Town & Country Fireplaces TC30.NG04D Bedienungsanleitung

TC30

TRANQUILITY

BURNER KIT

INSTRUCTIONS

PART# TC30.NG04D

For TC30 Series D

Fireplaces

200317-24 TC30_NG04D 5056.42904D

These instructions are supplementary to the Installation and

Operating Instructions supplied with the replace and should be

kept together. Refer to the Installation and Operating Instructions for

proper gas supply, safety requirements and operating instructions.

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

Visit www.townandcountryﬁreplaces.net for the most recent version of this manual

TC30_NG04D 200317-24

5056.42904D 2

Contents of Package

A. Burner assembly (including pilot & gas lines)

B. Panel, base (attached to burner assembly).

C. Pebble assembly

D. Hardware - tapered plugs, screws, brush, panel clips.

E. Side cover - left hand side.

F. 2.2 LBS. SAND

G. Side cover (right hand side)

Figure 1: TC30 Tranquility burner kit parts.

Figure 3: Access cover to valve control center. Figure 4: Flex line bent to shape.

TC30_NG04D 200317-24 5056.42904D

Tranquility Burner Installation

If converting to propane see conversion instructions on page 13 before proceeding with

Tranquility Burner Kit.

1. Plug the 4 vacant holes in the bottom of the rebox with 1/2” screws, as they are not required to

attach this style of burner (Figure 2).

Figure 2: 4 holes in replace oor to be plugged.

2. Remove the 10 screws securing the access cover for the valve control center (Figure 3).

3. Bend the larger gas ex line, the smaller gas pilot ex line and the ignition and sensor wires into

shape (Figure 4) so that the right hand side cover will t over top of them before the burner is

placed into the rebox (Figure 6).

TC30_NG04D 200317-24

5056.42904D

Figure 5: Left hand side cover. Figure 6: Right hand side cover.

Rear panel

Burner assembly

Figure 7: Lower rear panel and burner assembly.

4. Place side covers between the burner tray and its base (Figure 5 and Figure 6) before the burner

tray is inserted into the rebox. These will remain in the retracted position until later in the instal-

lation process.

5. Position lower rear panel centered at the rear of the rebox. Place burner assembly into the re-

box against the rear panel (Figure 7).

Interface module

Figure 8: Gas and pilot supply tubes.

TC30_NG04D 200317-24 5056.42904D

Ignition and sensor wires

Bulkhead plate

Figure 9: Ignition and sensor wires routing.

6. Attach the main gas supply line and the pilot gas supply line to the bulk head ttings and tighten

(Figure 8). Ensure that there are no leaks.

7. Feed the ignition and sensor wires through the bulkhead plate and gasket to the rebox

(Figure 9).

TC30_NG04D 200317-24

5056.42904D 6

Ignition wire (red)

Flame sensor

wire (white)

Interface module

Figure 10: Interface module.

8. Attach the ignition and sensor wires to the interface module as indicated in Figure 10.

9. Once the gas and electrical lines are connected to the bulkhead and the interface module, rein-

stall the valve control center’s access cover (Figure 3 on page 3). The panels are now ready

to be installed.

Panel retainer

Screw Screw

Figure 11: Panel retainer location.

TC30_NG04D 200317-24 5056.42904D

10.Remove the two screws (Figure 11) which secure the panel retainer to the ceiling. Remove the

panel retainer and keep for reinstallation (Figure 12).

11.Attach a panel clip on each of the side panels (Figure 13). These clips will t over the upper rear

panel, holding it in place.

Figure 12: Panel retainer removal.

Figure 13: Right side panel with clip attached.

TC30_NG04D 200317-24

5056.42904D

Figure 15: Inserting the upper rear panel.

12.Remove tag and plastic tie from the ue damper before installing the upper rear panel.

13.Install one of the side panels until it’s nearly up against the rebox wall. Leave enough room

between the panel and wall so that the upper rear panel can be slipped in behind the side panel.

14.Install the upper rear panel (Figure 15). Place one end on top of the lower rear panel and slip the

side of the upper rear panel in behind the side panel. Hold the upper rear panel up against the

rear rebox wall until the retaining clip can be positioned over the top of the upper rear panel.

NOTE: Remove this

tag and plastic tie

before installing

upper rear panel

Figure 14: Right side panel partially installed.

Figure 16: Left hand side panel installed.

TC30_NG04D 200317-24 5056.42904D

15.Install the other side panel (Figure 16) and bend its retaining clip over the upper rear panel as in

the previous step.

16.Reinsert the two screws previously removed from the panel retainer but do not tighten. Reinstall

the panel retainer and t slots to hook onto the two screws. Tighten screws (Figure 17).

Figure 17: Panel retainer reinstalled.

TC30_NG04D 200317-24

5056.42904D

Figure 18: Securing side covers.

Figure 19: Inserting tapered plugs.

17.Move the two side covers previously placed between the burner and its base, out to the side

panels. Line the screw holes in the side covers up with the screw holes in the burner tray base.

Use supplied self taping screws to secure the covers to the base (Figure 18).

18.Insert tapered plugs into raised burner ports to prevent sand from entering ports (Figure 19).

19.Place sand in tray. Use supplied brush to spread and level the sand to just below the top of

raised burner ports. Gently blow excess sand from around ports (Figure 20).

Andere Handbücher für TC30.NG04D

Inhaltsverzeichnis

Andere Town & Country Fireplaces Brenner Handbücher

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Series Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.NG03D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30.NG02DN Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42.NG04D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42.NG04D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42.NG03C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30.NG04C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.NG02DN Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces D Series Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.NG03C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.NG04D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54.NG02D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54NGST04D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.NG02CN Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54.NG04C2 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.NG04C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.38CE2 Gebrauchsanweisung

Town & Country Fireplaces

Town & Country Fireplaces TC42.NG02DN Bedienungsanleitung

Beliebte Brenner Handbücher anderer Marken

Riello

Riello RS 28/M Kurzanleitung

True Induction

True Induction TI4B Bedienungsanleitung

Weishaupt

Weishaupt WG20 Series Bedienungsanleitung

Carolina Cooker

Carolina Cooker M116672 Bedienungsanleitung

Riello

Riello RX 500 S/PV Bedienungsanleitung

Unigas

Unigas HTP2000 Bedienungsanleitung

baltur

baltur BT 250 DSG 4T Bedienungsanleitung

muenkel design

muenkel design round burner Bedienungsanleitung

baltur

baltur BT 14 DSGW Bedienungsanleitung

artisan

artisan Art-SB1 Leitfaden

AESYS

AESYS TurboFire II Bedienungsanleitung

Riello

Riello RG1RKD Kurzanleitung

IKEA

IKEA GRILLSKÄR Bedienungsanleitung

RUSTA

RUSTA SAREK Bedienungsanleitung

PROPOINT

PROPOINT 8933657 Bedienungsanleitung

baltur

baltur TBL 1000 ME Referenzhandbuch

Riello Burners

Riello Burners P 200 P/G Kurzanleitung

WLD-TEC

WLD-TEC powerjet Bedienungsanleitung