Bradley S19-220SS Bedienungsanleitung

Installation

P.O. Box 309, Menomonee Falls, WI USA 53052-0309

PHONE 800.BRADLEY (800.272.3539) FAX 262.251.5817

bradleycorp.com

215-158SS Rev. M; ECN 12-05-033

Page 1 of 4 3/19/2013

S19-220SS

Stainless Steel Wall-Mounted

Eyewash

Table of Contents

Pre-Installation Information ................... 2

Installation Instructions ...................... 3

Assembly of Components .................... 4

Parts List ................................. 4

S19-220SS Installation

3/19/2013 Bradley • 215-158SS Rev. M; ECN 12-05-033

WARNING

Read this installation manual completely to ensure proper installation, then file it

with the owner or maintenance department. Compliance and conformity to drain

requirements and other local codes and ordinances is the responsibility of the installer.

Separate parts from packaging and make sure all parts are accounted for before

discarding any packaging material. If any parts are missing, do not begin installation

until you obtain the missing parts.

Flush the water supply lines before beginning installation and after installation is

complete. Test the unit for leaks and adequate water flow. Main water supply to the

eyewash should be “ON” at all times. Provisions shall be made to prevent unauthorized

shutoff.

The ANSI Z358.1 standard requires an uninterrupted supply of flushing fluid. Bradley

plumbed emergency fixtures require a minimum of 30 PSI (0.21 MPa) flowing pressure.

Flushing fluid should be tepid per ANSI Z358.1.

The inspection and testing results of this equipment should be recorded weekly

to verify proper operation. This equipment should be inspected annually to ensure

compliance with ANSI Z358.1.

Workers who may come in contact with potentially hazardous materials should be

trained regarding the placement and proper operation of emergency equipment per

ANSI Z358.1.

For questions regarding the operation or installation of this product, visit www.

bradleycorp.com or call 1-800-BRADLEY.

Product warranties may also be found under “Product Information” on our web site at

www.bradleycorp.com.

Installation

THIS

SIDE

Packing List

•

P.O.Box309, Menomonee Falls, WI 53051

TESTTHISUNIT EACHWEEK

Test-operatevalve(s) each week and sign below.

Reportany malfunctions immediately.

Ventil(e)wöchentlich im Testbetrieb prüfen, bestätigt

durchUnterschrift. Jegliche Störung sofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESESGERÄT1ST WÖCHENTLICH ZU PRÜFEN.

ESSAIHEBDOMADAIRE

Testle fonctionnement des valves chaque semaine et

signeen bas. S'il y à quelque chose qui ne va pas fait

unrapport immédiatement.

P.O.BOX 309, MENOMONEE FALLS, WI 53052-0309 USA

TEL:1-800-BRADLEY FAX: (262-251-5817)

http://www.bradleycorp.com

114-051

Installation S19-220SS

Bradley • 215-158SS Rev. M; ECN 12-05-033 3/19/2013

Installation Instructions

Supplies Required:

• (2)1/4"boltsandwallanchorsformountingwall

bracket

• Pipesealant

• Pipingto1/2"NPTwatersupplyinletonunit

• Pipingto1-1/4"NPTdrainoutletforeyewash

• Sign-mountinghardware

Step 1: Install wall bracket

NOTE: The top of the eyewash heads should be

33"–45" (838mm–1143mm) from the ﬂoor.

1. Positionthewallbracketonthewall.

2. Usingthewallbracketasatemplate,mark

theboltholelocationsonthewallORinstall

twosuitablefasteners(suppliedbyinstaller)

for1/4"boltsinthewallatthemarkedhole

locations.

3. Boltthewallbrackettothewallorwall

fastenersusing3/8"bolts(suppliedby

installer).

Step 2: Assemble eyewash

components

1. Assembletheremainingcomponentsas

shownonpage4.

•Applypipesealant(suppliedbyinstaller)to

allmale-threadedpipejoints.

Step 3: Connect water supply

1. Connectthewatersupplypipingtothe1/2"

NPTinletontheeyewash(pipingsuppliedby

installer).

2. Connectdrainpipingtothe1-1/4NPTdrain

outletontheeyewash(pipingsuppliedby

installer).

3. Mountthesafetysigntoawallorpipe

usingsignmountinghardware(suppliedby

installer).

4. Openthewatersupplylines.Testforleaks

andadequatewaterflow.

36"

(914mm)

Suggested

Height To

Floor

30-1/2"

(775mm)

Suggested

Height To

Floor

Wall

S19-220SS Installation

3/19/2013 Bradley • 215-158SS Rev. M; ECN 12-05-033

Assembly of Components and Parts List

1.1

1.2

1.3

1.4

1.5

1.6

1.9

1.8

1.10

1.11

1.14

1.7

P.O.Box 309, Menomonee Falls, WI 53051

TESTTHISUNIT EACH WEEK

Test-operatevalve(s) each week and sign below.

Reportany malfunctions immediately.

Ventil(e)wöchentlich imTestbetrieb prüfen, bestätigt

durchUnterschrift. Jegliche Störung sofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESESGERÄT 1ST WÖCHENTLICH ZU PRÜFEN.

ESSAIHEBDOMADAIRE

Testle fonctionnement des valves chaque semaine et

signeen bas. S'il y à quelque chose qui ne va pas fait

unrapport immédiatement.

P.O.BOX 309, MENOMONEE FALLS,WI 53052-0309 USA

TEL:1-800-BRADLEY FAX:(262-251-5817)

http://www.bradleycorp.com

114-051

1.12 1.13

4.1

NOTE: Items 1.1–1.14 come preassembled as Item 1.

Item Part No. Qty Description

1 S90-318 1 StainlessSteelEyewashAssy.

1.1 111-049 1 Inlet-DrainFitting

1.2 124-028 1 Gasket

1.3 140-645 1 Wall Bracket

1.4 124-024 1 Gasket

1.5 187-053 1 StainlessSteelEyewashBowl

1.6 173-009 1 Cup Strainer

1.7 S21-074 1 Supply Pipe

1.8 113-1159 1 Spacer, Drain

1.9 S05-131 1 EyewashYoke

1.10 107-371 2 Dust Cover

1.11 269-912 1 SwivelStem

1.12 124-055 2 QuadRing

Item Part No. Qty Description

1.13 S57-148 1 SprayRingAssembly

1.14 110-209 1 Acorn Nut

2 113-965 1 Pipe,StainlessSteel1/2"x3-1/2"

3 269-241 1 StreetElbow

4 S27-328 1 1/2"BallValvewithNut

4.1 110-248 1 Nut 316 Stainless Steel

5 S08-336 1 Handle Assembly

6 269-167 1 Tailpiece

7 114-051 1 SafetySign

8 204-421 1 EmergencyTag

9 142-002DA 1 Washer

10 153-372R 1 Adapter

For proper handle and ball valve kits,

refer to instruction sheet 215-1774.

Prepack S45-2285 includes Items 1.4, 1.6, 1.7, 1.8

Prepack S05-127 includes Items 1.11, 1.12, 1.13, 1.14

Prepack S30-109 includes Items 4, 5, 9, 10

Inhaltsverzeichnis

Andere Bradley Sanitärprodukte Handbücher

Bradley

Bradley Terrazzo WF2613 Bedienungsanleitung

Bradley

Bradley Verge LVLD Series Bedienungsanleitung

Bradley

Bradley HN-400 Bedienungsanleitung

Bradley

Bradley S19-120FMBF Bedienungsanleitung

Bradley

Bradley 594 Bedienungsanleitung

Bradley

Bradley Indoor Furnishings Kurzanleitung

Bradley

Bradley S19-310BF Bedienungsanleitung

Bradley

Bradley Advocate AV Series Bedienungsanleitung

Bradley

Bradley MG Series Bedienungsanleitung

Bradley

Bradley S19-280 Series Bedienungsanleitung

Bradley

Bradley Express SS Series Bedienungsanleitung

Bradley

Bradley S19-260 Bedienungsanleitung

Bradley

Bradley Express EXD Series Bedienungsanleitung

Bradley

Bradley LC800 Bedienungsanleitung

Bradley

Bradley P19-234 Bedienungsanleitung

Bradley

Bradley Express ELX Series Bedienungsanleitung

Bradley

Bradley Express SS Series Bedienungsanleitung

Bradley

Bradley S19-600 Bedienungsanleitung

Bradley

Bradley FREQUENCY FL-1H Bedienungsanleitung

Bradley

Bradley S19-230T Bedienungsanleitung

Bradley

Bradley S19-270C Bedienungsanleitung

Bradley

Bradley S19-222 Bedienungsanleitung

Bradley

Bradley 1C TouchTime Bedienungsanleitung

Bradley

Bradley S19-310DCBF Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Kohler

Kohler K-6228 Montageanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Kohler

Kohler K-12183 Montageanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Kohler

Kohler Centerset K-15240 Montageanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

Kohler

Kohler Mira Eco Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema