Bradley S19-465EFW Bedienungsanleitung

P.O. Box 309, Menomonee Falls, WI USA 53052-0309

PHONE 1-800-BRADLEY FAX (262) 251-5817

http://www.bradleycorp.com

Installation

215-1170 Rev. K; EN 06-515

Page 1 of 4 6/23/06

S19-465EFW

Deck-Mounted Hand-Held

Drench Hose

Table of Contents

Pre-Installation Information . . . . . . . . . . . . . . .2

Installation Instructions . . . . . . . . . . . . . . . . . . .3

Assembly of Components . . . . . . . . . . . . . . . . .4

Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

S19-465EFW Installation

6/23/06 Bradley Corporation • 215-1170 Rev. K; EN 06-515

Pre-Installation Information

Operation

Water flows when the handle on the valve is squeezed and remains open while squeezed.

Components

Sprayhead: Perforated sprayhead provides soft spray for cleansing eyes and face. The integral flow

control assures safe, steady flow under varying water supply conditions from 30-90 PSI. NOTE: The

ANSI Z358.1 standard requires an uninterruptible supply of flushing fluid at a minimum 30 PSI flow

pressure.

Drench Hose: The 8' (2438mm) hose has a 3/8" IPS male thread with a removable 1/2" x 3/8"

female reducing coupling.

Supplies Required

• 1/2" IPS water supply

• Sign-mounting hardware

• Backflow prevention device as required by UPC, IPC and/or local plumbing codes

WARNING

Read this installation manual completely to ensure proper installation, then file it

with the owner or maintenance department. Compliance and conformity to drain

requirements and other local codes and ordinances is the responsibility of the

installer.

Separate parts from packaging and make sure all parts are accounted for before

discarding any packaging material. If any parts are missing, do not begin

installation until you obtain the missing parts.

Flush the water supply lines before beginning installation and after installation is

complete. Test the unit for leaks and adequate water flow. Main water supply to

the eyewash should be “ON” at all times. Provisions shall be made to prevent

unauthorized shutoff. Flushing fluid should be tepid per ANSI Z358.1.

The inspection and testing results of this equipment should be recorded weekly

to verify proper operation. This equipment should be inspected annually to

ensure compliance with ANSI Z358.1.

Workers who may come in contact with potentially hazardous materials should

be trained regarding the placement and proper operation of emergency

equipment per ANSI Z358.1.

For questions regarding the operation or installation of this product, visit

www.bradleycorp.com or call 1-800-BRADLEY.

Product warranties may also be found under ”Product Information” on our web

site at www.bradleycorp.com.

Installation

THIS

SIDE

Packing List



P.O.Box309, MenomoneeFalls, WI 53051

TESTTHISUNITEACHWEEK

Test-operatevalve(s) each week and sign below.

Reportany malfunctions immediately.

Ventil(e)wöchentlich im Testbetrieb prüfen, bestätigt

durchUnterschrift. Jegliche Störung sofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESESGERÄT1STWÖCHENTLICHZUPRÜFEN.

ESSAIHEBDOMADAIRE

Testle fonctionnement des valves chaque semaine et

signeen bas. S'il y à quelque chose qui ne va pas fait

unrapport immédiatement.

P.O.BOX309, MENOMONEE FALLS,WI 53052-0309 USA

TEL:1-800-BRADLEY FAX: (262-251-5817)

http://www.bradleycorp.com

114-051

Installation Instructions

Step 1: Prepare deck for installation

1. Rough-in 1/2" IPS supply piping from

wall where drench hose is desired

(piping supplied by installer).

2. Select desired location in deck for drench

hose and drill a 1-5/16" (34mm) diameter

hole.

3. Install the drain plug using the washers

and locknut provided (see Figure 2 and

the parts list, page 4).

Step 2: Install drench hose

1. Install the drench hose assembly as

shown in Figure 2 on page 4.

Step 3: Connect water supply

1. Connect the end of the drench hose to the

1/2" IPS water supply.

2. Mount the safety sign to the wall using

the sign-mounting hardware supplied by

installer.

3. Open the water supply line. Test for

leaks and adequate water flow.

Installation S19-465EFW

Bradley Corporation • 215-1170 Rev. K; EN 06-515 6/23/06

11-3/4"

(298mm)

2-1/4" (57mm)

MININUM

DISTANCE

FROM WALL

5-1/4"

(133mm)

Figure 1

Assembly of Components and Parts List

S19-465EFW Installation

6/23/06 Bradley Corporation • 215-1170 Rev. K; EN 06-515

P.O. Box 309, Menomonee Falls, WI 53051

TEST THIS UNIT EACH WEEK

Test-operate valve(s) each week and sign below.

Report any malfunctions immediately.

Ventil(e) wöchentlich im Testbetrieb prüfen, bestätigt

durch Unterschrift. Jegliche Störung sofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESES GERÄT 1ST WÖCHENTLICH ZU PRÜFEN.

ESSAI HEBDOMADAIRE

Test le fonctionnement des valves chaque semaine et

signe en bas. S'il y à quelque chose qui ne va pas fait

un rapport immédiatement.

4.2

4.3

4.1 4

P.O.BOX 309, MENOMONEE FALLS,WI 53052-0309 USA

TEL:1-800-BRADLEY FAX:(262-251-5817)

http://www.bradleycorp.com

114-051

1.1

Figure 2

1 S27-265 1 Valve Assembly

1.1 269-661 1 Valve Handle only

2 153-337 1 Adapter

3 153-380 1 Adapter

4 S05-148 1 Sprayhead Assembly

4.1 S05-147 1 Angled EFW Assembly

4.2 S05-135 2 Sprayhead

4.3 S53-063 2 Dust Cover

5 S29-092 1 Drain Flange Assembly

6 125-001CE 1 Washer, Rubber

7 169-875 1 Washer

8 S89-002 1 3/8" Yellow Tube

9 169-059 1 Reducing Coupling

10 204-421 1 Emergency Tag

11 114-051 1 Safety Sign

Item Part No. Qty Description Item Part No. Qty Description

Inhaltsverzeichnis

Andere Bradley Sanitärprodukte Handbücher

Bradley

Bradley Express MG-2/NDT Bedienungsanleitung

Bradley

Bradley Express MG Series Bedienungsanleitung

Bradley

Bradley Verge LVRD Series Bedienungsanleitung

Bradley

Bradley Terreon Quadra-Fount MF2944/IR Bedienungsanleitung

Bradley

Bradley S19-230B Bedienungsanleitung

Bradley

Bradley Terrazzo WF2600 Series Bedienungsanleitung

Bradley

Bradley Express SS-2 Infrared-to-Touch Time Bedienungsanleitung

Bradley

Bradley Express SS Series Bedienungsanleitung

Bradley

Bradley SN2003 Kurzanleitung

Bradley

Bradley S53-325 Bedienungsanleitung

Bradley

Bradley SS-2/IR/JUV Bedienungsanleitung

Bradley

Bradley EXD-2N Bedienungsanleitung

Bradley

Bradley S19-220ABF Bedienungsanleitung

Bradley

Bradley Advocate AV Series Bedienungsanleitung

Bradley

Bradley Aerada 900 Series Bedienungsanleitung

Bradley

Bradley Advocate AV Series Bedienungsanleitung

Bradley

Bradley E19-120A Bedienungsanleitung

Bradley

Bradley Terreon WF3204 Bedienungsanleitung

Bradley

Bradley OmniDeck 3000 Series Bedienungsanleitung

Bradley

Bradley Terreon Classic WF2500 Series Bedienungsanleitung

Bradley

Bradley Terreon TDB3104 Bedienungsanleitung

Bradley

Bradley Express SS-3 Infrared-to-Touch Time Bedienungsanleitung

Bradley

Bradley S19-630 Bedienungsanleitung

Bradley

Bradley Verge LVGD1 Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Kohler

Kohler K-6228 Montageanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Kohler

Kohler K-12183 Montageanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Kohler

Kohler Centerset K-15240 Montageanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

Kohler

Kohler Mira Eco Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema