JABSCO 17860 Series Bedienungsanleitung

Model 17860-SERIES

Model 17860 SERIES

FLAT TANK ENGINE OIL

CHANGE SYSTEM

FEATURES

Pum Body: Polypropylene

Dia hragm: *Geolast®, oil resistant

Valves: **Viton®, oil resistant

Motor: 12V/24V DC with integral power

switch

Receiver: Plastic with 3.5 Gal. (13.2L)

(maximum) capacity tank

Battery Leads: 7 ft. (2.1m) with alligator clips

Suction Tube: 8 ft. (2.4m), oil & heat resistant

Dimensions:

Weight: 3.5 lb (1.6 kg)

OPERATING INSTRUCTIONS

Run the engine for approximately 5 minutes to heat oil

to approximately 160°F (71°C), then shut off

engine prior to oil removal.

2. Insert 1/4" (6 mm) tube into pump inlet port and be

sure that it is securely in place.

3. Open the vent cap located on hose retainer strap,

vent cap must be opened to allow tank to vent air.

4. With the pump switch in the off position (to avoid

sparks), clamp the power-leads’ alligator clips to a

12V DC battery (red to positive; black to negative).

5. With the engine off, remove the dipstick, and insert

the 1/4" (6 mm) oil change probe through the dip-

stick tube until it contacts the bottom of the oil pan. It

may help to measure the probe against the dipstick,

add an inch and mark the probe. Do not push the

probe too far into the dipstick tube or it may curl up

and out of the oil. It may be useful to tape the probe

in place during evacuation.

6. To evacuate the oil, switch on the pump using the

rocker switch at the rear of the motor. Watch for flow

in the probe. If no flow appears in 15 seconds, check

the probe for sediment blockage. Clean the probe

and reset it 1/4" (6 mm) off the pan bottom.

The pump will speed up when the oil has been removed.

An average 5 Quart (5 liters) oil capacity engine will take

around 10 minutes to drain.

8. Switch off pump before removing alligator clips from

the battery, to avoid sparks.

9. Remove probe from dipstick tube while wiping with a

rag to prevent oil drips.

10. To empty the container, unscrew the pour cap and

pour the oil into a suitable container for

disposal/recycling.

11. For extended storage, flush pump with water based

degreaser solution.

NOTICE: Always recycle used oil in compliance with

federal and local legislation. andle petroleum products

in an environmentally responsible manner.

*Geolast is a registered trademark of Monsanto.

**Viton is a registered trademark of du Pont de Nemours & Co.

Model Amp Fuse

Number Voltage Draw Size

17860-0012 12 45

17860-0024 24 3 5

Explosion hazard. Motor switch must be in

"OFF" position when connecting and

disconnecting alligator clips to battery terminal

and ground. The switch in an "ON" position can

cause an electrical spark which can result in

explosion. Injury or death can occur. 

WARNING

Explosion hazard. Take necessary precautions

to ventilate area around battery of potentially

explosive gases.Continue ventilation during

oil changing procedure. Failure to do so can

result in explosion. Injury or death can occur.

WARNING

THE PR DUCTS DESCRIBED HEREIN ARE

SUBJECT T THE JABSC NE YEAR LIMITED

WARRANTY, WHICH IS AVAILABLE F R Y UR

INSPECTI N UP N REQUEST.

Part

Key Description Qty. Number

1 Cap 1 17864-0000

2 Pump 12V 1 17869-0012

Pump 24V 1 17869-0024

3 Tank 1 17866-0000

4 Hose 1 17867-0000

5 Bag (For Hose, Not Shown) 1 17868-0000

Burn Hazard. Heated oil can cause burns.

Wear protective gloves, clothing and safety

glasses during the oil change process.

Failure to do so may result in personal injury.

WARNING

For quicker oil changes, start engine

and run for 5 minutes to heat the oil.

Remove the dipstick and insert the

suction probe.

Attach the power cord clips to the

engine’s battery.

Red = Positive, Black = Negative

Activate pump with switch on motor to

drain crankcase.

KEY

U.S.A.

Flojet

666 E. Dyer Rd.

Santa Ana, CA 92705

Phone: 714.557.4700

Fax: 714.628.8478

UNITED KINGDOM

ITT Corporation

Bingley Road, oddesdon

ertfordshire EN11 OBU

Tel: +44 (0) 1992 450145

Fax: +44 (0) 1992 467132

JAPAN

N K Jabsco Company Ltd.

3-21-10, Shin-Yokohama

Kohoku-Ku, Yokohama, 222

Tel: 045.475.8906

Fax: 045.475.8908

GERMANY

Jabsco Gmb

Oststrasse 28

22840 Norderstedt

Tel: +49-40-53 53 73 -0

Fax: +49-40-53 53 73 -11

ITALY

ITT Corporation

Via Tommaseo, 6

20059 Vimercate, Milano

Tel: +39 039 685 2323

Fax: +39 039 666 307

Dieses Handbuch passt für folgende Modelle

Andere JABSCO Wasserpumpe Handbücher

JABSCO

JABSCO 37202-2 Bedienungsanleitung

JABSCO

JABSCO 23230-2012 Bedienungsanleitung

JABSCO

JABSCO 31595-009 Bedienungsanleitung

JABSCO

JABSCO 30580-0 Series Bedienungsanleitung

JABSCO

JABSCO 30510-0 Series Bedienungsanleitung

JABSCO

JABSCO 30550-0 Series Bedienungsanleitung

JABSCO

JABSCO 59520 Series Bedienungsanleitung

JABSCO

JABSCO 30520-1001 Bedienungsanleitung

JABSCO

JABSCO 12490 Series Bedienungsanleitung

JABSCO

JABSCO 30520-0001 Bedienungsanleitung

JABSCO

JABSCO 31395-0092 Bedienungsanleitung

JABSCO

JABSCO 52700 Bedienungsanleitung

JABSCO

JABSCO 18590 Series Bedienungsanleitung

JABSCO

JABSCO 18670 Series Bedienungsanleitung

JABSCO

JABSCO 50890 Bedienungsanleitung

JABSCO

JABSCO 30910-0000 Bedienungsanleitung

JABSCO

JABSCO 31295 Series Bedienungsanleitung

JABSCO

JABSCO 59510-Series Bedienungsanleitung

JABSCO

JABSCO 51270 Series Bedienungsanleitung

JABSCO

JABSCO 30510-1003 Bedienungsanleitung

JABSCO

JABSCO 30570-2 series Bedienungsanleitung

JABSCO

JABSCO HD Series Bedienungsanleitung

JABSCO

JABSCO 50870 Series Bedienungsanleitung

JABSCO

JABSCO 18690-0000 Bedienungsanleitung

Beliebte Wasserpumpe Handbücher anderer Marken

Neptun

Neptun NPHW 5500 Bedienungsanleitung

Sensidyne

Sensidyne Gilian BDX-II Montage- und Bedienungsanleitung

Draper

Draper 47808 Bedienungsanleitung

Trolla

Trolla 12820 Bedienungsanleitung

Sunfab

Sunfab SVH Series Bedienungsanleitung

WilTec

WilTec 50740 Bedienungsanleitung

Fieldmann

Fieldmann FVC 5015 EK Bedienungsanleitung

Everbilt

Everbilt EFSUB5-122HD Bedienungsanleitung

Graco

Graco Husky 3300e Bedienungsanleitung

esotec

esotec 101018 Bedienungsanleitung

Becker

Becker BASIC VASF 2.80/1-0.AC230 Bedienungsanleitung

Sykes AmeriPumps

Sykes AmeriPumps GP100M Fehlerbehebungshandbuch

DUROMAX

DUROMAX XP WX Series Bedienungsanleitung

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Bedienungsanleitung

Franklin Electric

Franklin Electric IPS Bedienungsanleitung

Xylem

Xylem e-1532 Series Bedienungsanleitung

Milton Roy

Milton Roy PRIMEROYAL Bedienungsanleitung

STA-RITE

STA-RITE ST33APP Bedienungsanleitung