Joerns Hoyer Calibre Bedienerhandbuch

User Instruction Manual

Hoyer®Calibre

To avoid injury, read user manual prior to use.

Hoyer®

Calibre

English

Contents

1. The Hoyer Calibre Patient Lift........................................................................... 3

2. Introduction: About Your Lift ............................................................................. 4

3. Assembly and Commissioning Instructions ...................................................... 5

4. Safety Precautions ............................................................................................ 10

5. Standard Control Box & Handset...................................................................... 12

6. Smart Monitor & Handset .................................................................................. 13

7. Operating Instructions ....................................................................................... 17

8. Removal of 6-point Cradle System ................................................................... 19

9. Charging Instructions ........................................................................................ 21

10. Maintenance Schedule & Daily Check List ....................................................... 22

11. Technical Specifications.................................................................................... 24

12. Warranty............................................................................................................ 27

Hoyer®

Calibre

English

1. The Hoyer Calibre Patient Lift

Boom

6-point Cradle

Electric Actuator

Mast

Rear Castor

(braked)

Push Handle

Battery/

Control Pack

Front Castor

(non-braked)

Foot Push Pad

Straight Line

Steering Device

Hoyer®

Calibre

English

2. Introduction: About Your Lift

Each Calibre lift is fully load tested and certified before being packed/shipped.

The packing consists of a strong, purpose built carton that is used for both export and domestic

markets to ensure the safe arrival of the lift. A number of documents are supplied in a wallet, and

packed with each lift and should be kept safely for future reference.

• TEST CERTIFICATE

• USER MANUAL

The TEST CERTIFICATE is an important document and will be required for your insurance

records. It is valid for six months and after it has expired the lift should be inspected and serviced

per the maintenance schedule.

To properly maintain your lift please refer to the maintenance schedule included in this document. If

you are at all unsure what your country’s servicing requirements are, please check with your dealer

and/or a local government agency.

Statement of Intended Use

The Hoyer Calibre lift is a passive patient handling device intended for the safe lifting and

transferring of patients up to a safe working load of 385 kg (850 lbs).

The Hoyer Calibre lift is intended for INDOOR USE ONLY and must be operated by a MINIMUM

of two people/carers.

The Hoyer Calibre is an electrically operated patient lift, designed to support and promote safe

patient handling and transfer for both the patient and carer.

The Hoyer Calibre is suitable for patients in the SITTING, SITTING/RECUMBENT and

RECUMBENT positions. The slings suitable for use with this device are listed as follows:

• Hoyer Bariatric Hammock Sling (Safe working load - 385kg / 850lbs)

Expected Service Life

Hoyer Professional lifts are designed and tested for a minimum service life of ten (10) years,

subject to the use and maintenance procedures stated in this manual. Use, other than in accordance

with these instructions, may compromise service life.

Hoyer®

Calibre

English

3. Assembly and Commissioning Instructions

Carton Contents

Place the carton in a clear working area and open carefully. The carton contains:

•HOYER CALIBRE LIFT •WALLET CONTAINING DOCUMENTS

•HAND CONTROL •BATTERY PACK

•CHARGING LEAD •DESK TOP CHARGER/STAND

Tools required

The following tools will be required for assembly:

•13MM SOCKET •TORQUE WRENCH

WARNING

Assembly and commissioning must be carried out by a competent engineer from an

authorised Hoyer Service Agent/Dealer.

WARNING

A MINIMUM OF 2 PERSONS REQUIRED. The Hoyer Calibre is heavy and will need to be

lifted with care. You will need assistance to lift the Hoyer Calibre from the carton.

Assembly Instructions

Remove all the parts from the carton and place on the floor, taking care to protect the paint finish

from damage.

1. Place the mast/base assembly in a clear space and lay with rear castors and push handle on floor.

2. Fit the left and right hand legs (check correct orientation) onto the chassis using two M10

screws per leg as provided.

Hoyer®

Calibre

English

3. Tighten the M10 screws to secure each leg using a socket and torque wrench.

WARNING

Ensure the screws are secured firmly. It is recommended to tighten these to 10Nm

WARNING

Avoid trapping fingers. Keep fingers away from the end of the leg when inserting into the leg

socket. Keep fingers away from the front castor bracket during assembly of the legs to the base.

4. Lift the Calibre onto its castors.

NOTE: On a flat surface, all 6 castors must be in contact with the floor.

WARNING

The Calibre is extremely heavy, a minimum of 2 people will be required to lift the hoist.

5. Insert the two bushings into the outside of the mounting brackets on either side of the boom.

Lift the boom and position the actuator so that the upper fixing hole align with the mounting

bracket holes on the boom.

Hoyer®

Calibre

English

6. Insert quick-release pin sleeve into mounting bracket/actuator hole. make sure the sleeve is

fully engaged in the hole on both mounting brackets.

7. Insert the quick-release pin through the quick-release pin sleeve until it is fully located.

WARNING

Check that the quick-release pin has been fully inserted by trying to push the pin back out.

8. Fit power pack to the lift and make sure the latch holding the pack in place is fully engaged.

“Click” in place. Check that the battery is fully charged.

9. Plug the handset and actuator cables into the bottom of the controller. Refer to the figures on

page 12 or 13 for correct positions.

Hoyer®

Calibre

English

Disassembly

WARNING

Disassembly must be carried out by a competent engineer from an authorised Hoyer Service

Agent/Dealer.

The lift should not be disassembled unless for service, repair or transport if necessary. Therefore

follow the assembly instructions in reverse sequence.

ALWAYS CHECK THE FOLLOWING BEFORE OPERATION

• The mast is fully locked into position by checking the grub screws at the front and rear of the

base are tight.

• The red emergency stop button, located on the rear of the control box, is in the OFF (out)

position.

Front grub screw

Rear grub

screw

Hoyer®

Calibre

English

• The legs of the lift open and close satisfactorily (This is done via the hand control).

• Push the up and down buttons on the hand control and confirm the boom rises and lowers.

Hoyer®

Calibre

English

4. Safety Precautions

Please read and follow the safety precautions listed below. The operation and use of Hoyer

patient lifts is simple and straight-forward. Following these few basic safety precautions will make

lifting operations easy and trouble free.

Please read and follow the safety precautions listed below. The operation and use of Hoyer

patient lifts is simple and straightforward. Following these few basic safety precautions will make

lifting operations easy and trouble free.

READ AND UNDERSTAND THE USER INSTRUCTION MANUAL BEFORE USING THE

HOYER CALIBRE LIFT

WARNING: Important safety information for hazards that might cause serious injury.

CAUTION: Information for preventing damage to the product.

NOTE: Information to which you should pay special attention.

WARNING

• DO NOT lift a patient unless you are trained and competent to do so.

• ALWAYS carry out the DAILY CHECK LIST located towards the end of the manual

before using the lift.

• DO NOT exceed the safe working load of the lift.

• ALWAYS plan your lifting operations before commencing.

• ALWAYS familiarize yourself with the operating control and safety features of a lift

before lifting a patient.

• DO NOT use a sling unless it is recommended for use with the lift.

• ALWAYS check the sling is suitable for the particular patient and is of the correct

size and capacity.

• NEVER use a sling, which is frayed or damaged.

• ALWAYS fit the sling according to the instructions provided (user instructions).

• ALWAYS check the safe working load of the lift is suitable for the weight of the

patient.

• ALWAYS carry out lifting operations according to the instructions in the user manual.

• NEVER disconnect or bypass a control or safety feature because it seems easier to

operate the lift.

• ALWAYS lock the wheels when lifting from the floor.

• DO NOT attempt to manoeuvre the lift by pushing on the mast, boom or patient.

• ALWAYS manoeuvre the lift with the handle provided. A foot push pad is also

provided.

Inhaltsverzeichnis

Andere Joerns Medizinische Geräte Handbücher

Joerns

Joerns Oxford Bedienerhandbuch

Joerns

Joerns Hoyer Bedienungsanleitung

Joerns

Joerns Oxford Elara Series Bedienerhandbuch

Joerns

Joerns Oxford Presence Bedienerhandbuch

Joerns

Joerns Oxford Mini Series Bedienerhandbuch

Joerns

Joerns Oxford Bedienerhandbuch

Joerns

Joerns Oxford Bedienerhandbuch

Joerns

Joerns Hoyer Bedienerhandbuch

Joerns

Joerns Oxford Bedienungsanleitung

Joerns

Joerns Dolphin Fluid Immersion Simulation System Fehlerbehebungshandbuch

Joerns

Joerns Hoyer HPL450 Bedienungsanleitung

Joerns

Joerns OXford Full Body (Hybrid) Bedienerhandbuch

Joerns

Joerns Hoyer HPL700 Leitfaden

Joerns

Joerns Chauffeur Fehlerbehebungshandbuch

Joerns

Joerns Oxford Stature Bedienungsanleitung

Joerns

Joerns Arise LAL 1000 EX Fehlerbehebungshandbuch

Joerns

Joerns Hoyer Comfort Access Bedienerhandbuch

Joerns

Joerns ACX Series Fehlerbehebungshandbuch

Joerns

Joerns Oxford UltraFine Deluxe Bedienerhandbuch

Joerns

Joerns ProCair Plus Fehlerbehebungshandbuch

Joerns

Joerns WeCare Bed Fehlerbehebungshandbuch

Joerns

Joerns CairTurn RT Fehlerbehebungshandbuch

Joerns

Joerns DermaFloat LR Fehlerbehebungshandbuch

Joerns

Joerns Oxford Stretcher Adjustment Cradle Bedienerhandbuch

Beliebte Medizinische Geräte Handbücher anderer Marken

TekTone

TekTone Tek-CARE160 Bedienungsanleitung

NeuroMetrix

NeuroMetrix Quell 2.0 Bedienungsanleitung

AMT

AMT XLR8 Bedienungsanleitung

EDAN

EDAN SONOTRAX Pro Bedienungsanleitung

Restorative Therapies

Restorative Therapies RT300 Bedienungsanleitung

Gendex

Gendex Expert DC Bedienungsanleitung

Dexcowin

Dexcowin ADX4000W Bedienungsanleitung

Libelium

Libelium MySignals Bedienungsanleitung

Acelity

Acelity V.A.C.ULTA 4 Bedienungsanleitung

Caputron

Caputron ActivaDose II tDCS Bedienungsanleitung

Plinth 2000

Plinth 2000 93CDT Bedienungsanleitung

GE SENOGRAPHE 800T Bedienungsanleitung

GE Definium 5000 Bedienungsanleitung

Kanmed

Kanmed GE-1380 Bedienungsanleitung

Huntleigh

Huntleigh FD1 Bedienungsanleitung

Stryker

Stryker SPR Plus Bedienungsanleitung

Tobii Dynavox

Tobii Dynavox I-Series Bedienungsanleitung

S-Capepod

S-Capepod Evac Cocoon Bedienungsanleitung