Travis Industries 430 GSR2 Bedienungsanleitung



430 GSR2 Traditional Log Set

Installation Instructions (SKU94500945)



Page 1 of 13 17601790.docx — 7/23/13 © Travis Industries, Inc.

WARNINGS:

•Make sure the gas control valve is OFF and the heater is cool prior to conducting service.

•Failure to position the parts in accordance with these diagrams or failure to use only parts specifically approved with

this appliance may result in property damage or personal injury.

•If using propane (LP), convert the appliance before installing the logs (see the owners manual for details).

Compatibility

•430 GSR2

Packing List

9-Piece Log Set Rear Log Support

Rear Air Deflector (NG)

Rear Air Deflector (LP - NOTE NOTCH)

Rock Wool and Embers

Left and Right Log Supports with (2) 10-24 Nuts



430 GSR2 Traditional Log Set

Installation Instructions (SKU94500945)



Page 2 of 13 17601790.docx — 7/23/13 © Travis Industries, Inc.

Preparing the Burner

NOTE: The insert should be in place, with the gas line and vent attached and the firebacks installed (see owner’s manual

for further details).

1. Remove the rear burner.

2. Remove the 3 screws from the back of the rear burner using a ¼” nutdriver.

3. Attach the rear air deflector (NG or LP – see page 1 for details) to the rear burner with the screws removed earlier.

Removethisscrew.



430 GSR2 Traditional Log Set

Installation Instructions (SKU94500945)



Page 3 of 13 17601790.docx — 7/23/13 © Travis Industries, Inc.

4. Replace the rear burner and secure with the screw removed earlier. Note how the two tabs on the rear burner fit over

the front burner.

5. Install the rear log shelf.



430 GSR2 Traditional Log Set

Installation Instructions (SKU94500945)



Page 4 of 13 17601790.docx — 7/23/13 © Travis Industries, Inc.

6. The left and right log supports are shown below (the right side support has a 45° notch on the lower right tab).

Attach the front log supports with the 2 included nuts.



430 GSR2 Traditional Log Set

Installation Instructions (SKU94500945)



Page 5 of 13 17601790.docx — 7/23/13 © Travis Industries, Inc.

Rock Wool Placement

7. Place the rock wool as follows:

a. Brush the rock wool using a stiff brush in a loose, gauze-like layer.

TIP: Hold the rock wool in a tight wad with one hand while brushing with the other.

Note how the rock wool is approximately 1/8” thick over the burner ports.

TIP: Feel free to apply a generous amount of rock wool to gain a darker flame and a brighter coal bed.



430 GSR2 Traditional Log Set

Installation Instructions (SKU94500945)



Page 6 of 13 17601790.docx — 7/23/13 © Travis Industries, Inc.

Log and Ember Placement

The logs are fragile, especially after being exposed to heat.

•The burner must be correctly positioned before installing the logs. Make sure the burner is fully seated and screwed

into place.

8. Place the rear log over the rear log support. Note how the two legs on the log rest on the rear burner.

NG Installations

Move the rear log forward until the front edge rests on the tabs on the rear burner.

LP Installations

Move the rear log back until the rests against the back wall. Note how the log is 1/2” from the tabs on the rear burner.



430 GSR2 Traditional Log Set

Installation Instructions (SKU94500945)



Page 7 of 13 17601790.docx — 7/23/13 © Travis Industries, Inc.

9. Place the left middle log. Note how the index hole fits over the pin on the burner and is pushed back.

10. Place the right middle log. The index hole on the log fits over the pin on the burner and the left side is pushed back.



430 GSR2 Traditional Log Set

Installation Instructions (SKU94500945)



Page 8 of 13 17601790.docx — 7/23/13 © Travis Industries, Inc.

11. Place the center ember chunk. Note how the two tabs on the front log supports insert into the slots on the chunk.

12. Place the left front log. Note how the tab and nut on the front left log support insert into the holes on the log.



430 GSR2 Traditional Log Set

Installation Instructions (SKU94500945)



Page 9 of 13 17601790.docx — 7/23/13 © Travis Industries, Inc.

13. Place the right front log. Note how the tab and nut on the front left log support insert into the holes on the log.



430 GSR2 Traditional Log Set

Installation Instructions (SKU94500945)



Page 10 of 13 17601790.docx — 7/23/13 © Travis Industries, Inc.

14. Place the ember chunks as shown below. Note that half the bag of embers is left over.

15. Re-apply the rock wool over the ember chunks along the front burner.

TIP: Applying rock wool in the cracks of the logs (see below) helps to add small points of glow, but may dampen the

overall glow of the logs.

TIP: Natural gas (NG) can use more rock wool than propane (LP).

NOTE: Initial application of rock wool may cause “matting” over burner ports. Turning the unit on and then off again

will loosen the rock wool, resulting in a better flame.

Andere Handbücher für 430 GSR2

Inhaltsverzeichnis

Andere Travis Industries Kamin im Innenbereich Handbücher

Travis Industries

Travis Industries 864 HO NB GSR2 Bedienungsanleitung

Travis Industries

Travis Industries Flush Wood Plus Bedienungsanleitung

Travis Industries

Travis Industries 96900911 Bedienungsanleitung

Travis Industries

Travis Industries DVL GSR Bedienungsanleitung

Travis Industries

Travis Industries Large Flush Wood Insert Bedienungsanleitung

Travis Industries

Travis Industries 21 TRV GreenSmart Bedienungsanleitung

Travis Industries

Travis Industries 564 Clean Face GSR2 Bedienungsanleitung

Travis Industries

Travis Industries Fireplace Xtrordinair 864 Deluxe Bedienungsanleitung

Travis Industries

Travis Industries Pro Builder42 Linear Bedienungsanleitung

Travis Industries

Travis Industries 564 HO Bedienungsanleitung

Travis Industries

Travis Industries GreenSmart Fireplace 564 SS Bedienungsanleitung

Travis Industries

Travis Industries 36 CF ST/Pier Bedienungsanleitung

Travis Industries

Travis Industries Flush Wood Insert Bedienungsanleitung

Travis Industries

Travis Industries DVS FIREPLACE Bedienungsanleitung

Travis Industries

Travis Industries 864 HO GS Bedienungsanleitung

Travis Industries

Travis Industries DVS Ember-Fyre 2.1 Log Bedienungsanleitung

Travis Industries

Travis Industries 864 See Through Bedienungsanleitung

Travis Industries

Travis Industries Revolution 36CF Bedienungsanleitung

Travis Industries

Travis Industries 864 HO NB GSR2 Bedienungsanleitung

Travis Industries

Travis Industries 616 GSR2 Insert Bedienungsanleitung

Travis Industries

Travis Industries 564 HO Bedienungsanleitung

Travis Industries

Travis Industries DVS GSR Bedienungsanleitung

Travis Industries

Travis Industries DVL EF Insert Bedienungsanleitung

Travis Industries

Travis Industries 21 TRV GreenSmart Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch