Bosch YS2180RA Bedienungsanleitung

SBB80BU

Rev. 04/14

GAS WATER HEATER

Owner’s Guide

Robert Bosch (Australia) Pty. Ltd.

Thank you for purchasing this Bosch Gas Water Heater.

Before using, please:

Read this manual completely for operation instructions.

Confirm warranty and proof of purchase.

Keep this manual where it can be found whenever necessary.

Installation must conform with local codes, or in the absence of local codes, AS/NZS5601, AS/

NZS3500.4, AS3000 wiring regulations and all Local Building, Water and Gas fitting regulations.

Bosch

reserves the right to discontinue, or change at any time, the designs and/or specifications of

its products without notice.

- Do not store or use petrol or other flammable vapours and liquids in the

vicinity of this or any other appliance.

-WHAT TO DO IF YOU SMELL GAS

• Do not try to light the appliance.

•Do not touch any electrical switches; Do not use electrical appilances,

including

the phone” inside the building.

•Immediately call you gas supplier, from a safe distance from the gas leak.

If the information in this manual is not followed exactly, a fire or explosion

may result causing property damage, personal injury, or death.

WARNING

- To be installed and serviced only by an authorised person

- This appliance is not suitable for use as a pool heater

Models YS2180RA YS2180RA5 YS2180RAP YS2180RA5P

YS1780RA YS1780RA5 YS1780RAP YS1780RA5P

Operating Instructions

* Note : This appliance requires a minimum flow rate to operate of 2.5 litres/min., water fixtures with a

flow rate of 7.5 litres/min. or higher are recommended.

For optimum performance we reommend installation of Bosch optional temperature controllers.

*SBB80BU*

Operating Instructions

Prohibited Don’t

touch.

Don’t

disassemble

the equipment.

Don’t touch

with a wet

hand.

No flame.

High

Temperature.

To prevent damage to property and injury to the user, the icons shown below will be used to warn of

varying levels of danger.

Every indication is critical to the safe operation of the water heater and must be understood and observed.

Potential dangers from accidents during installation and use are divided into the following four

categories. Closely observe these warnings; they are critical to your safety.

Other icons

DANGER

WARNING

CAUTION

DANGER indicates an imminently hazardous situation which,

if not avoided, will result in death or serious injury.

WARNING indicates a potentially hazardous situation which, if not

avoided, could result in death or serious injury.

CAUTION indicates a potentially hazardous situation which, if not

avoided, may result in minor or moderate injury.

CAUTION used without the safety alert symbol indicates a potentially

hazardous situation which, if not avoided, may result in property damage.

CAUTION

Be sure

to do. Earth

Electric

Shock.

DANGER

Icons warning of risk level

Important Safety Information

This is the safety alert symbol. It is used to alert you to potential personal injury hazards.

Obey all safety messages that follow this symbol to avoid possible injury or death.

Vapours from flammable liquids will explode and catch fire causing death or severe burns.

Do not use or store flammable products such as petrol, solvents or

adhesives in the same room or area near the water heater.

Prohibited

Keep flammable products:

1. Far away from the water

heater.

2. In approved containers.

3. Tightly closed.

4. Out of children’s reach.

Vapours:

1. Cannot be seen.

2. Vapours are heavier than air.

3. Go a long way on the floor.

4. Can be carried from other rooms

to the main burner by air currents.

Vapours

Hot Water Heater temperatures over 50 °C can cause severe burns instantly or

death from scalding.

Children, disabled and elderly are at the highest risk of being scalded.

Feel water temperature before bathing or showering.

Temperature limiting valves are available, ask licensed installer.

Prohibited

(Continued)

Operating Instructions

No flame.

(Continued)

Prohibited

WARNING

Be sure

to do.

When a gas leak is noticed:

1. Stop use immediately

2. Close the gas valve

Contact your gas supplier immediately

If you detect abnormal combustion

or abnormal odours, or during an

earthquake, tornado or fire:

1. Turn off the hot water supply

Turn off the power to the water heater

Turn off gas and water supply valve.

4. Call the Bosch Helpline

AU 1300 30 70 37 NZ 0800 54 33 52.

Be sure

to do.

(Continued)

Check the temperature

of the running hot water

before entering the

shower.

Check the temperature

before stepping into

the bath tub.

High

Temperature.

A. This water heater does not have a

pilot. It is equipped with an

ignition device that automatically

lights the burner. Do not try to

light the burner by hand.

BEFORE OPERATING smell all

around the water heater area for

evidence of leaking gas. Be sure

to smell next to the floor because

some gas is heavier than air and

will settle on the floor.

WHAT TO DO IF YOU SMELL GAS.

• Do not try to light any

appliance.

• Do not touch any electrical

switch; do not use any phone

in your building.

•

Immediately call your gas

supplier.

Follow the gas supplier’s

instructions.

C. Use only your hand to turn the

gas valve knob. Never use tools.

If the knob will not turn by hand,

don’t try to repair it. Call a

qualified service technician.

Force or attempted repair may

result in a fire or explosion.

D. Do not use this water heater if

any part has been under water.

lmmediately call a qualified

service technician to inspect the

water heater and to replace any

damaged parts.

Do Not Install Indoors.

This will cause carbon monoxide poisoning and a potential fire hazard.

Indoor

Leave the proper clearance between

the water heater and nearby objects

(trees, timber, boxes with flammable

materials etc.).

Be sure

to do.

Left side:

Min. 500mm Right side:

Min. 500mm

Front:

Sug. 600mm

Upper:

Min. 500mm

Operating Instructions

Important Safety Information

Do not allow small children to play

unsupervised in the bathroom.

Do not allow small children to

bathe unsupervised.

Do not touch the power

cord with wet hands.

Electric

Shock.

Don’t touch

with a wet

hand.

Prohibited

Contact Bosch before using with

a solar pre-heater.

Contact a qualified service

technician for any necessary

repairs, service or maintenance.

Don’t

disassemble

the equipment.

Be sure

to do.

Be sure the gas matches

the gas on the data

plate

(inside of frontcover)

gas type label (right side

of casing).

Installation and service must be

performed by a qualified installer,

service agency or the gas supplier.

Be sure

to do.

Be sure

to do.

Do not place combustibles such as

laundry, newspapers, oils etc. near

the heater.

Prohibited

Do not use combustible chemicals

such as oil, petrol, benzene etc. in

the near the water heater or the

exhaust vent.

Do not store or use petrol or other

flammable vapours and liquids in the

vicinity of this or any other appliance.

Prohibited

Do not place or use a spray can

near the water heater or the exhaust

vent.

Do not use hair spray or spray

detergent in the vicinity of the

heater.

Prohibited

Unit

(Continued)

Do not place the unit in an indoor en-

vironment by means of adding walls

and ceiling (Do not enclose using

corrugated sheets, etc.)

Carbon monoxide poisoning or fire may

occur as a result.

Unit

Prohibited

Carbon Monoxide Poisoning

Hazard. Do not install this water

heater in a mobile home, recreation

vehicle or on a boat.

Prohibited

Ex. For Natural Gas (YS2180RA)

Operating Instructions

CAUTION

Be sure to electrically earth the

unit.

Keep power cord free of dust.

Earth

Be sure

to do.

Do not use the water heater for

other than hot water supply, shower

and bath.

Prohibited

Do not cover the water heater, store

trash or debris near it, or in any way

block the flow of fresh air to the unit.

Do not turn off the water heater

while someone is bathing.

Prohibited

Do not use a broken or modified power

cord. Do not bind, bend or stretch

power cords. Do not scratch, modify,

or subject them to impact or force.

Do not touch the exhaust vent

during or immediately after

operation of the water heater.

Do not install in locations where

excessive dust or debris will be

in the air.

Prohibited

Don’t

touch.

Prohibited

Be sure

to do.

To prevent burns or scalding, turn

off the power button and wait until

the equipment cools before per-

forming maintenance.

Operating Instructions

Important Safety Information

CAUTION

Do not drink water that has been inside the

unit for an extended period of time. Do not

drink the first use of hot water from the

unit in the morning.

Clean the filter on the water inlet as

frequently as required. The quality of your

local water will affect the frequency required.

Keep the area around the unit clean.

If boxes, weeds, cobwebs, cockroaches etc. are in

the vicinity of the unit, damage or fire can result.

Do not install the equipment where the

exhaust will blow on walls or windows.

Treat hard, acidic or otherwise impure

supply water with approved methods to

ensure full warranty coverage.

Problems resulting from scale formation

are not covered by the warranty.

Preventing damage from freezing ( p.22)

Damage can occur from frozen water within the

device and pipes even in warm environments.

Be sure to read below for appropriate measures.

Repairs for damage caused by freezing are not

covered by the warranty.

Do not use parts other than those specified

for this equipment.

Power must be switched on at all times for

antifrost protection to work.

If it is snowing, check the air inlet, exhaust

gas vent and exhaust vent terminal for

blockage.

Do not disassemble the remote controller.

Do not use benzene, oil or fat detergents

to clean the remote controller.

This may cause deformation.

Do not get the remote controller wet.

YPRS67XBN and YPRP62XBN are water resistant,

too much water can cause damage.

YPRM67XBN is not water resistant.

Do not splash water on the remote

controller. Do not expose the remote

controller to steam.

Do not locate the remote controller near stoves or

ovens, this may cause damage or failure.

Do not run water through the unit when

unit is not on.

When discharging hot water, make sure the unit is ON.

If water is run through the unit with the unit

OFF, water may condense inside the unit and cause

incomplete combustion or damage to the internal

electrical components.

Operating Instructions

Important Safety Information....................................................................... 2

Contents ........................................................................................................ 7

General Parts

Main Unit.................................................................................................... 8

Names and Functions of Controllers

Main Controller (YPRM67XBN) ................................................................ 9

Bathroom Controller (YPRS67XBN) ....................................................... 10

Sub Controller (YPRP62XBN) ................................................................. 11

Initial Operation ........................................................................................... 12

Clock Adjustment ........................................................................................ 13

Setting and Using the Water Heater........................................................... 14

Controller Priority Function ........................................................................ 16

Muting the Remote Controller .................................................................... 17

Bath Fill Function ........................................................................................ 18

Call Function ................................................................................................ 21

Frost Protection ........................................................................................... 22

Regular Maintenance................................................................................... 23

Troubleshooting .......................................................................................... 25

Follow-up Service ........................................................................................ 29

Specifications .............................................................................................. 30

Manufacturer’s Warranty ............................................................................ 35

Contents

Operating Instructions

Main Unit

General Parts

Outdoor Wall Mounted, Power flue Model

* The above illustration shows an example of installation.

The exact installation configuration may be slightly different.

Front Cover

Air Inlet

Water Supply Valve

Gas Supply Valve

Water Drain Valve (with Water Filter)

(Inside Water Inlet) (p.24)

Flue Collar

Hot Water Pipe

External Weatherproof Power Point

Operating Instructions

Main Controller (YPRM67XBN) <Optional>

* Before use, remove the protective sheet from the remote controller surface.

What is actually displayed depends on how the water heater is set.

Names and Functions of Controllers

Error Code

A number will flash if

a failure occurs.

(p.28)

Burner On Indicator

When this indicator is lit,

the hot water temperature

can be set. ( p.16)

Priority Indicator

When burning, the

indicator is lit.

( p.15, 19)

Clock

When Time Set button

is pushed, the clock is

displayed. (p.13)

Setting Buttons

For setting the hot

water temperature

( p.14 -15)

For other settings.

Operation Button

For turning the water

heater on or off.

Bath Fill Button

To activate Bath Fill.

To set Bath Fill

temperature.

( p.18 -20)

For setting the amount

of water that is delivered.

( p.18 -20)

Bath Fill Temperature Indicator

When this indicator is lit,

bath fill temperature is

displayed. ( p.18 -20)

Temperature setting

(Eg.: 40°C)

Bath Fill Temperature setting

(Eg.: 40°C)

(p.18 -21)

Bath Fill Volume setting

Display

The illustration below shows the remote controller display.

What is actually displayed depends on how the water heater is set.

Display

Time Set Button

To set or lndicate Time

of day. (p.13)

Bath Fill Volume Button

Operating Instructions

Bathroom Controller (YPRS67XBN) <Optional>

* Before use, remove the protective sheet from the remote controller surface.

What is actually displayed depends on how the water heater is set.

Setting Buttons

For setting the hot

water temperature

( p.14 -15)

For other settings.

Operation Button

For turning the water

heater on or off.

Bath Fill Button

To activate Bath Fill.

To set Bath Fill

temperature.

( p.18 -20)

Error Code

A number will flash if

a failure occurs.

(p.28)

Burner On Indicator

When this indicator is lit,

the hot water temperature

can be set. ( p.16)

Priority Indicator

When burning, the

indicator is lit.

( p.15, 19)

Bath Fill Temperature Indicator

When this indicator is lit,

bath fill temperature is

displayed. ( p.18 -20)

Temperature setting

(Eg.: 40°C)

Bath Fill Temperature setting

(Eg.: 40°C)

(p.18 -20)

Bath Fill Volume setting

Display

The illustration below shows the remote controller display.

What is actually displayed depends on how the water heater is set.

Display

Call Button

To sound alarm at all

remote controls. (p.21)

Priority Button

To transfer control from

another remote

( p.16)

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Bosch Boiler Handbücher

Bosch

Bosch 125HX Bedienungsanleitung

Bosch

Bosch Tronic 3000T Sicherheitsleitfaden

Bosch

Bosch C950ES Bedienungsanleitung

Bosch

Bosch GWH 425 EF Bedienungsanleitung

Bosch

Bosch Greentherm 9800 SE 160/199 Bedienungsanleitung

Bosch

Bosch TR5500T Series Bedienungsanleitung

Bosch

Bosch Integra 500 Bedienungsanleitung

Bosch

Bosch JUNKERS UNIDOMO ELAFLUX ED 18-2 E Bedienungsanleitung

Bosch

Bosch T2400S 8 ND 23 Bedienungs- und Montageanleitung

Bosch

Bosch Greentherm T9900 SE 160 Bedienungsanleitung

Bosch

Bosch 715ES Bedienungsanleitung

Bosch

Bosch WR 11 G Series Technisches Dokument

Bosch

Bosch GWH 635 ES Bedienungsanleitung

Bosch

Bosch 330-PN-N Bedienungsanleitung

Bosch

Bosch BC3200RABC3200RA5 Bedienungsanleitung

Bosch

Bosch Tronic 3000T Bedienungsanleitung

Bosch

Bosch C 1210 ESC Referenzhandbuch

Bosch

Bosch TR2000TF Series Bedienungsanleitung

Bosch

Bosch 125B LP Bedienungsanleitung

Bosch

Bosch Stora WP 400 PK Kurzanleitung

Bosch

Bosch Tronic 5000C Referenzhandbuch

Bosch

Bosch TR7000R 18/21 DESOB Bedienungsanleitung

Bosch

Bosch TR4000R 6 ET Bedienungsanleitung

Bosch

Bosch Tronic 1500 TOR Bedienungsanleitung

Beliebte Boiler Handbücher anderer Marken

Kenmore

Kenmore 153.582400 Bedienungsanleitung

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Bedienungsanleitung

clage

clage E-Mini Series Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-180 Bedienungsanleitung

Bradford White

Bradford White EF Series Bedienungsanleitung

Eccotemp

Eccotemp 40-H Bedienungsanleitung

Dimplex

Dimplex ECSd125-580 Leitfaden

Dux

Dux 32FCR6N Bedienungsanleitung

Noritz

Noritz N-132M Gebrauchsanweisung

TESY

TESY GCV7/4S 10047 Technisches Datenblatt

A.O. Smith

A.O. Smith Gphe 50 Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Fehlerbehebungshandbuch

Koryo

Koryo KWHZF15Y Bedienungsanleitung

Pentair

Pentair PSC-14-4-02 Bedienungsanleitung

GE 40M06AAG Montageanleitung

Thermor

Thermor AEROMAX SPLIT 2 Bedienungsanleitung

American Hometec

American Hometec AHQ-B03X Bedienungsanleitung

PVI

PVI MAXIM Bedienungsanleitung