JABSCO 23230-2012 Bedienungsanleitung

MODELS:

23230-2012 12 Volts DC

23230-2024 24 Volts DC

GEAR PUPPY

FEATURES:

Medium duty pumps for general purpose

use.

lISO 8846 MARINE (Ignition protection)

lMaximum viscosity 150Cs

lInlet filter included

lSimple design means fewer wearing

parts

l24.5 lpm (6.5 US gpm) output @ 5m (16.4ft)

head

lSelf priming to 1.0m (3 ft)

lIdeal for water, oil and diesel transfer

INSTALLATION INSTRUCTIONS:

Jabsco Gear Puppy can be mounted on any flat

surface. Fit the pump in a dry, well ventilated

position. If installed in a vertical position the motor

must be above the pump head. Use the rubber

grommets provided to minimise vibration, do not

overtighten the mounting screws.

Secure 16mm (5/8”) id hose direct to the discharge

ports using stainless steel hose clamps. Use spiral

reinforced hose (with a smooth internal bore) that will

not collapse under suction, or rigid or semi rigid

pipework systems. The pipework must be compatible

with the liquid being pumped. Pipe runs should be

kept as straight and short as possible, avoiding rising

and dipping over obstructions. Fit a filter on the inlet

to prevent debris from entering the pump.

WIRING INSTRUCTIONS

Make all electrical connections in dry locations,

connections in humid environments should be sealed

to prevent corrosion. Protect the circuit with a

correctly rated fuse or circuit breaker in the red

positive (+) lead as close as possible to the power

source. Connect the black motor wire to the negative

(-) battery terminal. Inadequate voltage at the motor

terminals when the pump is running (not less than

10% below rated voltage at full load) due to partially

discharged batteries or insufficient cable size may

result in blowing fuses, failure to start or poor pump

performance.

WARNING: If the fuse fails

repeatedly do not fit a heavier fuse or

bridge the fuse terminals with silver

paper or metal wire. Failure to observe

this instruction may result in a fire

hazard due to overheating of cables.

WARNING: All marine pumps

discharging overboard must be

installed with the overboard discharge

well above both static and heeled

waterlines.

m ft lpm US gpm

0 0 26 6.9

5 16.4 24.5 6.5

10 33 22.5 6.0

15 49 20 5.3

20 65 17 4.5

GEAR PUPPY PERFORMANCE

Approximate performance for new pump,

running water at 20°C with fully charged battery

TOTAL HEAD

GEAR PUPPY

WARNING: Do not use any Jabsco

pump for petrol, petroleum products or

any products with a flash point below

37°C (98°F), explosion or death may

occur.

PART

NUMBERS

VOLTAGE

MAXIMUM

AMP

DRAW

MAXIMUM

FUSE

SIZE

MINIMUM WIRE

SIZE

MAXIMUM LENGTH

BETWEEN (+) & (-)

BATTERY TERMINALS

23230-2012 12 volt 12 amp 15 amp

30 / 0.25mm

(1.5mm²)

4.5m (15ft) *

23230-2024 24 volt 5 amp 7.5 amp

32 / 0.2mm

(1.0mm²)

4.5m (15ft) *

Electrical Wiring Information

DIMENSIONAL DRAWING

WEIGHT: Gear Puppy - 2.2kg (4.8lb)

Warranty: All products of the company are sold and all services of the company are offered subject to the company’s warranty and terms and conditions of sale, copies of which will be furnished upon request.

Jabsco

ITT Industries

Jabsco, 1 Kondelin Road, Cape Ann Industrial Park, Gloucester, MA 01930

Tel : +1 978 281 0440 Fax : +1 978 283 2619

Jabsco, Bingley Road, Hoddesdon, Hertfordshire, EN11 0BU

Tel : +44 (0) 1992 450 145 Fax : +44 (0) 1992 467 132

Fluid Products Canada,55 Royal Road, Guelph, Ontario N1H 1T1

Tel : +1 519 821 1900 Fax : +1 519 821 5316

NHK Jabsco Co Ltd,3-21-10, Shin - Yokohama, Kohoku-ku, Yokohama 222

Tel : +81 (0) 45 475 8906 Fax : +81 (0) 45 475 8908

Jabsco GmbH,Oststraße 28, 22844 Norderstedt

Tel : +49 (0) 40 53 53 73 0 Fax : +49 (0) 40 53 53 73 11

USA

CANADA

JAPAN

GERMANY

Discover Jabsco at www.jabsco.com

* For longer installations, fit thicker cables

All dimensions are in mm

Rev 10/03 43000-0796

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere JABSCO Wasserpumpe Handbücher

JABSCO

JABSCO 30520-5 Series Bedienungsanleitung

JABSCO

JABSCO 31295-0092 Bedienungsanleitung

JABSCO

JABSCO 5850-0001 Bedienungsanleitung

JABSCO

JABSCO 36680-2 Series Bedienungsanleitung

JABSCO

JABSCO 1673-Series Bedienungsanleitung

JABSCO

JABSCO 30510-0 Series Bedienungsanleitung

JABSCO

JABSCO 6400 Series Bedienungsanleitung

JABSCO

JABSCO 51510 Series Bedienungsanleitung

JABSCO

JABSCO 18400-0050 Bedienungsanleitung

JABSCO

JABSCO 30296 Series Bedienungsanleitung

JABSCO

JABSCO 22060-7125-C Bedienungsanleitung

JABSCO

JABSCO 50870 Series Bedienungsanleitung

JABSCO

JABSCO 37202-2 Bedienungsanleitung

JABSCO

JABSCO 30510-1003 Bedienungsanleitung

JABSCO

JABSCO VR050-2022 Bedienungsanleitung

JABSCO

JABSCO 51270 Series Bedienungsanleitung

JABSCO

JABSCO HD Series Bedienungsanleitung

JABSCO

JABSCO 4720 Series Bedienungsanleitung

JABSCO

JABSCO 11860 Series Bedienungsanleitung

JABSCO

JABSCO 18690-0000 Bedienungsanleitung

JABSCO

JABSCO 52700 Bedienungsanleitung

JABSCO

JABSCO 11860-0005 Bedienungsanleitung

JABSCO

JABSCO CENTRI PUPPY 18510-000 Series Bedienungsanleitung

JABSCO

JABSCO 36600-0000 Bedienungsanleitung

Beliebte Wasserpumpe Handbücher anderer Marken

Neptun

Neptun NPHW 5500 Bedienungsanleitung

Sensidyne

Sensidyne Gilian BDX-II Montage- und Bedienungsanleitung

Draper

Draper 47808 Bedienungsanleitung

Trolla

Trolla 12820 Bedienungsanleitung

Sunfab

Sunfab SVH Series Bedienungsanleitung

WilTec

WilTec 50740 Bedienungsanleitung

Fieldmann

Fieldmann FVC 5015 EK Bedienungsanleitung

Everbilt

Everbilt EFSUB5-122HD Bedienungsanleitung

Graco

Graco Husky 3300e Bedienungsanleitung

esotec

esotec 101018 Bedienungsanleitung

moyno

moyno 2000 CC Bedienungsanleitung

Becker

Becker BASIC VASF 2.80/1-0.AC230 Bedienungsanleitung

Sykes AmeriPumps

Sykes AmeriPumps GP100M Fehlerbehebungshandbuch

DUROMAX

DUROMAX XP WX Series Bedienungsanleitung

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Bedienungsanleitung

Franklin Electric

Franklin Electric IPS Bedienungsanleitung

Xylem

Xylem e-1532 Series Bedienungsanleitung

Milton Roy

Milton Roy PRIMEROYAL Bedienungsanleitung