Vermont Castings Encore 2550 Handbuch

Encore 2550 Service Procedure

REPLACING THE REFRACTORY PACKAGE

1. Open the damper and remove the handle stub (faucet). Use an Allen key wrench to loosen the Allen bolt in the

base of the damper handle stub. Pull the handle off the damper rod.

2. Remove the andirons; one 7/16" hex head bolt each.

3. Remove the throat hood; swing its bottom edge forward and

then

slide the hood to one side until the trailing

end drops from its supports. Take it out of the stove.

4. Use a hammer to tap the two wedges upward and out of the stove

5. Remove the lower fireback by pulling the upper edge toward the front of the stove. Then lift it and angle it out

of the stove through the front door. Scoop out any ashes in the bottom groove where the lower edge of the

lower fireback sits. Inspect the gasket on the back of the fireback and replace if damaged.

6. Remove the left and right air plates (inner walls). 7/16" hex head bolts at the top and bottom hold them in

place. These air plates have rope gaskets sealing them to the ends of the stove. With the bolts removed, pry the

forward edges of the plates toward the center of the firebox and remove them through the front or griddle

opening.

7. If the stove has a rear heatshield, remove the four bolts holding it in place and put it to one side. Four hex head

bolts hold it in place.

8. Remove the upper fireback. A hex head bolt on each side of the stove upper back holds the upper fireback

assembly in place. Remove the bolts and washers. From inside the firebox, pull the right hand end of the upper

fireback toward yourself; you may need to use a flat head screwdriver to pry the fireback loose from the rear

panel behind it. Slide over and down clearing the damper rod out of the left side.

9. Remove the catalyst access panel, part of the refractory assembly that houses the catalytic combustor. It is

friction fit into place. Wiggle it slightly to remove it. Take note of its position for reinstallation.

10. Remove the catalytic combustor, inspect and clean it and put it aside. Do not use compressed air to clean fly

ash out of the honeycomb.

11. Carefully pull the entire refractory package straight forward. Leave the steel heat exchangers in place in the

left and right sides of the stove back.

12. From the back of the stove, remove the secondary air access cover and put to one side with the two Phillips

screws. Unscrew the probe assembly and lift it off the linkage. Put it to one side.

13. Install the new refractory package. Replace the catalyst. Install the access panel.

14. Re-install the upper fireback assembly. If held in place with gasket, ensure it is in good condition before re-

installing. If held by cement, clean the grooves in the rear of the stove and the rear of the upper fireback before

re-cementing. Fasten it in place with two 1/4"-20 x 1-1/ 2" hex bolts and washers.

15. Attach the handle and its 'faucet' to the damper handle rod with the Allen bolt, and test the damper for smooth

action.

16. Re-install the left and right wear plates, each with their two bolts.

17. Re-install the lower fireback, and secure it with two wedges. Gently tap with a rubber mallet to make sure the

top of the fireback seats tightly to the bottom of the upper fireback. If not, clean the groove it sits in again

and/or loosen the two bolts that hold the upper fireback in place and re-install the lower fireback. Tighten the

upper fireback outer bolts when finished.

18. Replace the throat hood and re-install the andirons.

19. To reinstall the probe, pilot (with your hand) a small hole into the combustion package through the hole in the

back of the stove with a bit of smaller diameter than the probe. Replace the assembly by inserting it into the

hole, hooking it onto the linkage and screwing it back onto the firebox.

Andere Handbücher für Encore 2550

Inhaltsverzeichnis

Andere Vermont Castings Holzofen Handbücher

Vermont Castings

Vermont Castings Encore 2550 Montageanleitung

Vermont Castings

Vermont Castings Defiant 1610CE Montageanleitung

Vermont Castings

Vermont Castings Encore 1450CE Kurzanleitung

Vermont Castings

Vermont Castings Dutchwest Small 2460 Handbuch

Vermont Castings

Vermont Castings The Intrepid II 1990 Bedienungsanleitung

Vermont Castings

Vermont Castings Encore 2550CE Montageanleitung

Vermont Castings

Vermont Castings Defiant 1945 Montageanleitung

Vermont Castings

Vermont Castings Intrepid 1640 Montageanleitung

Vermont Castings

Vermont Castings Resolute Acclaim 2490 Montageanleitung

Vermont Castings

Vermont Castings WR1000L02 Bedienungsanleitung

Vermont Castings

Vermont Castings Defiant 1945 Bedienungsanleitung

Vermont Castings

Vermont Castings Encore 2040-CAT-C Bedienungsanleitung

Vermont Castings

Vermont Castings Defiant 1945CE Montageanleitung

Vermont Castings

Vermont Castings Defiant 1975T-CAT-C Montageanleitung

Vermont Castings

Vermont Castings Defiant 1945CE Montageanleitung

Vermont Castings

Vermont Castings Encore 2040-CAT-C Montageanleitung

Vermont Castings

Vermont Castings Windsor WR247001 Bedienungsanleitung

Vermont Castings

Vermont Castings Encore Flexburn 2040 Montageanleitung

Vermont Castings

Vermont Castings Aspen C3 Bedienungsanleitung

Vermont Castings

Vermont Castings Defiant 1610 Bedienungsanleitung

Vermont Castings

Vermont Castings Intrepid II Bedienungsanleitung

Vermont Castings

Vermont Castings Defiant 1945 Montageanleitung

Vermont Castings

Vermont Castings Encore 1450 Bedienungsanleitung

Vermont Castings

Vermont Castings The Intrepid II 1990 Bedienungsanleitung

Beliebte Holzofen Handbücher anderer Marken

Plamen

Plamen ECO MINIMAL 50 Bedienungsanleitung

RAIS

RAIS 800 Bedienungsanleitung

Henley

Henley Arklow Bedienungsanleitung

Jøtul

Jøtul F 500 Bedienungsanleitung

Englander

Englander BLUE RIDGE 100 Bedienungsanleitung

WoodPro

WoodPro WS-TS-1500 Bedienungsanleitung

Contura

Contura C 586W Bedienungsanleitung

Nordpeis

Nordpeis N-20 T Bedienungsanleitung

Palazzetti

Palazzetti EVA Konfigurationshandbuch

Lopi

Lopi 1250 Republic Bedienungsanleitung

Panadero

Panadero CAPRI 3V Programmierhandbuch

RAIS

RAIS RONDO 92 Bedienungsanleitung

RAIS

RAIS attika NEXO 100 GAS Bedienungsanleitung

ADURO

ADURO 15-3 Benutzerhandbuch

Pacific energy

Pacific energy SUPER 27 SPECTRUM Bedienungsanleitung

Avalon

Avalon Olympic 11190 Bedienungsanleitung

Ventis

Ventis HES350 Bedienungsanleitung

IronStrike

IronStrike Striker S160GL Bedienungsanleitung