Bradley Terrazzo WF2613 Bedienungsanleitung

IMPORTANT

Read this entire installation manual

to ensure proper installation.

Flush all the water supply lines

before making connections.

Main water supply to the unit

should be ON at all times.

This installation manual and parts

list should be filed by the owner’s

maintenance department.

215-609 Rev. J; EN 06-915B

Page 1 of 26 4/6/2007

P.O. Box 309, Menomonee Falls, WI 53052-0309

TEL. 1-800-BRADLEY FAX 262-251-5817

http://www.bradleycorp.com

Table of Contents

Pre-Installation Information . . . . . . . . . . . . . . . . . 2

Semi-Circular Washfountain Dimensions . . . . . . . 3

Rough-In Specifications . . . . . . . . . . . . . . . . . . . 4-5

Drain Rough-In Specifications . . . . . . . . . . . . . . . .6

Pedestal Assembly and Drain Spud Installation . .7-8

Supplies w/Optional Soap Dispenser (A/O drains) .....9-10

Supplies w/Optional Soap Dispenser (B/H drains) ....11-12

Valve Assembly . . . . . . . . . . . . . . . . . . . . . . . . . .13

Installing the Operating Rod . . . . . . . . . . . . . . . .14

Soap Recommendations and Maintenance . . . . . .15

Check Valve Troubleshooting . . . . . . . . . . . . . . .15

Soap Valve Repair Parts . . . . . . . . . . . . . . . . . . . .16

Stop, Strainer and Check Valve Repair Parts . . . .17

Sprayhead Troubleshooting/Repair Parts . . . . . . 18

Foot Valve Breakdown and Repair Kit . . . . . . . .19

Manual Mixing Valve Repair Parts . . . . . . . . . . .20

Angle Volume Control Valve Repair Parts . . . . . .21

Vernatherm™ Mixing Valve Maintenance . . .22-24

Cleaning and Maintenance Instructions . . . . .25-26

WF2613

Classic Corner 54"

Washfountain with Foot

Control

Installation

Instructions

UPC Certified

UPC

Classic Terrazzo®Corner Washfountain with Foot Control

WF2613 Installation Instructions

Bradley Corporation • 215-609 Rev. J; EN 06-915B

2 4/6/2007

Pre-Installation Information

Operation

The system used on your Bradley Foot Controlled Washfountain actuates the valve when the foot rail is

depressed. The valve then stays open until the foot rail is released.

Supplies Required:

• (6) lag bolts, screws or other fasteners to anchor washfountain pedestal to floor.

• 1" hot and cold water supply lines and fittings (refer to rough-ins on pages 4-5).

• Reducing fittings and 1/2" nominal copper tubing for models with supplies from above.

• Standard P-trap (refer to rough-ins on pages 4-5). Vented trap supplied by Bradley when

required.

• 2" drain lines and fittings (refer to rough-ins on pages 4-5).

• Pipe sealant and plumber’s putty.

• 1-1/2" vent pipe on types vented through washfountain column (see page 3 for lengths required).

NOTE: Supply lines for one or two washfountains should be 1"; for three washfountains, 1-1/4". For

more than three washfountains pipe size should increase proportionally. Vent pipe to be 1-1/2" on

models vented through washfountain.

Bradley Classic Washfountain Warranty Information

Product warranties may be found under “Product Information” on our website at www.bradleycorp.com

Material A B C D E F G H J K

Inches 19 29-1/4 39-1/8 47-5/8 36-1/4 56 26 28 37-1/4 10-1/4

Millimeters 483 743 994 1210 921 1422 660 711 946 260

Classic Terrazzo®Corner Washfountain with Foot Control

Installation Instructions WF2613

Bradley Corporation • 215-609 Rev. J; EN 06-915B 34/6/2007

Length of Tie Pipe Required for Vent through Washfountain Column

54" Less Soap Dispenser 21-1/2" (546mm)

54" With Soap Dispenser 30" (762mm)

54" Less Soap Dispenser With Towel Dispenser 55-1/2" (1410mm)

54" With Soap Dispenser With Towel Dispenser 48" (1219mm)

54" With Cube Adapter 32" (813mm)

54" With Cube Adapter With Towel Dispenser 50" (1270mm)

54" With Cube Adapter And Soap Dispenser 40" (1016mm)

Type Pipe Length

NOTE: Drain must be connected with 2" schedule 40 welded wrought iron pipe, minimum, to provide

lower support for this installation. Vent or support pipe must be of the same material in 1-1/2".

For juvenile height, subtract 4" from dimensions A-E.

Corner Washfountain Dimensions

6" (152)

ADJUST TO TOWEL DISPENSER

MOUTING HOLES

Classic Terrazzo®Corner Washfountain with Foot Control

WF2613 Installation Instructions

Bradley Corporation • 215-609 Rev. J; EN 06-915B

4 4/6/2007

RIGHT WALL LEFT WALL

Std. Ht. Juv. Ht. Std. Ht. Juv. Ht.

11-1/4" to 13-1/4" 9-1/4" to 10-1/4" 6" to 11" 6" to 8-1/2"

286mm to 337mm 235mm to 260mm 152mm to 279mm 152mm to 216mm

12" 8-1/4" 12" 8-1/4"

305mm 210mm 305mm 210mm

DIM.

Rough-In Specifications

Use this range of heights

when hook-up is made with

a coupling and nipple (2"

drain through wall must not

interfere with diagonal

frame member on pedestal).

Rough-In Notes:

1. All pipes and fittings not furnished by Bradley are shown in broken lines.

2. Supply lines for one to two washfountains should be 1"; for three washfountains 1-1/4"; for more than three washfountains, pipe sizes

should be increased proportionately.

3. Overhead supplies must be reduced to 1/2" copper tube to pass through support tube.

4. Check valve inlets are 1/2" NPT.

5. Dimensions shown in parentheses are millimeters.

Type A

Off-line vent with supplies from below. Type O

Off-line vent with supplies from above.

54” (1372)

WASHFOUNTAIN

TOP VIEW

SIDE VIEW SIDE VIEW

TOP VIEW

COLD

HOT

TRAP

54” (1372)

WASHFOUNTAIN

BOWL

HOT

COLD

TRAP

2” NPT DRAIN THRU FLOOR

(OPTIONAL) STUB UP 3” (76)

ABOVE FLOOR

1” NPT SUPPLIES THRU

FLOOR (STUB UP 2-1/2” (64)

ABOVE FLOOR)

CENTER OF

WASHFOUNTAIN

10”

(254) 10”

(254)

18-1/2”

(470)

10”

(254)

8-1/2”

(216)

9-3/4”

(248)

9-3/4”

(248)

12-3/4”

(324)

7-1/4”

(184)

7-1/4”

(184)

18-1/2”

(470)

12-3/4”

(324)

8-3/8”

(213)

8-3/8”

(213) 10”

(254)

TRAP FOR

WALL

OUTLET ONLY

DRAIN THRU

FLOOR

TRAP LOCATED

BELOW FLOOR

4”

(102)

DRAIN

THRU WALL

SUPPLIES

THRU

WALL

TRAP FOR WALL

OUTLET ONLY

DRAIN

TRHU WALL

SUPPLIES AND DRAIN THRU FLOOR,

TRAP LOCATED BELOW FLOOR.

1” NPT SUPPLIES FROM ABOVE

MUST REDUCE TO 1/2” NOM.

COPPER TUB ON THESE

CENTERS TO PASS THRU WASH

FOUNTAIN

4”

(102)

2” NPT

DRAIN

THRU WALL

(STUB OUT

SUIT TRAP

DIMENSION)

(OPTIONAL)

1” NPT

SUPPLIES

THRU WALL

(OPTIONAL)

4-1/2”

(114)

CLEARANCE HOLE

CENTER OF

WASHFOUNTAIN

2” NPT DRAIN THRU FLOOR

(OPTIONAL) STUB UP 3” (76)

ABOVE FLOOR

2” NPT DRAIN

THRU WALL

(STUB OUT TO

SUIT TRAP

DIMENSION)

(OPTIONAL)

CLEARANCE HOLE

RIGHT WALL

LEFT WALL

FLOOR

LEFT WALL

RIGHT WALL

LEFT WALL

FLOOR

NOTE: UPC AND IPC RESTRICT THE VERTICAL

DISTANCE FROM THE FIXTURE OUTLET TO THE TRAP

WEIR TO NOT MORE THAN 24". CHECK STATE AND

LOCAL CODES FOR VARIANCES.

Classic Terrazzo®Corner Washfountain with Foot Control

Installation Instructions WF2613

Bradley Corporation • 215-609 Rev. J; EN 06-915B 54/6/2007

RIGHT WALL LEFT WALL

Std. Ht. Juv. Ht. Std. Ht. Juv. Ht.

11-1/4" to 13-1/4" 9-1/4" to 10-1/4" 6" to 11" 6" to 8-1/2"

286mm to 337mm 235mm to 260mm 152mm to 279mm 152mm to 216mm

DIM.

Rough-In Specifications

Use this range of heights

when hook-up is made with a

coupling and nipple (2" drain

through wall must not

interfere with diagonal frame

member on pedestal).

Classic Terrazzo®Corner Washfountain with Foot Control

WF2613 Installation Instructions

Bradley Corporation • 215-609 Rev. J; EN 06-915B

6 4/6/2007

Installation Instructions

Step 1: Installing the Drain

1. Rough-in supply and drain piping as required for your installation (see pages 4-5 for rough-ins).

2. Assemble the drain to the dimension shown in Figure 1 or Figure 2.

NOTE: All piping shown in dotted lines to be supplied by the installer.

Figure 1

(mm)

Types A and O Types B and H

Figure 2

Vented Trap

(111-024)

Classic Terrazzo®Corner Washfountain with Foot Control

Installation Instructions WF2613

Bradley Corporation • 215-609 Rev. J; EN 06-915B 74/6/2007

Installation Instructions continued . . .

Step 2: Assembling the Pedestal

1. Assemble the legs and scuff base panels with the 5/16" carriage bolts and nuts provided (see

Figure 3).

2. Attach the pedestal frame members, the rear support members and the rear legs with the 5/16"

stove bolts and nuts provided (see Figure 3).

3. Add the foot levers and operating cross to the pedestal assembly (see Figures 3 and 4).

4 Attach the spacers, foot rail and spring pins to the foot valve levers (the bend in the center of the

foot rail must be pointing up) (see Figures 3 and 5).

Diagonal Support

(194-043) STD Hgt.

(194-043A) JUV. Hgt.

Figure 3

Figure 4 Figure 5

Classic Terrazzo®Corner Washfountain with Foot Control

WF2613 Installation Instructions

Bradley Corporation • 215-609 Rev. J; EN 06-915B

8 4/6/2007

Installation Instructions continued . . .

Step 3: Anchoring the Pedestal to the Floor and Installing Drain

IMPORTANT: FOR PROPER DRAINAGE, THE BOWL AND PEDESTAL MUST BE

LEVEL WHEN THEY ARE SECURED TO THE FLOOR .

WARNING: USE SUITABLE LIFTING EQUIPMENT TO POSITION THE BOWL AND

PEDESTAL ASSEMBLY. HANDLE WITH CARE! FAILURE TO DO SO

COULD RESULT IN SERIOUS PERSONAL INJURIES.

1. Position the pedestal assembly.

2. Anchor the pedestal assembly to the floor with suitable anchors (supplied by installer) (Figure 6).

3. Place the bowl on the pedestal using suitable lifting equipment.

CAUTION: Bowl Surface is smooth. Use suitable lifting equipment to position the

bowl and pedestal assembly. Handle with CARE!

4. Screw the spud into the drain with the lock nut and washer between the drain and bowl (see

Figure 7).

5. Tighten the spud and locknut against the bowl (see Figure 7).

Figure 6 Figure 7

STRAINER

(S45-067)

SPUD

112-015 (Terrazzo)

112-016 (Bradstone

and Stainless Steel)

BOWL

WASHER

(142-068)

LOCKNUT

(161-021)

Classic Terrazzo®Corner Washfountain with Foot Control

Installation Instructions WF2613

Bradley Corporation • 215-609 Rev. J; EN 06-915B 94/6/2007

Installation Instructions continued . . .

Step 4a: Installing Supplies with Optional Soap Dispenser for A/O drain units

NOTE: See Step 4b for units with type B/H drain.

NOTE: For models with optional paper towel dispensers, tie pipe assembly, or shroud, see separate

instruction sheets and Step 4b for units with type B/H drain.

NOTE: Flush the supply lines before making connections.

1. Install the hemmed end (not sharp end) of the support tube (welded seam toward the walls) with the

gasket into the bowl (see Figure 8 on page 10).

2. Using pipe sealant, connect the supply pipe to the sprayhead and place on top of the support tube. Make

sure spray holes point away from the wall.

3a.For Unit with Soap Option:

1. Place the upper tie bar on top of the sprayhead and join the upper and lower tie rod (the longer threaded

rod) with the coupling nut and setscrews (Tie bar must be parallel to wall).

2. Insert the tie rod assembly through the hole in the upper tie bar and secure with the lower tie bar, tie rod

nut and setscrew from below (see Figure 8).

3. Install the spacer, soap dispenser, dispenser cover and restraining bracket and secure with the acorn nut

and socket setscrew.

4. Continue installation with Step 5 on Page 13.

3b.For Unit without Soap Option:

1. Place the dispenser cover on the sprayhead. Thread the acorn nut onto the lower tie rod, run the tie rod

through the dispenser cover and restraining bracket and secure from below with the lower tie bar, tie rod

nut and socket setscrew (see Figure 8).

2. Continue installation with Step 5 on Page 13.

Classic Terrazzo®Corner Washfountain with Foot Control

WF2613 Installation Instructions

Bradley Corporation • 215-609 Rev. J; EN 06-915B

10 4/6/2007

Installation Instructions continued . . .

Operating Rod

(S14-007, Std. Ht.)

(S14-007A, Juv. Ht.)

Lower Tie Bar

(159-009)

Tie Rod Nut

(110-064)

& Set Screws

(160-208)

Gasket

(125-011)

Support Tube

(S57-005, 54") Sprayhead

(S05-054C)

Upper Tie Bar

(159-009A)

(notched at corners)

Soap

Dispenser

Soap Dispenser Lid

TYPE "A" DRAIN

TYPE "O" DRAIN

Acorn Nut (110-052A)

& Set Screw (160-093)

Dispenser Cover

Upper Tie Rod

(176-010)

Spacer

(113-155A) PARTS SHOWN IN

BOX ARE FOR

UNITS WITH SOAP

DISPENSER.

Coupling Nut (110-051D)

Set Screws (160-208)

Lower Tie Rod

(176-008A, 54")

Sprayhead Supply

Pipe (3/8")

(See Figure 10 on page 13

for valving assembly)

HOT

COLD

(Supplies from above)

CORNER RESTRAINING

BRACKET (S70-061E)

(FITS AROUND SUPPORT TUBE)

UPPER TIE BAR

(159-009A)

Figure 8

Andere Handbücher für Terrazzo WF2613

Inhaltsverzeichnis

Andere Bradley Sanitärprodukte Handbücher

Bradley

Bradley S19-120FMBF Bedienungsanleitung

Bradley

Bradley Terreon Classic WF2500 Series Bedienungsanleitung

Bradley

Bradley S19-120SSBF Bedienungsanleitung

Bradley

Bradley S19-220DCSS Bedienungsanleitung

Bradley

Bradley S19-430A Bedienungsanleitung

Bradley

Bradley HN200 Bedienungsanleitung

Bradley

Bradley FL-3H Bedienungsanleitung

Bradley

Bradley Terreon WF3204 Bedienungsanleitung

Bradley

Bradley S19-220TSS Bedienungsanleitung

Bradley

Bradley S19-230 Bedienungsanleitung

Bradley

Bradley EXD-2N Bedienungsanleitung

Bradley

Bradley TDB3108 Bedienungsanleitung

Bradley

Bradley S19-600 Bedienungsanleitung

Bradley

Bradley EXPRESS MG-EXT Bedienungsanleitung

Bradley

Bradley Express SS-3N/TT/STD Bedienungsanleitung

Bradley

Bradley AERADA 1000 Series S53-326 AC Bedienungsanleitung

Bradley

Bradley Sentry SN2004/IR Bedienungsanleitung

Bradley

Bradley TouchTime MG Series Bedienungsanleitung

Bradley

Bradley Express MG Series Bedienungsanleitung

Bradley

Bradley Verge LVQ Series Bedienungsanleitung

Bradley

Bradley MG-2/BIR3 Bedienungsanleitung

Bradley

Bradley Express Crescent CRS-2/IR Bedienungsanleitung

Bradley

Bradley SN2003 Bedienungsanleitung

Bradley

Bradley Express ELX Series Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Kohler

Kohler K-6228 Montageanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Kohler

Kohler K-12183 Montageanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Kohler

Kohler Centerset K-15240 Montageanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

Kohler

Kohler Mira Eco Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema