Toro ProLine 30194 Bedienungsanleitung

Operator’s Manual

IMPORTANT: Read this manual carefully. It contains information about your

safety and the safety of others. Also become familiar with the controls and

their proper use before you operate the product.

FORM NO. 3319–802 Rev. A

ProLine

13 HP – 36”

Mid-Size Mower

Model No. 30194 – 890001

The Toro Comany – 1997

Introduction

Thank you for purchasing a Toro product.

All of us at Toro want you to be completely satisfied

with your new product, so feel free to contact your

local Authorized Service Dealer for help with service,

genuine replacement parts, or other information you

may require.

Whenever you contact your Authorized Service

Dealer or the factory, always know the model and

serial numbers of your product. These numbers will

help the Service Dealer or Service Representative

provide exact information about your specific

product. You will find the model and serial number

plate located in a unique place on the product as

shown below.

m–3775

1. Model and Serial Number Plate

For your convenience, write the product model and

serial numbers in the space below.

Model No:

Serial No.

Read this manual carefully to learn how to operate

and maintain your product correctly. Reading this

manual will help you and others avoid personal injury

and damage to the product. Although we design,

produce and market safe, state-of-the-art products,

you are responsible for using the product properly

and safely. You are also responsible for training

persons, who you allow to use the product, about safe

operation.

The warning system in this manual identifies

potential hazards and has special safety messages that

help you and others avoid personal injury, even death.

DANGER, WARNING and CAUTION are signal

words used to identify the level of hazard. However,

regardless of the hazard, be extremely careful.

DANGER signals an extreme hazard that will cause

serious injury or death if the recommended

precautions are not followed.

WARNING signals a hazard that may cause serious

injury or death if the recommended precautions are

not followed.

CAUTION signals a hazard that may cause minor or

moderate injury if the recommended precautions are

not followed.

Two other words are also used to highlight

information. “Important” calls attention to special

mechanical information and “Note” emphasizes

general information worthy of special attention.

The left and right side of the machine is determined

by standing\sitting on the seat in the normal

operator’s position.

The engine exhaust from this product

contains chemicals known to the State of

California to cause cancer, birth defects,

or other reproductive harm.

Contents

Page

Safety 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Safe Operating Practices 2. . . . . . . . . . . . . .

Slope Chart 5. . . . . . . . . . . . . . . . . . . . . . . . .

Safety and Instruction Decals 7. . . . . . . . . .

Gasoline and Oil 9. . . . . . . . . . . . . . . . . . . . . . . .

Recommended Gasoline 9. . . . . . . . . . . . . .

Stabilizer/Conditioner 9. . . . . . . . . . . . . . . .

Filling the Fuel Tank 9. . . . . . . . . . . . . . . . .

Check Engine Oil Level 9. . . . . . . . . . . . . . .

Assembly 10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Loose Parts 10. . . . . . . . . . . . . . . . . . . . . . . . .

Install Front Castors 11. . . . . . . . . . . . . . . . . .

Install Upper Handle 11. . . . . . . . . . . . . . . . .

Connect Throttle Cable 13. . . . . . . . . . . . . . .

Install Blade Control (PTO) Rod 14. . . . . . . .

Install Shift Lever 14. . . . . . . . . . . . . . . . . . .

Mount Fuel Tank 15. . . . . . . . . . . . . . . . . . . .

Operation 16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Think Safety First 16. . . . . . . . . . . . . . . . . . .

Controls 16. . . . . . . . . . . . . . . . . . . . . . . . . . .

Parking Brake 17. . . . . . . . . . . . . . . . . . . . . . .

Starting and Stopping the Engine 18. . . . . . .

Operating Blade Control (PTO) 19. . . . . . . . .

The Safety Interlock System 19. . . . . . . . . . .

Driving Forward or Backward 20. . . . . . . . . .

Page

Stopping the Machine 20. . . . . . . . . . . . . . . .

Adjusting Height-of-Cut 21. . . . . . . . . . . . . .

Height-of-Cut Chart 22. . . . . . . . . . . . . . . . . .

Maintenance 23. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Service Interval Chart 23. . . . . . . . . . . . . . . .

Air Cleaner 24. . . . . . . . . . . . . . . . . . . . . . . . .

Engine Oil 25. . . . . . . . . . . . . . . . . . . . . . . . .

Tire Pressure 27. . . . . . . . . . . . . . . . . . . . . . . .

Cleaning the Cooling System 27. . . . . . . . . . .

Spark Plug 28. . . . . . . . . . . . . . . . . . . . . . . . .

Cutting Blades 29. . . . . . . . . . . . . . . . . . . . . .

Adjusting Blade Brake 31. . . . . . . . . . . . . . . .

Greasing and Lubrication 32. . . . . . . . . . . . . .

Brake 33. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Fuel Tank 34. . . . . . . . . . . . . . . . . . . . . . . . . .

Fuel Filter 35. . . . . . . . . . . . . . . . . . . . . . . . . .

Replacing the Wheel Belt 35. . . . . . . . . . . . .

Replacing the Traction Belt 36. . . . . . . . . . . .

Replacing the Mower Belts 36. . . . . . . . . . . .

Adjusting Grass\Mud Scraper 37. . . . . . . . . .

Replacing the Grass Deflector 37. . . . . . . . . .

Wiring Diagram 38. . . . . . . . . . . . . . . . . . . . .

Cleaning and Storage 39. . . . . . . . . . . . . . . . .

Troubleshooting 40. . . . . . . . . . . . . . . . . . . . . . . . .

Warranty Back Cover. . . . . . . . . . . . . . . . . . . . . . . . . .

       

     

    

         

       

      

 

Safety

This machine meets or exceeds safety

requirements B71.4–1990 of the American

National Standards Institute for commercial

mowers, in effect at time of production. However,

improper use or maintenance by the operator or

owner can result in injury. To reduce the potential

for injury, comply with these safety instructions

and always pay attention to the safety alert

symbol which means CAUTION, WARNING or

DANGER—“personal safety instruction.” Failure

to comply with the instruction may result in

personal injury.

Safe Operating Practices

This product is capable of amputating hands and feet

and throwing objects. Always follow all safety

instructions to avoid serious injury or death.

POTENTIAL HAZARD

•Engine exhaust contains carbon monoxide,

which is an odorless, deadly poison.

WHAT CAN HAPPEN

•Carbon monoxide can kill you and is also

known to the State of California to cause

birth defects.

HOW TO AVOID THE HAZARD

•Do not run engine indoors or in an enclosed

area.

This mower is designed for cutting and recycling

grass or, when equipped with a grass bag, for

catching cut grass. Any use for purposes other than

these could prove dangerous to user or bystanders.

Note: This engine is NOT equipped with a

spark arrester muffler. Use or operation

of this mower in the State of California

on any forest-covered, brush-covered

or unimproved grass-covered land,

without an approved spark arrester

muffler, is a violation of the law. Other

states may have similar laws.

General Operation

1. Read this manual carefully before operating the

mower. Become familiar with the controls and

proper use of the mower. Never allow children

under 16 years of age to operate the mower.

Never allow adults to operate mower without

proper instructions.

2. The operator of the mower is responsible for

keeping everyone, especially children and pets,

away from area of operation. The operator is

responsible for accidents or hazards occurring to

other people or their property.

3. Thoroughly inspect area where mower will be

used and remove sticks, stones, wire, and debris

that could be picked up and thrown by mower.

Watch for foreign objects while mowing.

4. Wear long pants and substantial shoes. Do not

operate mower while wearing open-toed shoes,

jewelry, loose clothing or when barefoot.

5. Check fuel level before starting engine. Because

fuel is highly flammable, handle it carefully.

A. Use an approved fuel container.

B. Fill fuel tank outdoors, not indoors.

NEVER ADD FUEL TO AN ENGINE

THAT IS RUNNING OR HOT.

C. Install gas cap on fuel container and gas

tank, and wipe up any spilled gasoline

before starting engine.

Safety

D. Do not smoke while refueling.

6. Keep all guards, shields, safety devices,

cover-deflector assembly, optional grass catcher,

optional side discharge chute or optional

discharge tunnel plug in place. Repair or replace

damaged parts, including decals. Check all

safety devices before each use.

7. Engine, blade and self–propelled drive

(self-propelled model) are designed to stop when

control bails are released. Ensure control and

brake function properly before each use of

mower.

8. Disengage the self-propelled mechanism or drive

clutch (self-propelled model) before starting the

engine.

9. Before using, always visually inspect to see that

the blades, blade fasteners and cutter assembly

are not worn or damaged. Replace worn or

damaged blades and fasteners in sets to preserve

balance.

While Operating

1. Do not run engine indoors.

2. Start the engine carefully according to

instructions and with feet well away from the

blade.

3. Always maintain secure footing. Keep a firm

grip on the handle and walk; never run. Never

operate mower in wet grass. Mow only in

daylight or in good artificial light.

4. Mow across the face of slopes; never up and

down. Use extreme caution when changing

direction on slopes. Do not mow excessively

steep slopes. Wear skid resistant shoes on slopes.

5. Always wear safety glasses or eye shields during

operation to protect eyes from foreign objects

that may be thrown from the machine.

6. Keep face, hands, and feet away from the mower

housing and cutter blade when the engine is

running. Blade can cause injury to hands and

feet. Stay behind the handle until the engine

stops.

7. Use extreme caution when reversing or pulling

the mower towards you.

8. Since the blade rotates for a few seconds after

the control bar is released, stay behind the

handle until all moving parts stop.

9. After striking a foreign object or if mower

vibrates abnormally, stop engine and remove

wire from spark plug. Check mower for damage

and make all repairs before using mower again.

If major repairs are ever needed or if assistance

is desired, contact your local Authorized TORO

Service Dealer.

10. Stop the engine and wait for all moving parts to

stop before adjusting the height-of-cut.

11. Stop the blade when moving the mower outside

the lawn area.

12. Stop engine before leaving the operator’s

position—behind the handle. Disconnect wire

from spark plug if mower will be unattended.

13. Do not touch engine while it is running or

shortly after it is stopped because engine will be

hot enough to cause a burn.

14. Refuel only when engine is cool.

15. If mower must be transported, turn off engine

and stay behind the handle until all moving parts

stop. Disconnect spark plug wire.

Safety

Maintenance And Storage

1. Perform only those maintenance instructions

described in this manual. If major repairs are

ever needed or if assistance is desired, contact

your local Authorized TORO Service Dealer.

2. Before mower is cleaned, inspected, serviced, or

adjusted, stop engine and disconnect wire from

spark plug. Keep wire away from plug to prevent

accidental starting.

3. To ensure the mower is in safe operating

condition, frequently check and keep all nuts,

bolts, and screws tight. Ensure blade bolt is

tightened to 75–80 ft-lb (101–108 Nm

4. When servicing blade, refer to blade

maintenance section for correct installation and

servicing procedures.

5. To reduce fire hazard, keep engine free of

excessive grease, grass, leaves, and

accumulations of dirt.

6. Allow engine to cool before storing mower in

any enclosure. Do not store mower with gasoline

in fuel tank near any open flame or where

gasoline fumes may be ignited by a spark.

7. Do not overspeed the engine by changing

governor settings.

8. At the time of manufacture, the mower

conformed to the safety standards in effect for

rotary mowers. To assure best performance and

continued safety certification of the mower, use

genuine TORO replacement parts and

accessories. Replacement parts and accessories

made by other manufacturers may result in

non–conformance with the safety standards, and

that could be dangerous.

Safety

Slope Chart

Read all safety instructions on pages 2–7.

Safety

Safety and Instruction Decals

Safety decals and instructions are easily visible to the operator and are located near

any area of potential danger. Replace any decal that is damaged or lost.

ON UPPER CON ROL BAR

(Part No. 82-2290)

ON OP-FRON  OF MOWER

(Part No. 66-1340)

ON LOWER CON ROL BAR

(Part No. 82-2280)

ON GRASS DEFLEC OR

(Part No. 93-1122)

ON OP-LEF  SIDE OF MOWER

(Part No. 43-8480)

ON ENGINE ABOVE MUFFLER

(Part No. 63-8440)

ON CON ROL PANEL

(Part No. E323564)

ON HE GEAR SELEC ION PANEL

(Part No. E323560)

ABOVE GRASS DEFLEC OR

(Part No. 67-5360)

Safety

ON REAR OF MOWER

(Part No. 98-3296)

ON PARKING BRAKE

(Part No. E323558)

ON LEF  SIDE OF HANDLE FRAME

(Part No. E323563)

ALONG LEF  SIDE OF FUEL ANK

(Part No. 95-2814)

ON REAR FRAME

(Part No. E323562)

 ON REAR-LEF  CORNER OF MOWER

(Part No. 68-8340)

Andere Handbücher für ProLine 30194

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Toro Rasenmäher Handbücher

Toro

Toro 31914 Bedienungsanleitung

Toro

Toro Z Master G3 Stücklistenhandbuch

Toro

Toro 20836 Bedienungsanleitung

Toro

Toro 31335 Bedienungsanleitung

Toro

Toro Z Master Professional 7500-DSeries Bedienungsanleitung

Toro

Toro Z580-D Z Master 74266CP Bedienungsanleitung

Toro

Toro 03805 Bedienungsanleitung

Toro

Toro Recycler 20332 Bedienungsanleitung

Toro

Toro Recyler 20379 Bedienungsanleitung

Toro

Toro Z Master Z597-D Bedienungsanleitung

Toro

Toro ProLine 22166 Bedienungsanleitung

Toro

Toro Reelmaster 5210 Bedienungsanleitung

Toro

Toro Recycler 145-1538 Bedienungsanleitung

Toro

Toro Groundsmaster 30344 Bedienungsanleitung

Toro

Toro Z Master Z300 Bedienungsanleitung

Toro

Toro eS52VST Bedienungsanleitung

Toro

Toro TimeCutter MX5060 Bedienungsanleitung

Toro

Toro SS 3200 Bedienungsanleitung

Toro

Toro 30643 Bedienungsanleitung

Toro

Toro 29643 Bedienungsanleitung

Toro

Toro 74161 Bedienungsanleitung

Toro

Toro 72200 Bedienungsanleitung

Toro

Toro Reelmaster 5100-D Bedienungsanleitung

Toro

Toro 75210 Bedienungsanleitung

Beliebte Rasenmäher Handbücher anderer Marken

RHINO

RHINO 1958 Bedienungsanleitung

Wolf Garten

Wolf Garten Compact plus 40 B Bedienungsanleitung

Cub Cadet

Cub Cadet LTX 1045 Bedienungsanleitung

Craftsman

Craftsman 917.378461 Bedienungsanleitung

GGP ITALY SPA

GGP ITALY SPA CR/CS 434 SERIES Bedienungsanleitung

Challenge

Challenge CH18V2 Betriebsanleitung

TALEN TOOLS

TALEN TOOLS AVR HGM30 Bedienungsanleitung

DEWEZE

DEWEZE ATM-725 Bedienungsanleitung

Weed Eater

Weed Eater 180083 Bedienungsanleitung

Husqvarna

Husqvarna Poulan Pro PP185A42 Bedienungsanleitung

Better Outdoor Products

Better Outdoor Products Quick Series Bedienungsanleitung

Cub Cadet

Cub Cadet 23HP Z-Force 60 Betriebsanleitung

MTD

MTD 795, 792, 791, 790 Bedienungsanleitung

Dennis

Dennis FT 610 Bedienungsanleitung

AIRFORCE

AIRFORCE F-15 Gen 3 Bedienungsanleitung

MTD

MTD 126-220-000 Bedienungsanleitung

Stihl

Stihl RMA 443 PV Bedienungsanleitung

Yard-Man

Yard-Man 3700-0 Bedienungsanleitung