BLADEZ ION 150 Bedienungsanleitung

Product Handbook

FOR THE BLADEZ

ION 150

ELECTRIC POWER BOARD

Model: PB-SM812

PLEASE BE SAFE WHEN RIDING . . .

ALWAYS WEAR A HELMET AND OBEY ALL LAWS!

Powered Personal Transportation

Electric Power Board

IMPORTANT

BATTERY MAINTENANCE and

CHARGING INSTRUCTIONS:

1. You MUST Charge your scooter completely prior to initial use.

(Follow charging instructions in your Product Handbook).

2. Charge immediately after every use.

3. Charge before storage. You must charge every 30 days if not in use.

4. Only use the charger provided.

5. DO NOT allow your unit to Deep Discharge.

6. For safety purposes, DO NOT charge for over 24 hours.

7. Power shuts off automatically when forward movement stops. There

is no on/off switch.

Failure to follow proper CHARING INSTRUCTIONS will

VOID YOUR WARRANTY!

This PRODUCT IS NOT INTENDED FOR EXTREME or

OFF-ROAD Use! Please take care of your POWER BOARD!

DO NOT JUMP or ABUSE THIS PRODUCT!

DO NOT RIDE IN WET CONDITIONS!

Failure to follow these instructions will

VOID YOUR WARRANTY!

If you have any questions, please contact Bladez customer service

(866) 325-2339 or visit us on the web at www.ebladez.com

IMPORTANT

PLEASE READ THIS BEFORE USING

THIS PRODUCT

WARNING

This product does not conform to Federal Motor Vehicle Standards and is

not intended for operation on public streets, roads or highways. Serious

injury can result from the unsafe operations of this product. Operator can

minimize these risks by using certain safety equipment such as: safety

helmet, goggles, gloves, elbow and kneepads and appropriate footwear.

DO NOT operate this product in traffic, on wet, frozen, oily or unpaved

surfaces or under the influence of drugs and/or alcohol. Avoid uneven

surfaces, potholes, surface cracks and obstacles.

DO NOT use a water hose to clean this product. See Product Handbook for

more information.

This product is recommended for riders 16 YEARS OF AGE and older.

SAFETY

This product should not be used by persons without excellent vision,

balance, coordination, reflex, muscle and bone strength and good

decision-making capabilities.

This product should not be used by minors without adult supervision.

This product should not be used by persons unwilling or unable to take

responsibility for their own actions.

•The user of this product assumes ALL risks associated with its use. To

minimize these RISKS, the user must wear safety helmet, goggles,

gloves, elbow and knee pads and appropriate footwear.

•This product is ELECTRIC! DO NOT Ride this product in wet conditions,

puddles or rainy weather.

IF YOU HAVE ANY QUESTIONS OR NEED

ASSISTANCE,

PLEASE CALL BLADEZ, TOLL FREE AT:

(866) EBLADEZ

(866) 325-2339

MONDAY thru FRIDAY, 8am to 5pm PST

Or visit us on the web at: www.ebladez.com

NATIONWIDE NETWORK OF SERVICING DEALERS

FOR ALL YOUR POWER BOARD NEEDS

DO NOT TAKE YOUR

BLADEZ POWER BOARD BACK

TO THE STORE!

TABLE OF CONTENTS

BATTERY MAINTENANCE and CHARGING INSTRUCTIONS .................................... 1

GETTING TO KNOW YOUR BLADEZ POWER BOARD............................................... 5

BOX CONTENTS............................................................................................................ 6

GETTING STARTED ...................................................................................................... 6

CHARGING SYSTEM..................................................................................................... 7

FOLDING AND STORAGE............................................................................................. 8

RECOMMENDED TOOLS.............................................................................................. 9

BRAKING SYSTEM........................................................................................................ 9

TIRES AND WHEELS..................................................................................................... 9

BELT DRIVE................................................................................................................. 10

TROUBLESHOOTING GUIDE ..................................................................................... 11

OTHER QUESTIONS ................................................................................................... 11

GETTING TO KNOW YOUR BLADEZ POWER BOARD

Before operating your Bladez ION 150 ELECTRIC POWER BOARD, please familiarize

yourself with the following features:

1. Accelerator Lever 7. Rear Drum Brake

2. Brake Lever 8. 1 Amp Charger

3. Folding Handle 9. Charging Port

4. Deck

5. Kickstand

6. 150W DC Motor

BOX CONTENTS

Your Bladez ION should come complete with:

1. Bladez ION 150 ELECTRIC POWER BOARD

2. AC Wall Charger

3. Allen Wrench

4. Instruction Manual and Registration Card

GETTING STARTED

YOUR SCOOTER WILL COME CHARGED OUT OF THE BOX BUT YOU MUST

CHARGE YOUR ION 150 FOR 6-8 HOURS EVEN IF BOTH LIGHTS ON THE

CHARGER ARE GREEN PRIOR TO FIRST USE!

Before You Ride

1. The ION is shipped with the Handlebars

unattached.

2. You need to insert the accelerator and

brake levers into the handlebars. To insert,

remove the screws from the handlebar,

then insert the right and left handle and

align the holes. (Fig.1). Then insert the

screws through the holes and tighten the

nuts. (Fig. 2).

3. *Note: The Accelerator Lever (the one

with the shorter lever) goes on the right,

the Brake Lever goes on the left.

4. Make sure all of the bolts are tightened.

Also make sure to insert the bolts in the

correct way with the nuts on the back side

of the handlebars as in Fig. 2

5. Make sure the front tire is inflated to 40 PSI

as the tire may lose pressure during

shipping. For information on inflating the

tire, please refer to page 10. The rear tire is

solid rubber.

* Note: It is not advisable to operate your Power Board with low tire pressure. This will negatively affect

speed, handling and performance.

Fig. 1

Fig. 2

Batteries

The ION comes with 2 12V-6Ah batteries. The batteries are located under the deck. If

you have any questions about your batteries you can contact us here at Bladez. You

can visit our website at www.ebladez.com or call us toll free at (866) 325-2339.

CHARGING SYSTEM

This unit comes standard with a regulated 24V charger.

* Note that it is not advisable to leave your Power Board plugged in for more than 24

hours.

Charging

1. The scooter comes with a 1 amp charger

(Fig. 3). To charge your scooter, plug the

adapter into the charging jack on the

scooter (Fig. 4) and plug the charger into

the wall. One green LED will light indicating

that the charging cycle has begun. When

the batteries are fully charged you will see

two green LED’s light up. Your ION 150 is

ready to ride.

*Note: Full charging takes approx. 6-8 hours from full

discharge. It is recommended that you charge your

Power Board after each use.

*It is recommended on your initial charge that you charge the batteries for 6-8 hours even if both lights on

the charger are lit.

Unfolding

1. To unfold your ION, unhook the handlebar security clip. Hold the unit with one hand

while gently pulling up on the handlebars with the other.

2. Fully extend the handlebars to their upright position until you feel the mechanism

lock into place.

Fig. 3

Fig. 4

Riding

1. Make sure that all of the bolts and screws are tightened.

2. Raise the kickstand to its upright position.

3. The ION does not have an on/off switch. To ride, put one foot on the deck of the

ION. After pushing off with the other foot, squeeze the ACCELERATOR LEVER on

the right side of the handlebars. The Power Board will begin to move under its own

power. You must reach approximately 2 mph to activate the motor.

4. To stop, release the accelerator handle and depress the BRAKE LEVER (on the left

side of the handlebars). Depressing the brake will temporarily disengage power to

the motor.

5. When you feel your Power Board moving slow, sluggish or running out of power, it is

time to recharge. (See charging instructions on page 7)

*Note that there is still a charge in the batteries but it is not advisable to fully discharge

the batteries.

FOLDING AND STORAGE

1. To fold your Power Board. Using one

hand, gently pull up on the Folding

Handle, while lowering the handlebars

with the other (Fig. 5).

2. Lock the unit into the folded position

using the handlebar security clip (Fig.

6).

Fig. 5

Fig. 6

RECOMMENDED TOOLS

To adjust and service the Bladez ION Power Board you will need the following tools:

•

•Allen Keys: •3 / 4 / 5 / 6mm.

•

•Wrenches: •10 / 13 / 16 mm Open and ring combination.

•

•Philips Head Screwdriver

•

•Hand bicycle pump

•

•Oil, Grease or Lubricant (such as WD-40)

BRAKING SYSTEM

The ION uses a rear wheel drum brake system activated by a hand lever (on the left

side of the handlebar). The brake is activated by squeezing the BRAKE LEVER with

your left hand. The ION is equipped with a controller that temporarily disengages the

power to the motor when the BRAKE LEVER is depressed.

Practice braking on a smooth, dry surface to get used to the feel of the braking system.

Braking distance is affected by wet conditions and loose and uneven riding surfaces.

The brakes are relatively maintenance free and come adjusted to the proper setting

from the factory.

TIRES AND WHEELS

It is recommended that the front tire is inflated to 40 PSI. During shipping, the tire might

be slightly deflated. The rear tire is solid rubber.

To Inflate the Tire

1. Remove the valve stem cover to expose the

valve stem (Fig. 7).

2. Using a standard bicycle pump, inflate the

front tire to 40 PSI and replace the valve

stem cover.

The Bladez ION uses a pneumatic tire in the front and a solid tire in the rear. The front

wheel is actually two halves (split-rim) bolted together to make it easier to remove or

replace the tire. Empty all air from the tire, prior to loosening the bolts to split the rim.

Fig. 7

Andere Handbücher für ION 150

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere BLADEZ Roller Handbücher

BLADEZ

BLADEZ XTR Street PB-SM1806 Bedienungsanleitung

BLADEZ

BLADEZ PRESIDENT Bedienungsanleitung

BLADEZ

BLADEZ Travel Mate DKS280 Bedienungsanleitung

BLADEZ

BLADEZ PB-SM1816 Bedienungsanleitung

BLADEZ

BLADEZ ION 450 Bedienungsanleitung

BLADEZ

BLADEZ MOBY X Bedienungsanleitung

BLADEZ

BLADEZ ION 150 Handbuch

BLADEZ

BLADEZ MOBY XS PB-SE830PF Bedienungsanleitung

BLADEZ

BLADEZ E-LITE 250 Bedienungsanleitung

BLADEZ

BLADEZ Sport DKS200 Bedienungsanleitung

BLADEZ

BLADEZ PB-SE802 Bedienungsanleitung

BLADEZ

BLADEZ XTR-COMP IIPB-SM 818 Bedienungsanleitung

BLADEZ

BLADEZ PB-SM 817 Bedienungsanleitung

BLADEZ

BLADEZ DKS500 AMBASSADOR Bedienungsanleitung

BLADEZ

BLADEZ PB-SM804SA Bedienungsanleitung

BLADEZ

BLADEZ Travel Mate DKS280 Bedienungsanleitung

BLADEZ

BLADEZ XTR-HD Bedienungsanleitung

BLADEZ

BLADEZ DKS320 EXECUTIVE Bedienungsanleitung

Beliebte Roller Handbücher anderer Marken

TEKTRO

TEKTRO CHEETAH Bedienungsanleitung

PLAYTIVE

PLAYTIVE AS-2448 Bedienungsanleitung

Ebinger

Ebinger DONKEY XL Bedienungsanleitung

Flyer

Flyer Mountain Benutzerhandbuch

BackCountry eBikes

BackCountry eBikes Storm Bedienungsanleitung

equipmed

equipmed FreeRoam II Bedienungsanleitung

Yoto

Yoto Lion Bedienungsanleitung

WESTHILL BIKES

WESTHILL BIKES LINK Bedienungsanleitung

BAnff

BAnff eProdigy series Bedienungsanleitung

Winther

Winther 475 Bedienungsanleitung

Jetson

Jetson JBZL17 Bedienungsanleitung

First Choice Mobility

First Choice Mobility Roma Medical Corella S741 Bedienungsanleitung

Carrera

Carrera impel Bedienungsanleitung

Afikim

Afikim Superlight SL-3 Bedienungsanleitung

CareCo

CareCo ZOOM Bedienungsanleitung

Douglas

Douglas Vespa G.S. Bedienungsanleitung

Gazelle

Gazelle with BOSCH System Bedienungsanleitung

Wisper

Wisper 806fe Bedienungsanleitung