Town & Country Fireplaces D2 Series Installations- und Betriebshandbuch

100001172-50 TCWS54D2 021118-12

Dimensions | Clearances | Venting

IMPORTANT

This booklet is intended as a basic speciﬁcation

guide for architects, designers and builders.

Please refer to the Instruction Manual supplied

with the ﬁreplace for detailed information regarding

installation and operation.

Product installation manuals can also be viewed at:

www.townandcountryﬁreplaces.com

FOR ARCHITECTS & DESIGNERS

TCWS54

SERIES D2

FOR REFERENCE ONLY. CONSULT MANUAL BEFORE INSTALLATION

021118-12 100001172-50 TCWS54D2

Fireplace Dimensions

Examples of Common Locations

TCWS54.D2 Cad Drawing

Available at

www.townandcountryreplaces.com

FOR REFERENCE ONLY. CONSULT MANUAL BEFORE INSTALLATION

021118-12

100001172-50 TCWS54D2

Mantel Clearance Chart

Minimum Clearances to Combustibles

* MANTEL CLEARANCE

A 9”

B 6”

C 3”

MANTEL CLEARANCE

CHART

** MANTEL DEPTH

D 12”

E 6 3/4”

F 1 1/2”

29 3/4"

24"

4“

CEILING

ADJACENT WALL

OR MANTEL SUPPORT

12”

COMBUSTIBLE FLOOR

COMBUSTIBLE HEARTH

MANTEL

Unit may be recessed up to 4 1/2” with

non-combustible masonary type material

Minimum Clearances:

Side standoffs .................................................. 0 in. (0 mm)

Back standoffs ................................................. 0 in. (0 mm)

Top standoffs.................................................... 0 in. (0 mm)

Bottom of appliance ......................................... 0 in. (0 mm)

Adjacent side wall............................................. 4 in. (102 mm)

Ceiling to appliance .......................................... 24 in. (610 mm)

*Mantel to appliance.......................................... See mantle clearance

.................................................................... chart above

**Maximum Mantel extension............................. See mantle clearance

..................................................................... chart above

Mantel support ................................................. 4 in. (102 mm)

Vertical vent pipe ............................................. 1 3/4" in.(45 mm)

Horizontal Vent pipe (Top, sides and bottom) .... 1 3/4" in.(45 mm)

MAY USE COMBUSTIBLE

FACING MATERIAL IN THIS

AREA

NON-COMBUSTBLE

FINISH MATERIAL

NON-COMBUSTIBLE ZONE.

DO NOT INSTALL ANY COMBUSTIBLE

MATERIAL, ELECTRICAL WIRING OR GAS

PLUMBING IN THIS AREA.

COMBUSTIBLE FRAMING AND

FINISH WALL ABOVE STANDOFFS

STANDOFF

STEEL FRAMING

FIREPLACE

FRONT

TOP OF LINTEL BAR

FOR REFERENCE ONLY. CONSULT MANUAL BEFORE INSTALLATION

021118-12 100001172-50 TCWS54D2

74 3/4"

55 1/16"

Steel Stud Framing Kit Dimensions Kit

Minimum Combustible Framing Dimensions

NON-COMBUSTIBLE materials

must extend 12” above and 9 5/8”

to the sides of the framing edges.

NON-COMBUSTIBLE BOARD NOT

INCLUDED.

NON-COMBUSTIBLE BOARD

All other framing can be done with

conventional lumber

Non-combustible

Board Detail

12”

9 5/8”

12”

31 1/2"

44 9/16"

74 13/16"

81 11/16"

115 9/16"

55 1/4"

74 13/16"

NOTE: FIREPLACE SHOULD BE IN ITS FINAL LOCATION BEFORE FRAMING

RANGE

23 11/16"

25 7/16"

RANGE

25 3/8”

26 7/8"

RANGE

1/32"

3 3/16"

11 3/4"

FRAMING

LINTEL

74 3/4"

Framing kit is supplied

with Fireplace

Must allow for

minimum 1/2 inch

gap for non-combustible

board and facing

NOTE: Fireplace should be in its final location before framing.

NOTE: Combustible framing must allow for sheetrock installation.

FOR REFERENCE ONLY. CONSULT MANUAL BEFORE INSTALLATION

021118-12

100001172-50 TCWS54D2

Proflame 2 Control System

Hearth Extension

Recessed Installation

Up to 50 Feet

REMOTE

OFF

PROGRAM

TOWN & COUNTRY

LUXURY FIREPLACES

Caution: This ﬁreplace may be recessed up to a maxi-

mum depth of 4 1/2”. This recess must be constructed

from non-combustible material. The space between the

outside framing edge and the ﬁrebox must be completely

free of any obstructions or debris, and the window, with

trim ﬁtted, must be able to move freely.

No building material is permitted to protrude past the

framing edges attached to the ﬁreplace under ANY

circumstance.

Town and Country D2 Series fireplaces use the SIT

Proflame 2 control system.

This includes an elegant hand-held remote control

transmitter with an easy to read LCD display.

The fireplace also comes with a wall-mounted control

switch which allows for simple ON/OFF operation, or

can be linked with the hand-held remote control unit.

This switch has a battery powered back-up system

which allows operation during power outages. The

wall-mounted switch easily connects to any customer

supplied Home Automation System.

Caution: While a hearth extension is not required and

combustible ﬂooring materials may be brought directly up

to the ﬁreplace, many materials (such as wood ﬂooring)

may not tolerate the radiant heat from this ﬁreplace,

resulting in discoloration, shrinking and cracking. For this

reason, we suggest a non-combustible hearth that is no

more than 1” above the bottom of the ﬁreplace. If material

is thicker, ﬁreplace must be raised accordingly.

Caution: Hearth extensions thicker than 1” will

interfere with the window frame when opening.

LINTEL

Surface of hearth extension

may not be be more than 1

inch above the bottom of the

replace.

FOR REFERENCE ONLY. CONSULT MANUAL BEFORE INSTALLATION

021118-12 100001172-50 TCWS54D2

Direct Vent

Roof Installation

FOR REFERENCE ONLY. CONSULT MANUAL BEFORE INSTALLATION

021118-12 100001172-50 TCWS54D2

20'

10'

40'

MAX.

48'

4' MAX.

18” MIN BEFORE ELBOW

Roof Termination Venting Chart

TCWS54.D2 Cad Drawing

Available at

www.townandcountryreplaces.com

CAUTION:

Under no condition should

combustible

material be closer than

1 3/4 inches from any part of

the vent pipe.

Only 45º elbows can be used

in this vent system.

Maximum number of

elbows is 2.

FOR REFERENCE ONLY. CONSULT MANUAL BEFORE INSTALLATION

021118-12

100001172-50 TCWS54D2

Direct Vent Terminal Clearance

Direct Vent Terminal Minimum Clearances

Minimum clearances to the vent terminal must be maintained

as shown (See illustration to right & below). Measure

clearances to the nearest edge of termination hood.

(See pitch table below).

NOTE: Vent terminal must not be recessed

NOTE: LOCAL CODES OR REGULATIONS MAY REQUIRE

DIFFERENT CLEARANCES.

Terminal to sloped Roof Pitch Table

(minimum)

ft m

Flat to 6/12 1.00 0.30

Over 6/12 to 7/12 1.25 0.38

Over 7/12 to 8/12 1.50 0.46

Over 8/12 to 9/12 2.00 0.61

Over 9/12 to 10/12 2.50 0.76

Over 10/12 to 11/12 3.25 0.99

Over 11/12 to 12/12 4.00 1.22

VENT TERMINAL MINIMUM CLEARANCES

TO ADJACENT STRUCTURES

A= *12 inches (30 cm) min. Clearances above grade, veranda, porch, deck, or balcony

B= *12 inches (30 cm) min. Clearance to window or door that may be opened

C= 12 inches (30 cm) min. Clearance to permanently closed window recommended to prevent condensation on window

D= 30 inches (76 cm) min. Vertical clearance to ventilated sofﬁt located above the terminal within a horizontal distance of 2 feet (60 cm) from the

edge of the terminal

E= 30 inches (76 cm) min. Clearance to unventilated sofﬁt

F= 6 inches (15 cm) min. Clearance to outside corner

G= 6 inches (15 cm) min. Clearance to inside corner

H= 3 feet (90 cm) min. *Not to be installed above a meter/regulator assembly within 3 feet (90 cm) horizontally from the center-line of the

regulator

I= *6 feet (1.8 m) min. Clearance to service regulator vent outlet

J= *12 inches (30 cm) min. Clearance to non mechanical air supply inlet to building or the combustion air inlet to any other appliance

K= *6 feet (1.8 m) min. Clearance to a mechanical air supply inlet

L= *7 feet (2.1 m) min. ^ Clearance above paved side-walk or a paved driveway located on public property

M= **30 inches (76 cm) min Clearance under veranda, porch, deck, or balcony

^ a vent shall not terminate directly above a side-walk or paved driveway which is located between two single family dwellings and serves both dwellings*

** only permitted if veranda, porch, deck, or balcony is fully open on a minimum of 2 sides beneath the ﬂoor*

* as speciﬁed in CAN/CSA B149.1 Installation Codes, Note: local Codes or Regulation may require different clearances

* for U.S.A. Installations follow the current National Fuel Gas Code, NFPA54/ANSI Z223.1

AIR SUPPLY INLET

VENT TERMINAL GAS METER

AREA WHERE TERMINAL

IS NOT PERMITTED

FIXED

CLOSED

FIXED

CLOSED OPEN-

ABLE

OPEN-

ABLE

36"

See Roof

pitch table

48"

ADJACENT

24"

(91.5 cm)

(61 cm)

(122 cm)

STRUCTURES

OR FENCE

FOR REFERENCE ONLY. CONSULT MANUAL BEFORE INSTALLATION

021118-12 100001172-50 TCWS54D2

Up to 66 feet

of vertical run

Up to 110 feet of run

plus six 90º elbows

Up to 3 feet below unit

Optional Power Vent

Power Vent Terminals

Direct Vent Terminals

Reach almost any room or commercial setting.

Optional Power Venting allows runs up to 110’ to

an outside wall or roof surface (maximum 66’ of

vertical run). Vent horizontally or vertically with up

to six 90-degree elbows, including runs up to 3’

below the ﬁreplace.

The premium Power Vent fan runs quietly outside,

at the exterior terminal.

Roof Termination Flush Mount termination

Stainless Steel Standard Venting

Termination for Condo Installation

Standard Venting

Wall Termination

Standard Venting

Roof Termination

TCWS54.D2 Cad Drawing

Available at

www.townandcountryreplaces.com

FOR REFERENCE ONLY. CONSULT MANUAL BEFORE INSTALLATION

021118-12

100001172-50 TCWS54D2

Andere Handbücher für D2 Series

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Town & Country Fireplaces Kamin im Innenbereich Handbücher

Town & Country Fireplaces

Town & Country Fireplaces TC36ST.NGST04D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54OD Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36STD2 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.RHKA Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54ST SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.CSTE3 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54 SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCW120 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 SEE-THRUC SERIES Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54ST SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces D Series Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36ST Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54NG04.C2 Technisches Handbuch

Town & Country Fireplaces

Town & Country Fireplaces TC36 AR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces Architectural Series Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch