Extech Instruments RPM40 Bedienungsanleitung

USERGUIDE



COMBINATIONPHOTO/CONTACTTACHOMETER



ModelRPM40



www.GlobalTestSupply.com

Find Quality Products Online at: sales@GlobalTestSupply.com

RPM40-en-GB_V1.2 10/14

Introduction

ThankyouforselectingtheExtechCombinationPhoto/ContactTachometer,ModelRPM40.This

combinationtachometerisapatenteddesignprovidingcontactandnon‐contactRPM

measurements.Inaddition,linearsurfacespeedscanbemeasuredinft/minorm/min.This

deviceisshippedfullytestedandcalibratedand,withproperuse,willprovideyearsofreliable

service.Pleasevisitourwebsite(www.extech.com)tocheckforthelatestversionofthisUser

Guide,ProductUpdates,andCustomerSupport.

Features

Compactpockettachometer

Combinationphotoandcontacttachometer

LaserpointerforPhotoTachometertargeting

Non‐contactPhotoTachometerdetectstargettoadistanceof1.5m(4.9ft.)

Widemeasuringrange0.5to19,999RPM(Contact)and99,999RPM(Photo)

0.1%basicaccuracy

Memory/Recallofhighest,lowest,andlastreadings

Durable,light‐weightABSplastichousing

Safety

1. Useextremecautionwhenthelaserbeamison

2. Donotpointthebeamtowardanyone'seye

3. Becarefulnottoletthebeamstriketheeyefromareflectivesurface

4. Donotusethelasernearexplosivegasesorinotherpotentiallyexplosiveareas



www.GlobalTestSupply.com

Find Quality Products Online at: sales@GlobalTestSupply.com

RPM40-en-GB_V1.2 10/14

MeterDescription

1. RPMAdapter(Contact)

2. SurfaceSpeedWheel

3. LCDDisplay

4. PhotoDetectSensor

5. Laserpointer(red)

6. MonitorIndicator

7. MeasureButton

8. FunctionButton

9. MemoryButton



Thebatterycompartmentislocatedonbackofmeter.



BatteryReplacement

Thelowbatteryindicatorappearswhenthebatteriesneedtobereplaced.Toreplacethe

batteries:

1. OpentherearbatterycompartmentbyremovingthetwoPhillipsheadscrewsthatsecureit

2. Replacethefour1.5VAAbatteriesobservingcorrectpolarity

3. Replacethebatterycoverbeforeattemptingtousethemeter



Neverdisposeofusedbatteriesorrechargeablebatteriesinhouseholdwaste.

Asconsumers,usersarelegallyrequiredtotakeusedbatteriestoappropriate

collectionsites,theretailstorewherethebatterieswerepurchased,orwherever

batteriesaresold.

Disposal:Donotdisposeofthisinstrumentinhouseholdwaste.Theuserisobligatedtotake

end‐of‐lifedevicestoadesignatedcollectionpointforthedisposalofelectricalandelectronic

equipment.



www.GlobalTestSupply.com

Find Quality Products Online at: sales@GlobalTestSupply.com

RPM40-en-GB_V1.2 10/14

Operation

Selectingafunction

PressandholdtheMEASUREbutton(7)and,whileholdingMEASURE,useshortpressesofthe

FUNCTIONbutton(8)tostepthroughthemodes.Theavailablemodesare:ContactRPM

measurement,Surfacespeed(m/min),Surfacespeed(ft/min),Surfacespeed(in/min),and

PhotoRPMmeasurement(laserpointerwillswitchONinthismode).



Note:Whenafunctionisselecteditbecomesthedefaultmodeofoperation(evenaftertheunit

ispoweredoff)untilanotherfunctionisselected.

PhotoRPMMeasurement

1. SelectPhotoRPMmeasurementmodeasinstructedintheprevioussection.

2. Applyanappropriatelysizedsquarepieceofreflectivetapetothesurfaceoftheobject

undertest.

3. PressandholdtheMEASUREbuttonandalignthelaserpointerwiththereflectivetape.

Measurementdistanceshouldbelimitedtoadistancerangeof2to60”(5to150cm).

4. VerifythattheMonitorIndicator(6)appearsontheLCDwhenthereflectivetapepasses

throughthebeam.

5. ReleasetheMeasurebuttonwhentheRPMreadingstabilizesontheLCD.

6. Iftherpmisunder50,applyadditionalsquaresofreflectivetape.Dividethereadingshown

onthedisplaybythenumberofpiecesofreflectivetapesquarestocalculatetheactualrpm.



NOTE:Brightambientlightmayinterferewiththereflectedlight.Shadingthetargetarea

maybenecessaryinsomecases.



CAUTION:Rotatingobjectscanbedangerous.Useextremecare.

Photo Tachometer

Rotating object

Reflective tape

Light source

and reflection

www.GlobalTestSupply.com

Find Quality Products Online at: sales@GlobalTestSupply.com

RPM40-en-GB_V1.2 10/14

ContactRPMMeasurement

1. Installarotatingattachment(coneorfunnel)tothemeter

2. SelectContactRPMmeasurementmodeasdescribedinthe‘Selectingafunction’section.

3. PressandholdtheMEASUREbuttonwhilesimultaneouslyplacingtheRPMadapter(1)

againstthecenteroftherotatingaxistobemeasured.

4. ReleasetheMEASUREbuttonwhenthereadingstabilizes(approximately2seconds).

ReversibleLCDDisplay

TheLCDdisplayindicatesPhotoTachometermeasurementsinonedirectionandContact

measurementsintheoppositedirection.Thispermitstheusertoeasilyreadthemeasurement

digitsinbothmeasurementmodes.

SurfaceSpeedMeasurement

1. SelecttheSurfaceSpeed(m/min,ft/min,orin/min)modeasdescribedaboveinthe

‘Selectingafunction’section.

2. AttachtheSurfaceSpeedwheel(2)tothemeter.

3. PresstheMEASUREbuttonandplacethesurfacespeedwheelagainsttheobjectundertest.

4. ReleasetheMEASUREbuttonwhenthereadingstabilizes(approximately2seconds).

MemoryRecall

Theminimum(dn),maximum(UP),andlast(LA)readingvaluesarestoredinmemoryaftereach

measurement(aftertheMEASUREbuttonisreleased).Toviewthesevalues:

1. PressandholdtheMEMORYbutton(9),thedisplaywilltogglebetweenthestoredreading

anditsidentificationlabel(dnforlowestreading),UPforhighestreading,orLAforlast

reading).

2. ReleasetheMEMORYbuttonandthenpressandholditagaintoviewthenextstored

reading.

3. ReleasetheMEMORYbuttonandthenpressandholditagaintoviewthenextstored

reading.

4. Repeatthesestepsasdesired.



www.GlobalTestSupply.com

Find Quality Products Online at: sales@GlobalTestSupply.com

RPM40-en-GB_V1.2 10/14

Specifications

Measurement&RangePhotoTachometer:5to99,999RPM

ContactTachometer:0.5to19,999RPM

SurfaceSpeed:

m/min.–0.05to1,999.9m/min.

ft/min.–0.2to6,560ft/min.

in/min.–2.0to78,740in/min.

ResolutionRPM 0.1RPM(<1000RPM)

1RPM(≥1000RPM)

m/min 0.01m/min(<100m/min)

0.1m/min(≥100m/min.)

ft/min.0.1ft/min.(<1000ft/min.)

1ft/min(≥1000ft/min.).

in/min.0.1in/min.(<1000in/min.).

1in/min.(≥1000in/min.).

DisplayLCD,size:32mmx28mm(1.26x1.10”)

Large5digitreversibledisplaywithunitofmeasureand

alertindicators

Accuracy±(0.1%ofreading+1digit)

SamplingratePhotomode:1second(>60RPM)

Contactmode:1second(>6RPM)

PhotoTachometerdetectingdistanceTypically50to150cm(2to60”)

TimebasecircuitQuartzcrystal

LaserlightsourceLessthan1mW;Class2laserdiode;645nm

OperatingTemperature0to50°C(32to122°F)

OperatingHumidityLessthan80%R.H.

MemoryStores/Recallshighest,lowest,andlastvalues

Battery4x1.5VAAAbatteries

PowerConsumptionPhototachometer:Approximately20mADC

Contacttachometer:Approximately9.5mADC

Dimensions165x50x33mm(6.5x2.0x1.3”)

Weight182g(0.4lbs.)Batteryweightincluded

AccessoriesincludedBatteries,Reflectivetape60cm(24”),Surfacespeed/rpm

rotatingattachments(cone&funnel)



Allrightsreservedincludingtherightofreproductioninwholeorinpartinanyform

www.extech.com

www.GlobalTestSupply.com

Find Quality Products Online at: sales@GlobalTestSupply.com

Inhaltsverzeichnis

Andere Extech Instruments Messgerät Handbücher

Extech Instruments

Extech Instruments UV510 Bedienungsanleitung

Extech Instruments

Extech Instruments SDL350-NIST Bedienungsanleitung

Extech Instruments

Extech Instruments SDL300-NIST Bedienungsanleitung

Extech Instruments

Extech Instruments MA1500 Bedienungsanleitung

Extech Instruments

Extech Instruments 461920 Bedienungsanleitung

Extech Instruments

Extech Instruments EX810 Bedienungsanleitung

Extech Instruments

Extech Instruments VB500 Bedienungsanleitung

Extech Instruments

Extech Instruments 461920 Bedienungsanleitung

Extech Instruments

Extech Instruments CO200 Bedienungsanleitung

Extech Instruments

Extech Instruments AN10 Bedienungsanleitung

Extech Instruments

Extech Instruments CO260 Bedienungsanleitung

Extech Instruments

Extech Instruments CO52 Bedienungsanleitung

Extech Instruments

Extech Instruments RH520B Bedienungsanleitung

Extech Instruments

Extech Instruments 451112 Bedienungsanleitung

Extech Instruments

Extech Instruments 381235 Bedienungsanleitung

Extech Instruments

Extech Instruments ExStik RE300 Bedienungsanleitung

Extech Instruments

Extech Instruments TKG100 Bedienungsanleitung

Extech Instruments

Extech Instruments 461995 Bedienungsanleitung

Extech Instruments

Extech Instruments AN310-NIST Bedienungsanleitung

Extech Instruments

Extech Instruments UV505 Bedienungsanleitung

Extech Instruments

Extech Instruments TKG250 Bedienungsanleitung

Extech Instruments

Extech Instruments MO750 Bedienungsanleitung

Extech Instruments

Extech Instruments 382095 Bedienungsanleitung

Extech Instruments

Extech Instruments HD755-NIST Bedienungsanleitung

Beliebte Messgerät Handbücher anderer Marken

Suaoki

Suaoki D40 Bedienungsanleitung

Elster

Elster BK-G1.6 Bedienungsanleitung

Endress+Hauser

Endress+Hauser Deltabar FMD71 Handbuch

Duratool

Duratool D03128 Bedienungsanleitung

Vega

Vega VEGAPULS 65 Bedienungsanleitung

Tonghui

Tonghui TH2618B Bedienungsanleitung

Tenmars

Tenmars TM-801 Bedienungsanleitung

MSR

MSR 145 Bedienungsanleitung

TPS

TPS WP-82 Bedienungsanleitung

ELMETRON

ELMETRON CP-511 Bedienungsanleitung

PCB Piezotronics

PCB Piezotronics 003C30 Bedienungsanleitung

Tenma

Tenma 72-10465 Bedienungsanleitung

Endress+Hauser

Endress+Hauser Proline Promag 50 Technische Daten

Siemens

Siemens SITRANS F Coriolis FCT030 Stücklistenhandbuch

KLINGER

KLINGER CMF V Series Bedienungsanleitung

EXFO

EXFO FTB-2 Bedienungs- und Wartungshandbuch

Keysight

Keysight M8290A Bedienungsanleitung

ADTEK

ADTEK MW-5 Bedienungsanleitung