. Tighten set screw(s) on flat of motor

shaft. On model PAI-7 make sure key-way is in wheel

hub. Rotate wheel by hand to make sure it is not

rubbing.

4. Replace inlet collar on housing with tapered end towards

wheel and secure access door.

5. Reconnect power supply. Run IN-FORCER and heating equipment through several heating cycles to verify

proper operation.

OPTION 2 FOR IN-FORCER WHEEL REMOVAL

1. Blower assembly may also be removed from IN-FORCER cabinet if preferred. Remove Access door screws. Remove

(2) motor assembly panel screws on front of IN-FORCER, (See Diagram A).

2. Disconnect motor leads.

3. Remove Fan Prover sensing tube from motor assembly panel by loosening brass compression fitting.

4. Remove (4) bolts which hold blower assembly to IN-FORCER cabinet.

5. Carefully slide out blower assembly from IN-FORCER cabinet.

6. Remove screws from wheel housing inlet collar and remove inlet collar.

7. Loosen set screw(s) on wheel with allen wrench. Install new wheel making sure it is centered in blower housing. Tighten

set screw(s) on flat of motor shaft. On model PAI-7 make sure key-way is in wheel hub. Rotate wheel by hand to make

sure it is not rubbing.

8. Reassemble IN-FORCER following reverse of procedures in steps 6 through 1. Make sure tapered end of inlet collar faces

towards wheel.

9. Reconnect motor leads and power supply. Run IN-FORCER and heating equipment through several heating cycles to

verify proper operation.

For technical assistance contact Tjernlund’s Technical Customer Service at 1-800-255-4208; M-F 7:30 - 4:30 CST.

TJERNLUND PRODUCTS, INC.

1601 Ninth Street • White Bear Lake, MN 55110-6794

PHONE (800) 255-4208 • (651) 426-2993 • FAX (651) 426-9547

Visit our web site • www.tjernlund.com

DIAGRAM A

Access door

Blower assembly

bolts (4)

Fan prover sensing

tube fitting

Motor assembly panel

screws (2) in front

Wheel housing

inlet collar

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere TJERNLUND Lüfter Handbücher

TJERNLUND

TJERNLUND SS1 SIDESHOT WITH UC1 UNIVERSAL CONTROL (VERSION X.04) 8504102 REV C... Bedienungsanleitung

TJERNLUND

TJERNLUND RV2 Bedienungsanleitung

TJERNLUND

TJERNLUND SS2G SIDESHOT (DISCONTINUED) 8504075 REV 1... Bedienungsanleitung

TJERNLUND

TJERNLUND SS2 SIDESHOT WITH UC1 UNIVERSAL CONTROL (VERSION X.04) 8504105 REV B... Bedienungsanleitung

TJERNLUND

TJERNLUND CS1 Bedienungsanleitung

TJERNLUND

TJERNLUND V1, V1D, V2D CRAWL SPACE VENTILATORS 8500720 Bedienungsanleitung

TJERNLUND

TJERNLUND Cool Breeze CB14 Bedienungsanleitung

TJERNLUND

TJERNLUND EA5 DUCT BOOSTER FAN 8504029 Bedienungsanleitung

TJERNLUND

TJERNLUND 950-0471 COMMERCIAL PAI FAN PROVER KIT 8504086 REV. A... Bedienungsanleitung

TJERNLUND

TJERNLUND aireshare as1p Bedienungsanleitung

TJERNLUND

TJERNLUND AireShare AS1 Bedienungsanleitung

TJERNLUND

TJERNLUND HS115-3 Bedienungsanleitung

TJERNLUND

TJERNLUND SS1R SIDESHOT WITH UC1 UNIVERSAL CONTROL (VERSION X.04) 8504117 REV... Bedienungsanleitung

TJERNLUND

TJERNLUND Duct Booster RB10 Bedienungsanleitung

TJERNLUND

TJERNLUND HSJ Benutzerhandbuch

TJERNLUND

TJERNLUND SIDESHOT SS1C INCREASED CAPACITY OIL VENT SYSTEM... Bedienungsanleitung

TJERNLUND

TJERNLUND DRAFT INDUCER DJ-3 Bedienungsanleitung

TJERNLUND

TJERNLUND DRAFT INDUCER DJ-3 Bedienungsanleitung

TJERNLUND

TJERNLUND WHKI MILLIVOLT APPLIANCE INTERLOCK (RECOMMEND WHKE FOR USE WITH UC1) 8504055 REV 3... Bedienungsanleitung

TJERNLUND

TJERNLUND EF DUCT BOOSTER FANS 8504057 REV.793 Bedienungsanleitung

TJERNLUND

TJERNLUND AD-1 FOR WOOD OR COAL STOVES 8504012 REV A... Bedienungsanleitung

TJERNLUND

TJERNLUND SS1C SIDESHOT WITH UC1 UNIVERSAL CONTROL (VERSION X.06) 8504103 REV D... Bedienungsanleitung

TJERNLUND

TJERNLUND SS1R SIDESHOT (DISCONTINUED VERSION-PRE UC1 UNIVERSAL CONTROL) 8504046 REV... Bedienungsanleitung

TJERNLUND

TJERNLUND 950-2064 L-185 SAFETY INTERLOCK KIT 8504020 REV 3... Bedienungsanleitung

Beliebte Lüfter Handbücher anderer Marken

ELTA FANS

ELTA FANS H03VV-F Bedienungsanleitung

Hunter

Hunter 20714 Gebrauchsanweisung

Emerson

Emerson CARRERA VERANDA CF542ORB00 Bedienungsanleitung

Hunter

Hunter Caraway Gebrauchsanweisung

Panasonic

Panasonic FV-15NLFS1 Bedienungsanleitung

Kompernass

Kompernass KH 1150 Bedienungsanleitung

VES

VES FALA100/12V/TR Bedienungsanleitung

Vertiv

Vertiv Liebert DCD Bedienungsanleitung

Westinghouse

Westinghouse GFP Series Bedienungsanleitung

Venmar

Venmar KUBIX HRV PLUS Series Bedienungsanleitung

Maico

Maico ECR 31 Bedienungsanleitung

Sonnenkonig

Sonnenkonig Dinky Bedienungsanleitung

S&P

S&P ECOWATT HXBR Bedienungsanleitung

Wider

Wider IMP03369BH Bedienungsanleitung

Panasonic

Panasonic F-60DHN Bedienungsanleitung

Hinkley

Hinkley HIGHLAND Bedienungsanleitung

Broan

Broan 766BN Bedienungsanleitung

Premium

Premium PFS16022 Montageanleitung