Bradley S19-220TSS Bedienungsanleitung

P.O. Box 309, Menomonee Falls, WI USA 53052-0309

PHONE 1-800-BRADLEY FAX (262) 251-5817

http://www.bradleycorp.com

Installation

215-158TSS Rev. F; EN 06-532E

Page 1 of 5 4/24/07

S19-220TSS

Stainless Steel Wall-Mounted

Eye/Face Wash

Table of Contents

Pre-Installation Information . . . . . . . . . . . . . . . .2

Installation Instructions . . . . . . . . . . . . . . . . . . . .3

Assembly of Components . . . . . . . . . . . . . . . . . .4

Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

S19-220TSS Installation

4/24/07 Bradley Corporation • 215-158TSS Rev. F; EN 06-532E

WARNING

Read this installation manual completely to ensure proper installation, then file it

with the owner or maintenance department. Compliance and conformity to drain

requirements and other local codes and ordinances is the responsibility of the

installer.

Separate parts from packaging and make sure all parts are accounted for before

discarding any packaging material. If any parts are missing, do not begin

installation until you obtain the missing parts.

Flush the water supply lines before beginning installation and after installation is

complete. Test the unit for leaks and adequate water flow. Main water supply to

the eyewash should be “ON” at all times. Provisions shall be made to prevent

unauthorized shutoff.

The ANSI Z358.1 standard requires an uninterruptible supply of flushing fluid at a

minimum 30 PSI (0.21 MPa) flowing pressure. Flushing fluid should be tepid per

ANSI Z358.1.

The inspection and testing results of this equipment should be recorded weekly

to verify proper operation. This equipment should be inspected annually to

ensure compliance with ANSI Z358.1.

Workers who may come in contact with potentially hazardous materials should be

trained regarding the placement and proper operation of emergency equipment

per ANSI Z358.1.

For questions regarding the operation or installation of this product, visit

www.bradleycorp.com or call 1-800-BRADLEY.

Product warranties may also be found under ”Product Information” on our web

site at www.bradleycorp.com.

Installation

THIS

SIDE

Packing List

P.O.Box309, MenomoneeFalls, WI 53051

TESTTHISUNITEACHWEEK

Test-operatevalve(s) each week and sign below.

Reportany malfunctions immediately.

Ventil(e)wöchentlich im Testbetrieb prüfen, bestätigt

durchUnterschrift. Jegliche Störung sofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESESGERÄT1STWÖCHENTLICHZUPRÜFEN.

ESSAIHEBDOMADAIRE

Testle fonctionnement des valves chaque semaine et

signeen bas. S'il y à quelque chose qui ne va pas fait

unrapport immédiatement.

P.O.BOX309, MENOMONEE FALLS,WI 53052-0309 USA

TEL:1-800-BRADLEY FAX: (262-251-5817)

http://www.bradleycorp.com

114-051

Installation S19-220TSS

Bradley Corporation • 215-158TSS Rev. F; EN 06-532E 4/24/07

Installation Instructions

NOTE: Flush the water supply line before

beginning installation.

Supplies Required:

• (2) 1/4" wall fasteners and bolts

• Pipe sealant

• Piping to 1/2" IPS water supply inlet on

unit

• Piping to 1-1/4" IPS drain outlet

• Sign-mounting hardware

Step 1: Install inlet drain fittings

NOTE: Top of eyewash heads should be

33"-45" (838mm-1142mm) from floor.

1. Position the inlet drain fitting over the

1-1/4" drain outlet pipe from wall.

2. Using the inlet drain fitting as a

template, mark the bolt hole locations

on wall OR install three suitable

fasteners (supplied by installer) for

1/4" bolts in the wall at the marked

hole locations (see Figure 1).

3. Bolt the inlet drain fitting to the wall

or wall fasteners using 1/4" bolts

(supplied by installer).

Step 2: Assemble eyewash

1. Assemble eyewash components as

shown in Figure 2 on page 4.

• Apply pipe sealant (supplied by installer) to all male-threaded pipe joints.

• Use a strap wrench around pipes when tightening to prevent marring.

Step 3: Connect water supply

1. Connect the water supply piping (supplied by installer) to the 1/2" IPS inlet on the eyewash.

2. Connect the tailpiece to the 1-1/4 IPS drain outlet on the eyewash (see Figure 2 on page 4).

3. Mount the safety sign to a wall or pipe using sign-mounting hardware (supplied by installer).

4. Open the water supply lines. Test for leaks and adequate water flow.

8-1/8"

(206mm)

13-1/2"

(343mm)

Ø 10-3/4" (273mm)

15-3/8" (391mm)

(102mm)

8-3/8"

(213mm)

7-1/2"

(191mm)

5-1/4"

(133mm)

Wall

4-1/2"

(114mm)

36"

(914mm)

Suggested

Height

To Floor

29-1/4"

(743mm)

Suggested

Height

To Floor

Figure 1

Assembly of Components

S19-220TSS Installation

4/24/07 Bradley Corporation • 215-158TSS Rev. F; EN 06-532E

P.O.Box 309, Menomonee Falls, WI 53051

TESTTHISUNIT EACHWEEK

Test-operate valve(s) each week and sign below.

Report any malfunctionsimmediately.

Ventil(e) wöchentlichim Testbetrieb prüfen, bestätigt

durch Unterschrift.Jegliche Störungsofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESESGERÄT1ST WÖCHENTLICH ZU PRÜFEN.

ESSAI HEBDOMADAIRE

Test le fonctionnement desvalveschaque semaine et

signe en bas. S'il y à quelque chose qui ne va pasfait

un rapport immédiatement.

1/2" IPS

Supply Inlet

P.O.BOX 309, MENOMONEE FALLS,W I 53052-0309 USA

TEL:1-800-BRADLEY FAX:(262-251-5817)

http://www.bradleycorp.com

114-051

1-1/4" IPS

Drain Outlet

4.1

1.1

1.2

1.3

1.4

1.5

1.6

1.7

1.10

1.9

1.11

1.12

1.8

NOTE: Items 1.1 -1.12 come presasembled as Item 1.

Figure 2

Installation S19-220TSS

Bradley Corporation • 215-158TSS Rev. F; EN 06-532E 4/24/07

Parts List

1 S90-362 1 Stainless Steel Eyewash Assembly

1.1 111-049 1 Inlet-Drain Fitting

1.2 124-028 1 Gasket

1.3 140-645 1 Wall Bracket

1.4 124-024 1 Gasket

1.5 187-053 1 Stainless Steel Bowl

1.6 173-009 1 Cup Strainer

1.7 113-1151 1 Supply Stem

1.8 S05-131 1 Eyewash Yoke

1.9 S05-135 2 EFW Sprayhead

1.10 S53-063 2 Dust Cover

1.11 153-333 1 Pipe Plug

1.12 269-874 1 Cap Plug

2 113-965 1 Pipe, Stainless Steel 1/2" x 3-1/2"

3 269-241 1 Street Elbow

4 S27-287 1 1/2" Ball Valve with Nut

4.1 161-151 1 Nut only

5 S08-338 1 Handle Assembly

6 269-167 1 Tailpiece

7 114-051 1 Safety Sign

8 204-421 1 Emergency Tag

9 142-002DA 1 Washer

Item Part No. Qty Description Item Part No. Qty Description

Prepack S45-1789 includes Items 1.4, 1.6, 1.7

Inhaltsverzeichnis

Andere Bradley Sanitärprodukte Handbücher

Bradley

Bradley S19-200B Bedienungsanleitung

Bradley

Bradley Verge LVQ Series Bedienungsanleitung

Bradley

Bradley S19-230 Bedienungsanleitung

Bradley

Bradley Terreon Classic WF2500 Series Bedienungsanleitung

Bradley

Bradley Verge LVRD Series Bedienungsanleitung

Bradley

Bradley FREQUENCY FL-1H Bedienungsanleitung

Bradley

Bradley S19-230FW Bedienungsanleitung

Bradley

Bradley Express SS-2 Infrared-to-Touch Time Bedienungsanleitung

Bradley

Bradley Advocate AV Series Bedienungsanleitung

Bradley

Bradley S19-220SC Bedienungsanleitung

Bradley

Bradley WS-1X Bedienungsanleitung

Bradley

Bradley HN-400 Bedienungsanleitung

Bradley

Bradley EXPRESS MG-EXT Bedienungsanleitung

Bradley

Bradley E19-120A Bedienungsanleitung

Bradley

Bradley S96-085 Bedienungsanleitung

Bradley

Bradley S19-310DCBF Bedienungsanleitung

Bradley

Bradley Terrazzo WF2600 Series Bedienungsanleitung

Bradley

Bradley AERADA 1000 Series S53-326 AC Bedienungsanleitung

Bradley

Bradley Sentry SN2003/TT Bedienungsanleitung

Bradley

Bradley Express Crescent CRS-2/IR Bedienungsanleitung

Bradley

Bradley Verge LVGD1 Bedienungsanleitung

Bradley

Bradley Terreon MG Series Produktinformationsblatt

Bradley

Bradley S67-504 Bedienungsanleitung

Bradley

Bradley Express SS-2N/BIR3/STD Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Kohler

Kohler K-6228 Montageanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Kohler

Kohler K-12183 Montageanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Kohler

Kohler Centerset K-15240 Montageanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

Kohler

Kohler Mira Eco Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema