Town & Country Fireplaces TC36.D Bedienungsanleitung

Visit www. townandcountryﬁreplaces.net for the most recent version of this manual

191023-16 SKU# 22150017 100005912

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

TC36D

COUNTRY HOME

BURNER KIT

INSTRUCTIONS

(NATURAL GAS ONLY)

SKU# 22150017

For TC36D & TC36D Arch

Series D

These instructions are supplementary to the

Installation and Operating Instructions supplied

with the replace and should be kept together.

Refer to the Installation and Operating Instructions

for proper gas supply, safety requirements and

operating instructions

1. Place the keyhole slots of the burner (Figure 3) over the two screws located on the rebox oor

(Figure 2).

Screws

Burner/ Grate Installation

SKU# 22150017 191023-16

100005912

Contents of Package

Figure 2: Firebox base.

Figure 1: TC36 and TC36 Arch Country Home burner kit contents.

7Pcs Log Set

Air Deector

Ember Material

Burner Assembly

Log Grate

2. Slide the burner back to engage the screws in the small part of the keyhole slot and tighten

screws (Figure 4).

3. Remove access cover to the valve control center from right side of rebox (Figure 5)

SKU# 22150017 191023-16 3100005912

Figure 5: Access cover to valve control center.

Figure 4: Burner assembly pushed back against right

side screw.

Figure 3:Burner assembly over top of right side screw.

Ignition and sensor wires

Bulkhead plate

5. Feed the ignition and sensor wires through the bulkhead plate to the interface module. Tuck the

ignition and sensor wires below the supply tubes (Figure 7).

4. Attach the pilot and gas supply tubes to the bulk head tting and tighten (Figure 6). Ensure the

connections are gas tight.

SKU# 22150017 191023-16

100005912

Figure 7: Ignition and sensor wire routing.

Figure 6: Gas and supply tubes.

Ignition wire.

Flame sensor

wire.

Interface module

6. Attach the ignition and sensor wires to the Interface module as shown in Figure 8.

7. Reinstall the valve control center access panel (See Figure 5 on page 3).

A panel set must now be installed before the log grate can

be installed. See Installation and Operating Instructions

manual for details.

SKU# 22150017 191023-16 5100005912

Figure 8: Interface module.

AIR DEFLECTOR SECURING SCREWS

8. Remove the two screws in the bottom of the unit then position the slots of the grate securing brackets

over the holes in the oor shield and secure with the two screws (Fig. # 9).

9. Attach rear deector to rear of grate using the two screws provided (Figure 10).

SKU# 22150017 191023-16

100005912

Figure 10: Rear air deector.

Figure 9: Securing log grate to the oor.

Ember Material Placement

A large bag of ember material is shipped with the replace and needs to be installed to ensure optimum

performance and ame appearance.

Pull apart the material into ember size pieces (approximately 1” squares) and gently place them into the

burner pan. Do not compress, leave it loose for best performance.

Fill the burner pan level with the top of the pan at rear, and gradually slope forward to the rebox oor at

the front, covering both burner tubes.

Place remaining ember material outside of the burner pan as desired to cover-up gas lines and brackets.

Note: Ember material placement and amount will affect ame appearance. More ember material results

in lower ame height. Add or remove as needed until desired ame affect.

GLOWING EMBERS

SKU# 22150017 191023-16 7100005912

Figure 11: Glowing Ember placement.

Log Set and Assembly

SKU# 22150017 191023-16

100005912

Note: Improper placement of logs will cause sooting on internal parts and glass. The logs

may need to be repositioned slightly to avoid excessive ﬂame impingement.

Log Placement

Gas plumbing and vent connections should be completed before proceeding.

The logs are fragile, and should be handled with care. Unpack and inspect log set. There should be a

total of seven logs.

Position the logs as indicated by the following pictures. The three main logs have holes and / or pins.

Engage each pin in the corresponding holes. The four smaller logs do not have holes or pins. They

rest in position. Locate as per the diagrams 12 through 19.

1. Place Log 1 onto the log grate with the thicker end on the right and engage the holes in the bottom of the log

onto the two pins on the log grate.

2. Place Log 2 onto the lef side of the log grate with the thicker end down and rest the log onto the long pin on

the side of the log grate then engage the hole in the bottom of Log 2 onto the pin in the top left of Log 1.

SKU# 22150017 191023-16 9100005912

Figure 12: First log placement.

Figure 13: 2nd log placement.

3. Place Log 3 on an angle and engage the holes in the bottom of Log 3 onto the pin in the back corner of the

log grate and the pin in the middle of Log 1.

4. Place Log 4 onto log grate resting on the second nger from the left and the narrow part pointing towards

the center of the log grate.

SKU# 22150017 191023-16

100005912

Figure 14: 3rd log placement.

Figure 15: 4th log placement.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Town & Country Fireplaces Kamin im Innenbereich Handbücher

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces Architectural Corner Right Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36ST Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.NG03D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54 SERIES DMODULAR Gebrauchsanweisung

Town & Country Fireplaces

Town & Country Fireplaces Architectural Series Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 TC36ST.NGST03D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.NGST04C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54ST SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54CE SERIES C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces Series C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.NGST03 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54 SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCW120 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54CE2 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCW120 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54ST SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54NG04.C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54OD Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces HELIFIRE 360 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.38CE3 Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch