Clarke IMAGE 14 120V Bedienungsanleitung

Electronic Service

Manuals

This electronic document is provided as a service to our customers.

Wedonotcreatethecontentsoftheinformationcontainedinthisdocu-

ment. Shouldyouhavedetailedquestionspertainingtotheinformation

contained in this document, you may contact Michco, or the manufac-

turer which provided the original information in this electronic deliver-

able. Michco’sonlypartin this electronic deliverable was the electronic

assemblyprocess. Byprovidingthismanualonlinewearenotguaran-

teeing parts availability.

You may contact Michco through the following methods:

Phone (517) 484-9312 or (800) 331-3339

2011 N. High St. -- Lansing, Michigan -- 48906

Fax: (517) 484-9836

Email: [email protected]

Web site: www.Michco.Com

Parts Web site: www.FloorMachineParts.Com

Order Parts on Line at:

www.FloorMachineParts.Com

Directly to Parts & Service:

By Email: [email protected]

By Fax: (517) 702-2041

By Voice: Use numbers above.

Serving the Cleaning Industry Since 1922

Notice: All copyrighted material remains property of original owners, all trademarks are property of respective owners.

ManualsaresubjecttoManufacturer’sreproductionlimitations. Originalsorreproductionswereprovidedbymanufacturers

through a request. We make no warranty as to the correctness of information provided in this document and you assume

allrisk. By placing thesemanualsonlinewe are notdeclaringourcorporation to be anmanufacturerauthorizeddealer or

provider, please check ourwebsiteforauthorizedmanufacturerswerepresent.

Operator's

Manual

READ THIS BOOK

Thisbookhasimportantinformationfortheuseandsafeoperationofthismachine. Failuretoreadthis

book prior to operating or attempting any service or maintenance procedure to your Clarke machine

could result in injury to you or to other personnel; damage to the machine or to other property could

occur as well. You must have training in the operation of this machine before using it. If you or your

operator(s) cannot read English, have this manual explained fully before attempting to operate this

machine.

Si Ud.osusoperadoresnopuedenleerelInglés,sehaganexplicarestemanualcompletamenteantes

de tratar el manejo o servicio de esta máquina.

All directions given in this book are as seen from the operator’s position at the rear of the machine.

For new books write to: Clarke®, 2100 Highway 265, Springdale, Arkansas 72764.

Form No. 70088A 9/02 Clarke®Printed in the U.S.A.

IMAGE 14

120V

Division of

Page 2 Clarke®Operator's Manual - Image 14

TableofContents

OperatorSafety Instructions ............................................................................................................ 3

Introduction & Machine Specifications ............................................................................................. 5

Instructions - Power Supply 120Volt ................................................................................................ 6

MachineControls ............................................................................................................................. 7

HowToPreparethe Machine forOperation....................................................................................... 7

HowtoCleanCarpet ........................................................................................................................ 8

OPERATOR'SMAINTENANCE:

How to Empty the RecoveryTank .............................................................................................. 9

How to Empty the SolutionTank ................................................................................................ 9

How to Attach the Auxiliary FloorTool........................................................................................ 10

After Each Use of the Machine.................................................................................................. 10

Howto PreventDamagefromFreezingTemperatures ................................................................ 11

Spray Bar Nozzle ...................................................................................................................... 11

SECTION II Parts and Service Manual

AUTHORIZEDPERSONNELMAINTENANCE

To Access Pump/Brush Motor ................................................................................................... 14

BrushDrive Belt Replacement................................................................................................... 14

Maintenanceof theVacuum Motor............................................................................................. 14

Brushmaintenance.................................................................................................................... 14

Howto Correct Problemsinthe Machine ......................................................................................... 15

Final Assembly Drawing & Parts List Image 14................................................................................ 16

Handle Assembly Drawings & Parts List .......................................................................................... 17

RecoveryTank Assembly Drawing & Parts List................................................................................ 18

SolutionTank Assembly Drawing & Parts List .................................................................................. 19

Brush/Pump Assembly Drawing & Parts List ................................................................................... 20

Main Frame Assembly Drawing & Parts List ................................................................................... 21

Pump Drawing & Parts List .............................................................................................................. 22

ConnectionDiagram120Volts.......................................................................................................... 23

Electrical Schematic 120 Volts........................................................................................................ 24

AuthenticClarke Products ............................................................................................................... 25

Clarke®Operator's Manual - Image 14 Page 3

IMPORTANTSAFETYINSTRUCTIONS

WARNING AVERTISSEMENT ADVERTENCIA

DANGER: FailuretoreadandobserveallDANGERstatementscouldresultinsevere

bodilyinjuryordeath. ReadandobserveallDANGERstatementsfoundinyour

Owner'sManualandonyourmachine.

WARNING: FailuretoreadandobserveallWARNINGstatementscouldresultininjuryto

youortootherpersonnel;propertydamagecouldoccuraswell. Readand

observeallWARNINGstatementsfoundinyourOwner'sManualandonyour

machine.

CAUTION: FailuretoreadandobserveallCAUTIONstatementscouldresultindamageto

themachineortootherproperty. ReadandobserveallCAUTIONstatements

foundinyourOwner'sManualandonyourmachine.

WARNING: To reduce the risk of fire,electric shock,or injury:

1. Donotleaveapplianceunattendedwhenpluggedin. Unplugfromoutletwhennotin

useandbeforeservicing.

2. Toreducetheriskofelectricshockuseindoorsonly.

3. Donotallow to be used as a toy. Close attention is necessarywhen used by or near

children.

4. Useonlyasdescribedinthemanual. Useonlymanufacturer'srecommendedattach-

ments.

5. Donot use with damagedcord or plug. Ifappliance isnot workingas itshould, has

beendropped,damaged,leftoutdoors,ordroppedintowater,returnittoaservice

center.

6. Donotpullorcarrybycord,usecordasahandle,closeadooroncord,orpullcord

aroundsharpedgesorcorners. Donotrunapplianceovercord. Keepcordawayfrom

heatedsurfaces.

7. Do not unplug by pulling on cord. To unplug, grasp the plug, not the cord.

8. Donothandleplugorappliancewithwethands.

9. Do not put any objectinto openings. Donot usewith anyopening blocked;keep freeof

dust,lint,hairandanythingthatmayreduceairflow.

10. Keephair,looseclothing,fingers,andallpartsofbodyawayfromopeningsandmoving

parts.

11. Donotpickupanythingthatisburningorsmoking,suchascigarettes,matches,orhot

ashes.

12. Donot usewithout filtersinplace.

13. Turnoffallcontrolsbeforeunplugging.

14. Useextracarewhencleaningonstairs.

15. Donotusetopickupflammableorcombustibleliquidssuchasgasolineoruseinareas

wheretheymaybepresent.

16. Connecttoproperlygroundedoutlet. See"GroundingInstructions".

SAVETHESEINSTRUCTIONS

Page 4 Clarke®Operator's Manual - Image 14

IMPORTANTESMESURESDESECURITE

AVERTISSEMENT:Pourréduirelesrisquesd'incendie,dechocélectriqueou

de blessure:

1. Nepaslaisserl'appareilsanssurveillancelorsqu'ilestbranché. Débrancherlorsque

l'appareiln'estpasutiliséetavantl'entretien.

2. Pourréduirelesrisquesdechocélectrique,utiliseràl'intérieurseulement.

3. Nepaspermettreauxenfantsdejoueravecl'appareil. Uneattentionparticuliéreest

4. N'utiliserqueconformémentàcettenoticeaveclesaccessoiresrecommandésparle

fabricant.

5. Nepasutilisersilecordonoulaficheestendommagé. Retournerl'appareilàunatelier

deréparations'ilnefonctionnepasbien,s'ilesttombéous'ilaétéendommagé,oubliéà

l'extérieurouimmergé.

6. Nepastirersouleveroutraînerl'appareilparlecordon. Nepasutiliserlecordoncomme

unepoignée,lecoincerdansl'embrasured'uneporteoul'appuyercontredesarêtesvives

oudescoins. Nepasfaireroulerl'appareilsurlecordon. Garderlecordonàl'écartdes

surfaceschaudes.

7. Nepasdébrancherentirantsurlecordon. Tirerplutôtlafiche.

8. Nepastoucherlaficheoul'appareillorsquevosmainssonthumides.

9. N'inséreraucunobjetdanslesouvertures. Nepasutiliserl'appareillorsqu'uneouverture

estbloquée. S'assurerquedelapoussière,delapeluche,descheveuxoud'autres

matièresneréduisentpasledébitd'air.

10. Maintenirlescheveux,lesvêtementsamples,lesdoigtsettouteslespartiesducorpsà

l'écartdesouverturesetdespiècesmobiles.

11. Nepasaspirerdematièresencombustionouquidégagentdelafumée,commedes

cigarettes,desallumettesoudescendreschaudes.

12. Nepas utiliserl'appareilsi lesacà poussièreoule filtren'estpas enplace.

13. MettretouteslescommandesàlapositionARRETavantdedébrancherl'appareil.

14. Userdeprudencelorsdunettoyagedesescaliers.

15. Nepasaspirerdesliquidesinflammablesoucombustibles,commedel'essence,etne

pasfairefonctionnerdansdesendroitsoùpeuventsetrouverdetelsliquides.

16. "Nebrancherqu'àuneprisedecourantavecmiseàlaterre. Voirlesinstructionsvisant

lamiseàlaterre."

CONSERVERCESINSTRUCTIONS

Clarke®Operator's Manual - Image 14 Page 5

DANGER: Machinescancause anexplosionwhenoperatednear flammablematerialsandvapors. Do

not use this machine with or near fuels, grain dust, solvents, thinners, or other flammable

materials.

WARNING: You must have training in the operation of this machine before using it. READ THE

INSTRUCTIONBOOKFIRST.

WARNING: Anyalterationsormodificationsofthismachinecouldresultindamagetothemachineorinjury

to the operator or other bystanders. Alterations or modifications not authorized by the

manufacturervoids any andallwarranties and liabilities.

WARNING: Do not use this machine as a step or furniture. Injury could occur to the operator.

WARNING: To avoid serious injury, use proper lifting procedures when lifting the machine.

WARNING: Makesurethatallthelabels,decals,warnings,cautionsandinstructionsarereadable. Replace

them when necessary by ordering them from Clarke.

WARNING: Do not use water that is hotter than 140°F.

WARNING: Improperdischargeofwastewatermaydamage the environment and beillegal. TheUnited

States Environmental Protection Agency has established certain regulations regarding

discharge of waste water. Also, city and state regulation regarding this discharge may be in

effect in your area. Understand and follow the regulations in your area. Be aware of the

environmental hazards of chemicals that you dispose.

Introduction and Machine Specifications

TheImage14isan extractorforcleaningcarpet. The machineapplies cleaning solution tothe carpet andremoves

dirty solution and soilfromthecarpet. The Image 14 isequipped withapowerbrush. The extractorhascontrolsto

start the solution pump,and vacuummotor. This machine is intended forcommercial use.

Specifications: Image 14

120V

Model 04120A

Electrical 120 V. 50/60 Hz

Solution Pump 45 PSI Bypass

Power Cable 35' 14/3-wire

Spray Jets 1 Quarter Turn Q.C.

Solution Tank Capacit 4 Gallon

Recovery Tank 4 Gallon

Waterlift/CFM 82"/97

Vacuum Tangential discharge,

1.25 HP, 2 stage

Brush Size 3½" x 11"

Brush Motor Size 1/8 HP

Dimensions 31½" x 37" x 14"

Weight 55 lbs.

ShippingWeight 65 lbs.

Control Switch

Recovery Tank

Recovery Tank Handle

Vacuum Hose

SolutionTank

Recovery Tool

Self Adjusting Brush

Locking

Handle

AuxiliaryConnection

Page 6 Clarke®Operator's Manual - Image 14

120 VOLT, 50/60 CYCLE MACHINES

GROUNDING INSTRUCTIONS

This product must be grounded. If it should malfunction or

breakdown, grounding provides a path of least resistance

for electric current to reduce the risk of electric shock. This

product is equipped with a cord having an equipment-

grounding conductor and grounding plug. The plug must be

inserted into an appropriate outlet that is properly installed

and grounded in accordance with all local codes and

ordinances.

WARNING: Improper connection of the

equipment-grounding conductor can result in a risk of elec-

tric shock. Check with a qualified electrician or service

person if you are in doubt as to whether the outlet is prop-

erly grounded. Do not modify the plug provided with the

product - if it will not fit the outlet, have a proper outlet in-

stalled by a qualified electrician.

This product is for use on a nominal 120 volt circuit and has

a grounding attachment plug that looks like the plug

illustrated in Fig. 1. Make sure that the product is connected

to an outlet having the same configuration as the plug. No

adaptor should be used with this product.

For maximum protection against electric shock, use a circuit

that is protected by a ground fault circuit interrupter. The

green (or green and yellow) conductor in the cord is the

ground wire. Never connect this wire to any terminal other

than the ground terminal.

WARNING: To prevent possible electric shock,pro-

tect the machine from rain. Keep the

machine in a dry building.

WARNING: To prevent possible electric shock, al-

waysuse a3-wire electricalsystem con-

nected to the electrical ground. For

maximum protection against electrical

shock, use a circuit that is protected by

a ground fault circuit interrupter. Con-

sult your electrical contractor.

WARNING: Do not cut, remove or break the ground

pin. If the outlet does not fit the plug,

consult your electrical contractor.

WARNING: Have worn, cut, or damaged cords and

plugs replaced by an authorized service

person.

EXTENSION CORDS

Use only an approved extension cord with three conductors, a

plug with three terminals, and a connector body with three

holes. The machine has a power cord with wire size 14 AWG

(AWG means American Wire Gauge).

WARNING: If you use an extension cord, use an

extension cord with minimum wire

size 14 AWG. Do not use an exten-

sion cord longer than 50 feet. Do

not join two extension cords.

Figure 1

Grounded

Outlet

Grounded

OutletBox

Grounding

Clarke®Operator's Manual - Image 14 Page 7

HOW TO PREPARE THE MACHINE FOR OPERATION

THECONTROLS

The Vacuum/Accessory/Pump Switch

This switch is located on the handle. To turn the

vacuum motor on, place the switch in the middle

position. To turn pump, brush, and vacuum motor on,

place the switch in bottom position. (Figure 2, #1)

The Vacuum Hose Connector

The vacuum hose connector is on the right hand rear

of the machine. (Figure 2, #2)

The Solution Hose Connector

The solution hose connector is located on the bottom

center of the machine. This connection is used to

hook up optional auxiliary floor tools. (Figure 2, #3)

Recovery Tank Drain

Remove hose from rear of machine. Using the handle

lift the recovery tank free and and pour water into

drain.

Solution Tank Drain

Remove the hose from the rear of the machine. Place

over drain.

WARNING: This machine has moving parts.

To reduce the risk of injury,unplug

before servicing.

WARNING: To reduce the risk of fire, use only

commercially available floor clean-

ersandwaxesintended for machine

application.

WARNING: Do not use water that is hotter than

140°F.

WARNING: Operatingamachine thatisnot com-

pletely or fully assembled could re-

sult in injury or property damage.

Do not operate this machine unless

it is completely assembled. Inspect

themachinecarefullybefore operat-

ing.

This machine is intended for commercial use.

To preparethemachine foroperation,followthis

procedure:

1. Before moving the extractor onto the carpet, put

clean hot water into the solution tank. The solution

tank capacity is approximately four gallons.

2. Add two to ten ounces of "Clarkare®Extractor

concentrate"perevery one gallon ofwater,depend-

ingon carpet condition.

3. If the extractor removes an excess amount of foam

from the carpet, add a defoamer such as Clarkare®

Defoamer Concentrate to the recovery tank. The

amountneededwill change accordingto the

amountof detergent alreadyinthecarpet.

CAUTION: Do not leave the extractor or

other cleaning machines or

tools on the carpet when not in

use. Cleaning solution in the

machines and tools can leak

onto the carpet and cause light

spots or stains.

NOTE: To order Clarkare®ExtractorConcentrate,

OrderPartNo.398421. ToorderClarkare®

Defoamer,orderPartNo.398420.Forinstructions

forpreparation and operation ofyour floortool,

readtheoperator'smanual

supplied with your floor tool.

Figure 2

Page 8 Clarke®Operator's Manual - Image 14

CAUTION: The recovery tank is equipped

with a mechanical shut-off float

switch. When the recovery tank

becomes full the machine will

no longer recover water. Turn

the vacuum/accessory and

spray/brush/switch to the "O"

positionbeforeemptyingthere-

coverytank.

NOTE:When using the extractor to clean carpets,

followthisprocedure:

1. Do not walk on freshly cleaned carpets for at

least four hours or until the carpet is dry to

touch.

2. If aluminum or plastic pieces have been placed

under the legs of furniture, do not

remove them until the carpet is dry.

3. Do not allow children or pets to crawl or walk

aroundonthe damp carpet.

4. Vacuum right after the carpet is dry and then

vacuum the carpet once a week, or as often as

needed.

To clean an area of carpet,follow this procedure:

(SeeFigure3)

1. DryVacuum area of carpet to be cleaned.

2. Turn the Vacuum switch to the "ON" position.

3. Brush will self adjust.

NOTE: Incorrect brush height may cause

circuit breaker to trip. Check for obstructions in

brushhousing , clear andproceed.

4. With the pump switch activated, slowly and

steadily pull the machine backwards.

5. Switch to Pump "OFF" and vacuum an addi-

tional 6 inches.

6. To clean a small area of carpet, clean the carpet

in sections three feet square. As you make

additional passes, overlap one inch of the area

alreadycleaned.

7. Cleaning speed is determined by how dirty the

carpet is. If the carpet is very dirty, move the

machineslower.

8. As the machine is used, dirty solution will begin

to fill the recovery tank. When the solution tank

is empty, the recovery tank must be emptied.

HOWTO CLEAN AN AREA OF CARPET

Figure 3

Clarke®Operator's Manual - Image 14 Page 9

OPERATOR'SMAINTENANCE

How to Empty the RecoveryTank

To empty the recovery tank, follow this procedure:

1. Turn the switches on the machine to the "O" posi-

tion.

2. Remove the hose on the rear of the recovery tank.

Lift recovery tank by handle and carry to drain.

3. Usingdrainspout, pour intodrain.

How to Empty the SolutionTank

1. Turn switches to the "O" position.

2. Positionthemachinenearadrain. Removethehose

from the rear of the machine and place hose into

drain.

To clean a larger area of carpet, follow this procedure:

(SeeFigure4)

1. Begin at the right-hand corner of the carpet.

2. Make a pass halfway along the edge of the carpet.

Pull the machine backward at a steady speed.

3. Move to the edge of the carpet. Make another pass

next to your first pass.

4. As you make more passes, overlap one inch of the

area already cleaned. Make each pass four inches

different in length to prevent making a line in the

center of the carpet.

5. Make more passes until half of the carpet is

cleaned.

6. Move to the right hand corner of the carpet not yet

cleaned.

7. Make a pass halfway along the edge of the carpet.

8. As you make passes, overlap one inch of the area

alreadycleaned.

9. Make more passes until all of the room is cleaned.

CAUTION: Clarke will not be held liable for dam-

age to the carpet, or poor results be-

cause of the operator's lack of ability.

Figure 4

Inhaltsverzeichnis

Andere Clarke Staubsauger Handbücher

Clarke

Clarke D14 Bedienungsanleitung

Clarke

Clarke S12 Gebrauchs- und Pflegehandbuch

Clarke

Clarke Filtra-Pac 02150A Bedienungsanleitung

Clarke

Clarke CombiVac 12 Bedienungsanleitung

Clarke

Clarke Summit Pumper Bedienungsanleitung

Clarke

Clarke DTV-7 Bedienungsanleitung

Clarke

Clarke CTV 20 Bedienungsanleitung

Clarke

Clarke Woodworker CDE1000 Installations- und Betriebshandbuch

Clarke

Clarke Summit Wet/Dry Vacuum Bedienungsanleitung

Clarke

Clarke CVACASH500 Installations- und Betriebshandbuch

Clarke

Clarke CTV 02175A Bedienungsanleitung

Clarke

Clarke BextSpot Pro Bedienungsanleitung

Clarke

Clarke VAC KING 6471100 Installations- und Betriebshandbuch

Clarke

Clarke CCVAC20P Installations- und Betriebshandbuch

Clarke

Clarke FiltraVac 14 Bedienungsanleitung

Clarke

Clarke CWVE2 Installations- und Betriebshandbuch

Clarke

Clarke CDE85 Installations- und Betriebshandbuch

Clarke

Clarke 560 B Bedienungsanleitung

Clarke

Clarke Comfort Pak 6 Bedienungsanleitung

Clarke

Clarke Woodworker CDE7B Installations- und Betriebshandbuch

Clarke

Clarke 590 Bedienungsanleitung

Clarke

Clarke BEXTSPOT 04153A Bedienungsanleitung

Clarke

Clarke FiltraPac Bedienungsanleitung

Clarke

Clarke SUMMIT SUMMIT Wet/Dry Vacuum Bedienungsanleitung

Beliebte Staubsauger Handbücher anderer Marken

Bissell

Bissell LittleGreen Proheat 1425 Series Bedienungsanleitung

Panasonic

Panasonic MC-YL637S147-AE Bedienungsanleitung

NEFF

NEFF N17XH10 0 Series Bedienungsanleitung

LG A9 Series Bedienungsanleitung

Oreck

Oreck Cordless Captura BK51700 Series Bedienungsanleitung

Kogan

Kogan KAVACROBVWA Bedienungsanleitung

Kränzle

Kränzle VENTOS 50 ID Benutzerhandbuch

EVVO

EVVO Ai35 Bedienungsanleitung

DeWalt

DeWalt DWH200D Bedienungsanleitung

Pontec

Pontec Pondomatic Vacuum Cleaner Bedienungsanleitung

Cleanmaxx

Cleanmaxx PC-P007E Bedienungsanleitung

Exido

Exido 240-114 Bedienungsanleitung

RIDGID

RIDGID WD1685AU0 Bedienungsanleitung

Ezviz

Ezviz RE4P Bedienungsanleitung

STG global

STG global TANVAC HDV3000 Bedienungsanleitung

Shark

Shark ROTATOR PRO COMPLETE NV550 Series Bedienungsanleitung

Factory

Factory M3340 Bedienungsanleitung

Shop-Vac

Shop-Vac VN92 SERIES Bedienungsanleitung