Drive VacuMax 18610 Handbuch

VacuMaxTM Suction Unit

Instruction Guide

Medical Suction Device

Models No. :

18610 VacuMaxTM Plus Suction Machine

18615 VacuMaxTM Go Portable Suction Machine

This unit complies with EU EMC standard EN60601-1-2

Caution: Use this Aspirator Only for its intended use as described in this

manual. Improper use or failure to do so could result in personal injury or

property damage. This device is to only be used by or on the prescription

of a physician.

REV4.04.29.15

VacuMaxTM Suction Machine

Models No.: 18610 & 18615

Table of Contents

1. Introduction -----------------------------------------------------------------------------Page 2

2. Product Structure ---------------------------------------------------------------------Page 3

3. Important Safeguards ---------------------------------------------------------------Page 4

4. Device Speciﬁcations ---------------------------------------------------------------Page 5

5. Operation Instruction ---------------------------------------------------------------Page 6

6. Cleaning and Sterilization ---------------------------------------------------------Page 7

7. Replaceable Parts and Accessories -------------------------------------------Page 8

8. Warranty ---------------------------------------------------------------------------------Page 9

1) Introduction of Intended Use

A. This Medical Suction Device is intended for removal of ﬂuids from the

airway or respiratory system. This appliance may also be employed in the

removal of infections materials from patient wounds.

B. Utilizing a motor to drive an air pump to generate negative pressure

(vacuum), this device will aspirate mucous secretions from the patient’s

body, in the management and treatment of respiratory disease. Aspirated

secretions are collected in a suction canister for proper disposal.

Product Structure

A. Visual appearance

18610/18615

B. Assembly

18610 18615

AC Power Connection AC Power connection with

Rechargeable Battery

VacuMaxTM Suction Machine

2) Included Accessories

1. 800cc Suction Canister

2. 6’ Suction Tubing

3. 10” Suction Tubing

4. Hydrophobic Filter

5. Elbow Connector

3) Important Safeguards

Note: Read all instructions carefully before use.

The following basic precautions are needed when using the product.

Caution: Failure to read and observe all precautions could result in personal

injury or equipment damage.

Warning: Modiﬁcation of this equipment voids the warranty.

Product Cautions:

1. To avoid electrical shock, keep the unit away from water; do not immerse the

power cord or the unit in any liquid. Do not use while bathing. Do not reach

for a unit that has fallen into water – immediately unplug the unit.

2. Never operate the unit if it has any damaged parts (including power cord),

and/or if it has been dropped or submersed in water.

3. The unit should not be used where ﬂammable gas, oxygen or aerosol spray

products are being used.

4. Disconnect the unit from the electrical outlet before cleaning, ﬁlling and after

each use.

Operating Cautions:

1. Connect this product to an appropriate voltage outlet for your model.

2. Do not run this product unattended.

3. If any abnormality occurs, discontinue use immediately until the unit has

been examined and repaired.

4. Always unplug the product immediately after use.

Storage Cautions:

1. Do not store the unit under direct sunlight, extreme temperature or humidity.

2. Keep the unit out of reach of children.

3. Always keep the unit unplugged while not in use.

6. Product Manual

7. AC Power Cord (18610 and 18615)

8. DC Power Cord (18615 Only)

9. Carry Bag (18615 Only)

4) Device Speciﬁcations:

No. Item 18610 18615

1 Rated Power input DC 12V DC 12V

2 Power 48VA Max 48VA Max

3 Max Negative Pressure 10PSI (530mmHg) 10PSI (530mmHg)

4 Negative Pressure

Adjust Range

2.9 – 10PSI

(150-530mmHg)

2.9 – 10PSI

(150-530mmHg)

5 Max Suction Speed 25 LPM 25 LPM

6 Collection bottle

Capacity 800cc

7 Dimensions 12.4in x 9.8in x 8.1in

(315mm x 248mm x 207mm)

8 Weight 4.4lbs (2.0 kgs) 5.0lbs (2.3kgs)

9 Life of Use 2 years

10 Operating Environment 50oF to 104oF (10oC to 40oC), 30% to 75% RH

11 Storage Environment -4oF to 140oF (-20oC to 60oC), 10% to 95% RH

12 Noise 60dBA at 1 meter

Cleaning Cautions:

1. Clean after each use as instructed in this guidebook.

2. Do not immerse the unit in water. It may damage the unit.

3. Disconnect the unit from the electrical outlet before cleaning

VacuMaxTM Suction Machine

5) Operation Instruction

A. Canister, Tubing and Filter Assembly:

1. Open the accessories case and take out the silicone tube, the elbow and the

ﬁlter cover. Connect one end of the silicone tube to the front air input port

and the other end to the ﬁlter cover.

2. Connect the ﬁlter cover to the collection bottle with the elbow.

3. Inspect suction tubing and collection bottle for leaks, cracks, etc. before

each use.

B. Turn on the device:

1. Plug in the power cord.

2. Turn on the power switch.

3. Connect the suction tube to the device, open the suction valve, make sure the

suction air way is unobstructed.

4. Adjust the negative pressure through the adjusting knob; choose the

appropriate negative pressure for the recommended treatment (please refer to

your physician) for the patient.

Note: For DC Model 18615, if the device is connected with the adaptor, the

device will not use the energy in the battery set.

18610 Operating Lights

• The Low Battery and Charging lights have been deactivated and will not illuminate

during operation

Note: The 18610 and 18615 has been built with the same housing in order to facilitate

simple battery installation during conversion from the 18610 to the 18615 model.

18615 Operating Lights

• Low Battery Light

• OFF while charging

• RED when operating on DC power and battery is not fully charged

• Will turn o when the unit is plugged in

• GREEN when fully charged

• Charging Light

• OFF when in use and operating on AC power

• RED while charging

• GREEN when fully charged and plugged in

• Will turn o when the unit is unplugged

C. Turn o the device:

1. After the treatment is over, turn o the power switch, the device will stop

working.

For DC Model 18615, when the Power Switch is turned o and the device is

plugged in, the device starts battery charging. The time of the battery charge

is less than eight hours.

2. The working cycle of the device is 30 minutes on & 30 minutes o.

VacuMaxTM Suction Machine

6) Cleaning and Sterilization

Disconnect from the power source prior to cleaning.

1. It is recommended that the tubes and collection bottle be thoroughly cleaned

with hot water after each use and be cleaned with a mild detergent after the

last treatment of the day. If your physician or respiratory therapist speciﬁes a

dierent cleaning procedure, follow their instructions.

2. The ﬁlter can’t be cleaned.

3. If the ﬁlter gets wet, or becomes contaminated or clogged, it must be

replaced.

Rinsing and Disinfection

Please follow the following steps to disinfect your Suction Device unless other-

wise speciﬁed by your physician. It is suggested that the unit is disinfected after

each treatment.

Rinsing:

(Recommended after each treatment)

1. Disconnect the tubes, collection bottle, the ﬁlter cover and the elbow. Rinse

the tubes, collection bottle with water.

2. Dry them with clean soft towel or let it air dry.

3. Reassemble the product when completely dry and put these parts in a dry

sealed container.

Disinfection:

(Recommended after each treatment)

1. Use one part white vinegar with three parts distilled water. Make sure mixed

solution is enough to submerge the tubes and collection bottle.

2. Complete Rinsing Steps 1-3.

3. Wash the tubes and collection bottle in warm water and a mild detergent.

Then wash them in a hot tap water.

4. Submerge these parts in the vinegar and water solution for thirty minutes.

5. Complete Rinsing Steps 2-3.

Commercial Bacterial Germicides specially intended for cleaning medical

devices within the institutional environment may be used in compliance to the

manufacturer’s instructions in cleaning this equipment.

7) Replaceable Parts and Accessories

Always use OEM parts

Never use any AC-DC Adaptor other than approved Drive Medical adaptors.

Use compliant FDA or CE approved suction tubing with the diameter of 6.0mm x

9.0mm with the Drive Medical VacuMaxTM 18610/18615 suction machine.

Accessories

Part Number Description UOM

18615-ACORD AC Power Cord for the 18610 and 18615 1/ea

18615-DCORD DC Power Cord for the 18615 1/ea

18615-BATTERY Replacement Rechargeable Battery for

the VacuMax™ Go 18615

1/ea

18615-BAG Carry Bag for VacuMax™ 1/ea

18600-FILTER Hydrophobic Filter 3/bx

22330 800cc Disposable Suction Canister Kit 1/ea

22330-12 800cc Disposable Suction Canister Kit 12/cs

18600-KITN Universal Suction Tubing and Filter Kit 1/bx

610-12B 800cc Disposable Suction Canister 12/cs

610-48BP 800cc Disposable Suction Canister 48/cs

Consult accompanying documents

Type BF equipment

Disposal for Separate Collection

Device in protection class 2

Prescription Only

VacuMaxTM Suction Machine

8) LIMITED WARRANTY

The VacuMaxTM Suction Machine has been carefully manufactured and

inspected and is warranted to be free from defectives in workmanship and

materials. Under this warranty, Drive Medical’s obligation shall be limited to

the replacement or repair of any such units which prove, by Drive Medical’s

inspection, to be defective within two years from the original purchase date.

Rechargeable batteries are warranted for 6 months from the original purchase

date. This warranty is not transferrable or assignable to any subsequent

purchaser or owner. Any abuse, operation other than the intended use of this

product as outlined in the manual, negligence, accident, or repairs by someone

other than a Drive Medical Authorized Service Professional, shall immediately

void this warranty.

Drive Medical will not accept damages or charges for labor, parts, or expenses

incurred in making ﬁeld repairs.

The foregoing warranty is exclusive and in lieu of all other expressed warranties.

Implied warranties, if any, including but not limited to the implied warranties of

merchantability and ﬁtness for a particular purpose, shall not extend beyond the

duration of the express warranty provided herein. In no event shall Drive Medical

or its subsidiaries by liable for loss of use or proﬁt or other collateral, special or

consequential damages.

Drive Medical

99 Seaview Blvd

Port Washington, NY 11050

Toll-Free 877-224-0946

www.drivemedical.com

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Drive Medizinische Geräte Handbücher

Drive

Drive DeVilbiss Healthcare Vacu-Aide 7325 Series Handbuch

Drive

Drive RTLAGF-900 Bedienungsanleitung

Drive

Drive Evolution OM-900 Bedienungsanleitung

Drive

Drive 15003 Bedienungsanleitung

Drive

Drive inspired BCWL-7210S Bedienungsanleitung

Drive

Drive WA008 Bedienungsanleitung

Drive

Drive 13063 Bedienungsanleitung

Drive

Drive 13029 Bedienungsanleitung

Drive

Drive DeVilbiss Eclipse II with Dial Pump Bedienungsanleitung

Drive

Drive Winnie wagon Bedienungsanleitung

Drive

Drive 13085RN Bedienungsanleitung

Drive

Drive 15005LP Bedienungsanleitung

Drive

Drive FC 8050 Bedienungsanleitung

Drive

Drive DSF 130 Bedienungsanleitung

Drive

Drive 14508 Bedienungsanleitung

Drive

Drive PreserveTech LS9500N Bedienungsanleitung

Drive

Drive OXYMIZER Pendant P-224 Bedienungsanleitung

Drive

Drive RTL10433 Bedienungsanleitung

Drive

Drive AGF-5X Bedienungsanleitung

Drive

Drive 14026 Bedienungsanleitung

Drive

Drive DeVilbiss Healthcare Hybrid-Power Bedienungsanleitung

Drive

Drive 13049SV Bedienungsanleitung

Drive

Drive 12025KD-1 Bedienungsanleitung

Drive

Drive Ultra Light Plus Bedienungsanleitung

Beliebte Medizinische Geräte Handbücher anderer Marken

TekTone

TekTone Tek-CARE160 Bedienungsanleitung

NeuroMetrix

NeuroMetrix Quell 2.0 Bedienungsanleitung

AMT

AMT XLR8 Bedienungsanleitung

EDAN

EDAN SONOTRAX Pro Bedienungsanleitung

Restorative Therapies

Restorative Therapies RT300 Bedienungsanleitung

Gendex

Gendex Expert DC Bedienungsanleitung

Dexcowin

Dexcowin ADX4000W Bedienungsanleitung

Libelium

Libelium MySignals Bedienungsanleitung

Acelity

Acelity V.A.C.ULTA 4 Bedienungsanleitung

Caputron

Caputron ActivaDose II tDCS Bedienungsanleitung

Plinth 2000

Plinth 2000 93CDT Bedienungsanleitung

GE SENOGRAPHE 800T Bedienungsanleitung

GE Definium 5000 Bedienungsanleitung

Kanmed

Kanmed GE-1380 Bedienungsanleitung

Huntleigh

Huntleigh FD1 Bedienungsanleitung

Stryker

Stryker SPR Plus Bedienungsanleitung

Tobii Dynavox

Tobii Dynavox I-Series Bedienungsanleitung

S-Capepod

S-Capepod Evac Cocoon Bedienungsanleitung