AFe Power 77-46316 Bedienungsanleitung

advanced FLOW engineering

Instruction Manual P/N: 77-46316

Make: BMW Model: 125i/220i/ix/228i/ix (F2X) Year: 2012-2016 Engine: L4-2.0L (t) N20

Make: BMW Model: 328i/ix/GT/420i/ix/428i/ix (F3X) Year: 2012-2016 Engine: L4-2.0L (t) N20

Make: BMW Model: 430i/ix/GT (F3X) Year: 2017-2020 Engine: L4-2.0L (t) N20

Make: BMW Model: 528i/ix/Li/Lix (F1X) Year: 2010-2017 Engine: L4-2.0L (t) N20

Make: BMW Model: X1 28i/ix/X3 28i/ix/X4 28ix (E84/F2X) Year: 2012-2018 Engine: L4-2.0L (t) N20

Make: BMW Model: Z4 28i (E89) Year: 2011-2016 Engine: L4-2.0L (t) N20

Label Qty. Description Part Number

A 1 Module R77-46316

B 1 LED Switch 05-70029

C 2 Velcro (2 Inches) 05-01244

D 4 Cable Ties 05-60167

Note: Legal in California for use on race vehicles only. The use of this device on vehicles used on public

streets or highways is strictly prohibited in California and others states that have adopted California

emission regulations.

• Please read the entire instruction manual before proceeding.

• Ensure all components listed are present.

• If you are missing any of the components, call customer support at 951-493-7185.

• Ensure you have all necessary tools before proceeding.

• Do not attempt to work on your vehicle when the engine is hot.

• Disconnect the negative battery terminal before proceeding.

• Retain factory parts for future use.

Page 2

Warranty Information available at: https://afepower.com/contact#warranty

aFepower.com

Page 3

REMOVAL

Page 4

Refer to Figure A for Step 1.

Step 1: Before installing your aFe module, you will have to place your vehicles ECU in sleep mode. In

order to do this you will need to do the following:

- If the engine is cold, open the hood, close the doors lock the car and wait 30 seconds.

- If the engine is warm, open the hood, close the doors lock the car and wait 20 minutes.

- If the engine is warm and you can’t wait 20 minutes, disconnect the battery.

Note: Do NOT open the doors or start the vehicle when one of the sensors is

disconnected. This could create a check engine light.

Figure A

Refer to Figure B for Step 2.

Step 2: Locate the TMAP 1 and MAP sensors 2 . The MAP sensor is located on top of the intake

manifold under the engine cover, the TMAP sensor is located on the charge pipe, just before the

throttle body.

REMOVAL

Page 5

aFepower.com

Figure B

Refer to Figure C for Steps 3-4.

Step 3: Remove the engine cover to gain access to the MAP sensor then disconnect the MAP sensor.

Step 4: Locate the MAP sensor jumper harness on the aFe module. This is the shortest harness with

three wires on each connector. Plug the female connector of the module to the stock MAP

sensor, then the male connector of the module female connector of the engine harness.

Note: Make sure connections are fully engaged. Usually, connectors make a snapping

sound when fully engaged.

Figure C

Page 6

INSTALL

Refer to Figures D for Steps 5-6.

Step 4: Locate and disconnect the TMAP sensor.

Step 5: Locate the TMAP sensor jumper harness on the aFe Module. This is the longer harness

with four wires on each connector. Plug the male connector of the module to the stock

TMAP sensor, then take the female connector of the module and connect to the male

connector of the engine harness.

Figure D

Page 7

INSTALL

aFepower.com

Page 8

Refer to Figure E for Steps 7-8.

Step 7: Carefully route the switch cable behind steering wheel cover.

Step 8: Mount the Switch where desired on an open, ﬂat surface.

Figure E

INSTALL

aFepower.com

Page 9

Refer to Figure F for Steps 9-11.

Step 9: Remove the two 10mm nuts holding the foot trim panel.

Step 10: Route the switch cable through ﬁrewall and into the engine bay. Follow the main harness

through the grommet into the ﬁrewall. Plug the end of the cable to the module.

Step 11: Re-install foot trim panel.

Figure F

REMOVAL

Page 10

Refer to Figure G for Step 12.

Step 12: Mount the module in a safe location with adequate hood clearance, using the supplied Velcro

strip. Then, secure the wires and module away from any extreme heat and moving parts, with

the provided ties. Make sure all connections are secured and fully engaged.

Figure G

INSTALL

Andere aFe Power Autozubehör Handbücher

aFe Power

aFe Power 52-10002D Bedienungsanleitung

aFe Power

aFe Power SCORCHER BLUE 77-83043 Bedienungsanleitung

aFe Power

aFe Power 46-70022 Bedienungsanleitung

aFe Power

aFe Power 46-70049 Bedienungsanleitung

aFe Power

aFe Power 46-70162 Bedienungsanleitung

aFe Power

aFe Power MOMENTUM GT 50-70034S Bedienungsanleitung

aFe Power

aFe Power 51-82722 Bedienungsanleitung

aFe Power

aFe Power 50-70007D Bedienungsanleitung

aFe Power

aFe Power 77-43025 Bedienungsanleitung

aFe Power

aFe Power SCORCHER 77-44008 Bedienungsanleitung

aFe Power

aFe Power takeda 56-70043D Bedienungsanleitung

aFe Power

aFe Power 46-39102 Bedienungsanleitung

aFe Power

aFe Power 46-20299-B Bedienungsanleitung

aFe Power

aFe Power GT MOMENTUM 50-70087D Bedienungsanleitung

aFe Power

aFe Power 77-43023 Bedienungsanleitung

aFe Power

aFe Power Quantum 2500 Bedienungsanleitung

aFe Power

aFe Power 57-10018D Bedienungsanleitung

aFe Power

aFe Power 77-42008 Bedienungsanleitung

aFe Power

aFe Power SCORPION 79-21003L Bedienungsanleitung

aFe Power

aFe Power advanced FLO engineering Bedienungsanleitung

aFe Power

aFe Power advanced FLOW engineering Bedienungsanleitung

aFe Power

aFe Power 77-47001 Bedienungsanleitung

aFe Power

aFe Power 50-70009S Bedienungsanleitung

aFe Power

aFe Power SCORPION 79-21004L Bedienungsanleitung

Beliebte Autozubehör Handbücher anderer Marken

James Baroud

James Baroud Odyssey Bedienungsanleitung

Motorola

Motorola i50sx Bedienungsanleitung

Yakima

Yakima 9MM STANDARD BIKE MOUNT Bedienungsanleitung

Feniex

Feniex T3 Bedienungsanleitung

Kia

Kia E8300-4D000 Bedienungsanleitung

Brink

Brink 756843 Bedienungsanleitung

Whispbar

Whispbar K085W Bedienungsanleitung

v.link

v.link CI-VL2-PC-HSD Bedienungsanleitung

Viking

Viking Stack-Rack Kurzanleitung zur Einrichtung

Aries

Aries 203015 Bedienungsanleitung

Choetech

Choetech AT0005 Bedienungsanleitung

ZZ2

ZZ2 ZZAIR-PRO Bedienungsanleitung

Holman

Holman 4A80L Bedienungsanleitung

Thule

Thule 2075 Bedienungsanleitung

Motorola

Motorola T325 Bedienungsanleitung

TAUBENREUTHER

TAUBENREUTHER 16-3950 Installationsanleitung

DV8

DV8 FBJL-02 Bedienungsanleitung

Prorack

Prorack K1163 Bedienungsanleitung

aFe Power 77-46316 Bedienungsanleitung

Beliebte Autozubehör Handbücher anderer Marken