Bradley S67-504 Bedienungsanleitung

S67-504

Push Button Metering Air

Valve For 1WCA AST

Econowall Shower

Installation

Instructions

215-1342 Rev. B; ECN 14-03-023

Page1of 4

Table of Contents

Pre-Installation Information . . . . . . .... . . . .2

Metering Air Valve Repair parts ........ . .3

Metering Air Valve Troubleshooting .......4

P.O. Box 309, Menomonee Falls, WI 53052-0309

1-800-BRADLEY +1 262 251 6000

http://www.bradleycorp.com

IMPORTANT

Read this entire installation manual

to ensure proper installation.

Flush all water supply lines before

making connections.

File these instructions with the

owner or maintenance department.

1WCA AST Econowall Shower

Push Button Metering Air Valve For 1WCA AST Econowall Shower

S67-504 Installation Instructions

2Bradley • 215-1342 Rev. B; ECN 14-03-023

Pre-Installation Information

Overview

The Push Button Air Valve, when installed onto Bradley's 1WCAASTEconowall shower, controls

water flow throughtheuse of pneumaticmetering.Whenthepushbutton is released,thevalve is acti-

vated, which then delivers water to the fixture for a preset length of time.

Components

Supply Inlet: The supply inlet to the metering valve is 3/4" IPS.

Supplies required for installation of valve and shower

• 3/4" IPS tempered water supply piping and fittings

• 3/4" IPS piping

• 1/4"-20 wall anchors and fasteners

• Teflon pipe sealant

NOTE: See Instruction Sheet 215-924 for rough-in and installation information.

Bradley Metering Valve Shower Warranty

Bradley Corporation warrants to commercial and institutional purchasers only each unit free from

defects in material and workmanship under normal use and service upon the following terms and

conditions:

1. This warranty is limited to replacing or repairing, at our option, transportation charges prepaid by

the purchaser, any Bradley unit or part thereof which our inspection shall show to have been

defective within the limitations of this warranty.

2. The period during which shower valve components are warranted is one (1) year, measured from

the date of our invoice.

3. This warranty does not cover installation or any other labor charges and does not apply to any

units which have been damaged by accident, abuse, improper installation or improper mainte-

nance.

4. The replacement or repair of defective units as stated in this warranty shall constitute the sole

remedy of the purchaser and the sole liability of Bradley Corporation under this warranty. Bradley

Corporation shall not otherwise be liable under any indirect damages caused by defects in the

repair or replacement thereof.

5. This warranty extends only to commercial and institutional purchaser and does not extend to any

others, including consumer customers of commercial institutional purchasers.

6. This warranty is in lieu of all other warranties, expressed or implied, including any implied war-

ranty of merchantability or fitness for a particular purpose or otherwise.

3Bradley • 215-1342 Rev. B; ECN 14-03-023

Push Button Metering Air Valve For 1WCA AST Econowall Shower

Installation Instructions S67-504

Metering Air Valve Repair Parts (for 1WCA AST Econowall Shower)

NOTE: Some components

not shown (for clarity).

MOUNTING

BRACKET

(140-827)

PLUG

(153-409)

REDUCING

BUSHING

(169-076A)

TUBING

CONNECTOR

(269-960)

TUBING

CONNECTOR

(269-960)

NUT

(110-115)

FILTER

WASHER

(269-1188)

NIPPLE

(113-339)

"L" FITTING

(269-1186)

3/8" DIA.

TUBING

(269-783C)

1/8" DIA.

TUBING

(169-960G)

FLEXIBLE

HOSE

(269-653)

PUSH BUTTON

ASSEMBLY

(S45-1712)

INCLUDES LABEL

(204-501)

Push Button Metering Air Valve For 1WCA AST Econowall Shower

S67-504 Installation Instructions

4Bradley • 215-1342 Rev. B; ECN 14-03-023

Metering Air Valve Troubleshooting

Problem: Water is dripping from the showerhead.

Cause: Debris on valve seat or orifices.

Solution: Clean and inspect the valve seat.

1. Remove screws and disassemble metering valve, leaving the

plastic upper body firmly snapped together.

2. Clean the valve seat and inspect for deep gouges or scratches.

Replace if necessary.

3. Remove all debris that may be clogging center hole of plastic

diaphragm assembly.

4. Remove any debris clogging the off-center hole in the rubber

diaphragm.

Problem: Valve will not shut off.

Cause: Timing mechanism is clogged.

Solution: Clean timing mechanism:

1. Remove the entire timer assembly from the valve body. If the valve shuts off immediately, the

problem is in the timer assembly. If the valve does not shut off immediately, the problem is due

to debris in the valve seat or orifice.

2. If compressed air is available, blow water and debris from perforated metal sleeve of timing

mechanism.

3. Reinstall the timer assembly into the valve body.

4. Turn the adjusting screw in all the way but do not force screw.

5. Turn adjusting screw out to desired cycle time.

Cause: There is an air leak

Solution: Check assembly:

1. Check all tubing and fittings for proper assembly.

2. Tighten all screws which hold valve together.

Problem: Timing can not be adjusted for more than5seconds.

Cause: There is an air leak

Solution: Check assembly:

1. Check all tubing and fittings for proper

assembly.

2. Tighten all screws which hold valve together.

Problem: Push button does not work

properly.

Cause: Air volume may not be sufficient to operate

valve.

Solution: Check for leaks and lubricate U-cup:

1. Check all fittings for air leaks.

2. Disassemble push button and lubricate U-cup

seal (see push button assembly diagram.

Timer Assembly

Push Button Assembly

Inhaltsverzeichnis

Andere Bradley Sanitärprodukte Handbücher

Bradley

Bradley Express SS Series Bedienungsanleitung

Bradley

Bradley SN2003 Bedienungsanleitung

Bradley

Bradley S19-465EFW Bedienungsanleitung

Bradley

Bradley Terreon TDB3104 Bedienungsanleitung

Bradley

Bradley LC840 Bedienungsanleitung

Bradley

Bradley S19-600 Bedienungsanleitung

Bradley

Bradley Terreon WF3204 Bedienungsanleitung

Bradley

Bradley S96-085 Bedienungsanleitung

Bradley

Bradley Verge LVGD Series Bedienungsanleitung

Bradley

Bradley S19-120BF Bedienungsanleitung

Bradley

Bradley S53-325 Bedienungsanleitung

Bradley

Bradley S19-200B Bedienungsanleitung

Bradley

Bradley 1C TouchTime Bedienungsanleitung

Bradley

Bradley Equa-Flo Pressure Balancing Valve Bedienungsanleitung

Bradley

Bradley TBD3103 Bedienungsanleitung

Bradley

Bradley Terreon Quadra-Fount MF2949/IR Bedienungsanleitung

Bradley

Bradley EXD-2N Bedienungsanleitung

Bradley

Bradley FREQUENCY FL-1H Bedienungsanleitung

Bradley

Bradley Terreon Classic WF2500 Series Bedienungsanleitung

Bradley

Bradley Indoor Furnishings Kurzanleitung

Bradley

Bradley Verge LVQ Series Bedienungsanleitung

Bradley

Bradley Express SS Series Bedienungsanleitung

Bradley

Bradley S19-260 Bedienungsanleitung

Bradley

Bradley S96-050 Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Kohler

Kohler K-6228 Montageanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Kohler

Kohler K-12183 Montageanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Kohler

Kohler Centerset K-15240 Montageanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

Kohler

Kohler Mira Eco Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema