Keys Fitness Encore 4500 Bedienungsanleitung

KEYS Fitness Products, LP

P.O. Box 551239

Dallas, Texas 75239

OWNER’S MANUAL

ENCORE 4500/6500HR TREADMILL

Table of Contents

Table of Contents 2

Specification Sheet 3

Important Safety Information 4

Before You Start 5

Warm Up Exercises 6

Assembly, Moving Instructions 7

Power Requirements 8

Console Functions and Descriptions 9 & 10

Program and Operating Instructions 11, 12, 13, &14

Program Instructions Heart rate 15 & 16

Program Descriptions and Profiles 17

Belt Adjustments and Tension 18

Maintenance Instructions 19

Change to MPH or KM 20

Troubleshooting Guide 21

Parts and Diagrams 22 & 23

Parts List 24

Warranty Registration (Mail In Form) 25

Information Page #

Page 2

EC4500 EC6500HR

♦Horsepower (Continuous) 2.0hp 2.5hp

♦Display Type 4 Window LCD 5 Window LED

♦Electronics Push button Push button

♦Pre-Set Programs 3 4

♦Custom Programs 6 8

♦User Programs 0 2

♦Heart rate interactive No Yes

♦Speed/Incline Toggles Switches No Yes

♦Power Incline 0-12% 0-12%

♦Roller Diameter 2.5” 2.5”

♦Cushioned Deck Yes Yes

♦Speed Range 0-10mph 0-10mph

♦Belt Size 20 x 56” 20 x 56”

♦Side Hand Rails Yes Yes

♦Foot Print 32 x 71” 32 x 71”

♦Foot Print Folded 32 x 26” 32 x 26”

♦Warranty Motor 10 Years 10 Years

♦Warranty Parts 2 Years 2 Years

♦Warranty Labor 2 Year 2 Years

♦Warranty Frame Lifetime Lifetime

Specification Sheet

PAGE 3

Important Safety Information

1) WARNING! Before using this treadmill or starting any exercise program, consult your physician. This is

especially important for persons over the age of 35 and/or persons with pre-existing health problems. The

manufacturer or distributor assumes no responsibility for personal injury or property damage sustained by or

through the use of this product.

2) WARNING! To reduce the risk of electrical shock, burns, fire, or other possible injuries to the user, it

is important to review this manual and the following precautions before operation.

SAFETY PRECAUTIONS AND TIPS

♦It is the owner’s responsibility to ensure that all users of this treadmill have read the Owner’s Manual and

are familiar with warnings and safety precautions.

♦This treadmill has a user maximum capacity of 275 pounds.

♦The treadmill should only be used on a level surface and is intended for indoor use only. The treadmill

should not be placed in a garage, patio, or near water and should never be used while you are wet. KEYS

recommends a treadmill mat be placed under the treadmill to protect floor or carpet and for easier

cleaning.

♦Follow safety information in regards to plugging in your treadmill. Keep the power cord away from the

incline wheels and do not run the power cord underneath your treadmill. Do not operate the treadmill with

a damaged or frayed power cord.

♦Wear comfortable, good-quality walking or running shoes and appropriate clothing. Do not use the

treadmill with bare feet, sandals, socks or stockings.

♦Always straddle the belt and allow it to start moving before stepping onto the belt.

♦Hold on to handrails when adjusting speed, incline, or other controls.

♦Always examine your treadmill before using to ensure all parts are in working order.

♦Allow the belt to fully stop before dismounting.

♦Pets should never be allowed near or on the treadmill.

♦Do not leave children unsupervised near or on the treadmill.

♦Never operate the treadmill where oxygen is being administered, or where aerosol products are being

used.

♦Never insert any object or body parts into any opening.

♦For safety and to prevent damage to your treadmill, no more than one person should use the treadmill at a

time.

♦Always unplug the treadmill before cleaning and/or servicing. Service to your treadmill should only be

performed by an authorized service representative, unless authorized and/or instructed by the

manufacturer. Failure to follow these instructions will void the treadmill warranty.

♦Never leave the treadmill unattended while it is running.

PAGE 4

Thank you for purchasing a KEYS treadmill! The ENCORE 4500/6500HR treadmill was designed to

meet your needs for cardiovascular exercise.

Before you start, please read the Owner’s Manual and become familiar with the operation of your new

treadmill.

♦Remember to take the time to perform the stretching exercises provided on Page 6 to avoid

injury.

♦Do not stand on the walking belt while pressing the Power button or Start/Stop button.

♦Always adjust the speed of the treadmill in small increments as this treadmill is capable of high

speeds.

♦If you are taking medication, consult your physician to see if the medication will affect your exercise

heart rate.

♦If you have heart problems, you are not active, and/or are over the age of 35 years, do not use the

pre-set treadmill programs or start an exercise program without first contacting and receiving approval

from your physician.

♦To avoid the risk of electrical shock, always keep the console dry. Do not spill liquids on the console.

KEYS recommends a sealed water bottle for beverages consumed while using the treadmill.

♦Please review the following picture below to familiarize yourself with the listed parts. This manual covers several

treadmills, so the one pictured below may not be identical to your particular model.

Before You Start

PAGE 5

SAFETY LATCH

ELECTRONIC DISPLAY

CONSOLE

WATER BOTTLE

HOLDER

(WATER BOTTLE NOT INCLUDED)

SIDE HAND RAILS

UPRIGHTS

MOTOR COVER

WHEEL

REAR ROLLER

ADJUSTMENT BOLTS

FOOT RAILS

WALKING BELT

READING RACK

Warm Up Exercises

EXERCISE GUIDELINES

WARNING! Before beginning this or any exercise program, you should consult your physician. This is es-

pecially important for individuals over the age of 35 or individuals with pre-existing health problems.

Warming up prepares the body for the exercise by increasing circulation, supplying more oxygen to the

muscles and raising body temperature. Begin each workout with 5 to 10 minutes of stretching and light ex-

ercise to warm up. The photos on this page show several forms of basic stretching you may perform before

your workouts. In order to achieve an adequate warm-up, perform each stretch three times.

TOE TOUCH STRETCH

Stand bending your knees slightly and slowly bend

forward from your hips. Allow your back and shoul-

ders to relax as you reach down toward your toes as

far as possible. Hold for 15 counts, then relax. This

will stretch your hamstrings, back of knees , and

back.

HAMSTRING STRETCH

Sit with one leg extended. Bring the sole of the op-

posite foot toward you and rest it against the inner

thigh of your extended leg. Reach toward your toes

as far as possible. Hold for 15 counts, then relax.

This will stretch your hamstrings, lower back, and

groin.

CALF/ACHILLES STRETCH

With one leg in front of the other, reach forward and

place your hands against a wall. Keep your back leg

straight and your back foot flat on the floor. Bend

your front leg, lean forward and move your hips to-

ward the wall. Hold for 15 counts, then relax. To

cause further stretching of the Achilles tendons,

bend your back leg as well. This will stretch your

calves, Achilles tendons, and ankles.

QUADRICEPS STRETCH

With one hand against a wall for balance, reach

back and grasp one foot with your other hand.

Bring your heel as close to your buttocks as possi-

ble. Hold for 15 counts, then relax. This will stretch

your quadriceps and hip muscles.

INNER THIGH STRETCH

Sit with the soles of your feet together and your knees

outward. Pull your feet toward your groin area as far as

possible. Hold for 15 counts, then relax. This will

stretch your quadriceps and hip muscles.

PAGE 6

The EC4500 and EC6500HR is shipped in two pieces, please see assembly instructions below. After

opening the box, remove any packing materials from the treadmill. Do not throw away any packing

materials until the unit is working properly. Place the base on a clean, level surface. Make sure the

electrical cord will easily reach an electrical outlet.

Assembly

See Figure 1

To attach End cap:

1. Place plastic end cap over exposed rear roller area.

2. Align holes in plastic end cap with pre-drilled holes in frame.

3. Loosely tighten each screw until all four screws are lined up.

4. Tighten all four screws snugly.

Moving

See Figure 2

CAUTION! TO AVOID THE RISK OF INJURY, NEVER ATTEMPT TO MOVE THE TREADMILL WHILE IT IS IN THE

UNFOLDED OPERATING POSITON. TO REDUCE THE POSSIBILITY OF INJURY WHILE LIFTING, BEND YOUR

LEGS AND KEEP YOUR BACK STRAIGHT. AS YOU RAISE THE TREADMILL, LIFT USING YOUR LEGS, NOT

YOUR BACK. IN ORDER TO RAISE OR LOWER THE TREADMILL SAFELY, YOU MUST BE ABLE TO LIFT 45

POUNDS (20KG). IT IS SUGGESTED YOU ALWAYS USE THE AID OF A SECOND PERSON WHEN MOVING THE

TREADMILL.

With the treadmill in the folded locked position (safety latch is engaged), grasp the handrails and place one foot on the base as

shown in the photo below. Next, with a firm grasp on handrails, place one foot on the center of the base crossbar and carefully

tilt the treadmill back until it rolls freely on the wheels. Using extreme caution, move the treadmill to the desired location. To

set the treadmill down, place one foot on the center of the base crossbar and carefully lower treadmill onto base in resting

position. Do not attempt to move the treadmill over an uneven or rough surface.

Assembly, Moving Instructions

PAGE 7

Figure 2

Figure 1

ARNG!

IMPROPER CONNECTION OF THE EQUIPMENT GROUNDING CONNECTOR CAN RESULT IN A

RISK OF AN ELECTRIC SHOCK. CHECK WITH A QUALIFIED ELECTRICIAN OR SERVICE MAN

IF YOU ARE IN DOUBT AS TO WHETHER THE PRODUCT IS PROPERLY GROUNDED. DO NOT

MODIFY THE PLUG PROVIDED WITH THE PRODUCT, IF IT WILL NOT FIT THE OUTLET, HAVE

A PROPER OUTLET INSTALLED BY A QUALIFIED ELECTRICIAN.

This treadmill can be seriously damaged by sudden voltage changes in your home’s electrical power.

Voltage spikes, surges, and noise interference can result from weather conditions or from other appliances

being turned on or off. To reduce the possibility of treadmill damage, always use a surge protector (not

included) with your treadmill.

Surge protectors can be purchased at most hardware stores. The manufacturer recommends a single outlet

surge protector with a UL 1449 rating as a Transient Voltage Surge Suppressor (TVSS) with a UL

suppressed voltage rating of 400V or less and an electrical rating of 120VAC, 15 amps.

This treadmill must be grounded to reduce the risk of electrical shock. Grounding provides a path of least

resistance for electric current, should the treadmill malfunction. This treadmill comes with an electrical

cord having an equipment-grounding conductor and a grounding plug. Always plug the power cord into a

surge protector, and plug the surge protector into an appropriate outlet that is properly installed and

grounded in accordance with all local codes and ordinances.

This product is for use on a nominal 120-volt circuit and has a grounding plug that looks like the plug

illustrated in the drawing below.

Power Requirements

PAGE 8

SPEED WINDOW

INCLINE WINDOW

EC4500

There are four display windows on the control panel to provide feedback information.

TIME WINDOW

♦TIME: Indicates elapsed time after pressing start in minutes and seconds (0-99 minutes, 0-59 seconds)

♦INTERVAL TIME: Indicates countdown in seconds to the next interval starting at 5 seconds and counting to

0 seconds

SPEED WINDOW

♦SPEED: Indicates MPH (miles per hour) or KMH (kilometer per hour) in .1 increments

DISTANCE / CALORIES WINDOW

♦DISTANCE: Indicates Miles or Kilometers traveled in .01 increments up to 9.99 and .1 increments starting at

10.0

♦CALORIES: Indicates estimated calories used based on 150 lb. person at the indicated speed, incline, and

time

INCLINE WINDOW

♦INCLINE: Indicates incline in percent of grade 0-12% in .5 increments

Console Functions and Descriptions

PAGE 9

TIME WINDOW

DISTANCE/CALORIE WINDOW

SPEED WINDOW

INCLINE WINDOW

EC6500HR

There are five display windows on the control panel to provide feedback information.

WORKOUT TIME/PACE WINDOW

♦TIME: Indicates elapsed time after pressing start in minutes and seconds (0-99 minutes, 0-59 seconds)

♦INTERVAL TIME: Indicates countdown in seconds to the next interval starting at 5 seconds and counting to

0 seconds

♦PACE: Indicates amount of time required to complete 1 mile at current speed.

SPEED WINDOW

♦SPEED: Indicates MPH (miles per hour) or KMH (kilometer per hour) in .1 increments

DISTANCE / CALORIES WINDOW

♦DISTANCE: Indicates Miles or Kilometers traveled in .01 increments up to 9.99 and .1 increments starting at

10.0

♦CALORIES: Indicates estimated calories used based on 150 lb. person at the indicated speed, incline, and

time

INCLINE WINDOW

♦INCLINE: Indicates incline in percent of grade 0-12% in 0.5 increments

CENTER BRICKYARD WINDOW

♦Displays quarter mile track in Manual mode. Indicates position on track by a blink. In program mode, shows

Console Functions and Descriptions

PAGE 10

TIME WINDOW CALORIE/DISTANCE WINDOW

CENTER BRICKYARD WINDOW

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Keys Fitness Tretmühle Handbücher

Keys Fitness

Keys Fitness ENCORE 1350 Bedienungsanleitung

Keys Fitness

Keys Fitness DCV560HR Bedienungsanleitung

Keys Fitness

Keys Fitness Health Trainer 800HR Treadmill HT800HR Bedienungsanleitung

Keys Fitness

Keys Fitness KF-T4-0 Bedienungsanleitung

Keys Fitness

Keys Fitness HT9000 Bedienungsanleitung

Keys Fitness

Keys Fitness 6600t Bedienungsanleitung

Keys Fitness

Keys Fitness 4600T Bedienungsanleitung

Keys Fitness

Keys Fitness CardioZone CZ PRO Bedienungsanleitung

Keys Fitness

Keys Fitness 8500 Bedienungsanleitung

Keys Fitness

Keys Fitness Alliance 900 Bedienungsanleitung

Keys Fitness

Keys Fitness Discovery 100 DCV100 Bedienungsanleitung

Keys Fitness

Keys Fitness 4500T Bedienungsanleitung

Keys Fitness

Keys Fitness CardioZone CZE Bedienungsanleitung

Keys Fitness

Keys Fitness Treadmill Bedienungsanleitung

Keys Fitness

Keys Fitness ALL800 Bedienungsanleitung

Keys Fitness

Keys Fitness HT2-0 Bedienungsanleitung

Keys Fitness

Keys Fitness ALLIANCE 950HR-OB Bedienungsanleitung

Keys Fitness

Keys Fitness KF-2-5T Bedienungsanleitung

Keys Fitness

Keys Fitness 5500T Bedienungsanleitung

Keys Fitness

Keys Fitness HealthTrainer HT-740T Bedienungsanleitung

Keys Fitness

Keys Fitness PRO 750 Bedienungsanleitung

Keys Fitness

Keys Fitness Triumph 8.3 Treadmill TRI-8.3t Bedienungsanleitung

Keys Fitness

Keys Fitness HT75t Bedienungsanleitung

Keys Fitness

Keys Fitness Treadmill HT901 Bedienungsanleitung

Beliebte Tretmühle Handbücher anderer Marken

Treadly

Treadly TREADLY 2 Bedienungsanleitung

HEALTH ONE

HEALTH ONE Walk Ro Bedienungsanleitung

NordicTrack

NordicTrack T7.5 S Bedienungsanleitung

Gold's Gym

Gold's Gym ADVANTAGE GGTL12920 Bedienungsanleitung

Merax

Merax MS282992 Bedienungsanleitung

FYTTER

FYTTER RU-2SX Bedienungsanleitung

Precor

Precor 903 Bedienungsanleitung

FitLogic

FitLogic freewill d225 Bedienungsanleitung

HOP-SPORT

HOP-SPORT ESTIMA HS-3200LB Bedienungsanleitung

Horizon Fitness

Horizon Fitness Adventure 5 Plus Bedienungsanleitung

Stamia

Stamia InMotion II Bedienungsanleitung

Smooth Fitness

Smooth Fitness EVO 3i Bedienungsanleitung

NordicTrack

NordicTrack NETL81810.0 Bedienungsanleitung

Schwinn

Schwinn 830/Journey 8.0 Bedienungsanleitung

Spirit

Spirit XT8 Bedienungsanleitung

NordicTrack

NordicTrack T 14.0 Treadmill Bedienungsanleitung

Master

Master F22 Bedienungsanleitung

Precor

Precor PRECISION SERIES Technisches Handbuch