Kohler Sterling 20243 Montageanleitung

Installation and Care Guide

Apron-Front Kitchen Sink

Français, page “Français-1”

Español, página“ Español-1”

20243

1307771-2-A

Tools and Materials

Important Information

IMPORTANT! Refer to the ″Roughing-In″section for cabinet

dimensional requirements.

IMPORTANT! This sink must be installed prior to the installation

of the countertop. Cut-line is based from the front face of the

cabinet.

IMPORTANT! Long screws may damage adjacent cabinets. Ensure

the screws are long enough to secure the support framing, but short

enough not to extend through the walls of adjacent cabinets.

Due to the nature of under-mount installations, Kohler Co.

recommends that under-mount sink installations be performed by

trained and experienced installers.

This sink is intended for installation into a standard framed 36″

base cabinet.

Anchors and fasteners to be provided and installed by the

countertop manufacturer.

Observe all local plumbing and building codes.

Plus:

• 2x4s

• Screws

100% Silicone

Sealant

Construction

Adhesive

1307771-2-A 2 Sterling

Roughing-In

17-7/16"

(443 mm)

Apron

1-5/8"

(41 mm)

Front of Cabinet

False Drawer Front

Drawer Opening

B = Top of Cabinet to Top

of Doors

Top of Cabinet to Bottom

of Drawer Opening

A =

Ensure clearance

for faucet installation.

6-11/16"

(170 mm)

Before installing this sink, verify the opening height (A) is

less than the apron height and the distance to the top of

the doors (B) is greater than the apron height.

IMPORTANT!

1-5/8"

(41 mm)

Sterling 3 1307771-2-A

1. Prepare the Cabinet

Remove the false drawer front from your cabinet. Use care not to

damage the cabinet.

Carefully cut away the top rail and center support.

Center

Support

Rail

False Drawer

Front

1307771-2-A 4 Sterling

2. Install Support Framing

NOTICE: For proper countertop installation, the top of the sink

must not extend above the top of the cabinet.

Using 2x4s, construct support framing to extend along the inside

walls on each side of the base cabinet.

Measure and mark the support mounting locations; ensure the

sink rim will sit at or slightly below the top of the cabinet.

Position and level the support framing.

Secure the support framing with construction adhesive and

screws (not provided).

Cut four lengths of support framing from 2x4s to extend from the

bottom of the installed supports to the ﬂoor of the cabinet.

Secure the vertical supports with construction adhesive and

screws (not provided).

Support

Framing

Sterling 5 1307771-2-A

3. Install the Sink

Lower the sink into the cabinet. Verify the sink is supported by

the frame.

Verify the sink is level, make any adjustments, and shim as

needed.

Remove the sink.

Apply a bead of silicone sealant to the top of each support.

Lower the sink onto the supports and push in to ensure the apron

is ﬂush to the front of the cabinet.

1307771-2-A 6 Sterling

4. Install the Countertop

Apply a bead of silicone sealant around the sides and back of the

sink.

Install the countertop.

Sterling 7 1307771-2-A

5. Secure the Sink

NOTE: Anchors are pre-installed by the countertop manufacturer.

Install the clips to the countertop. Ensure each clip engages the

rim of the sink. Tighten the clips evenly.

1-5/8"

(41 mm)

1307771-2-A 8 Sterling

6. Seal the Countertop and Cabinet

Apply a thin bead of silicone sealant where the sink meets the

countertop and cabinet.

Immediately wipe away any excess sealant.

Care and Cleaning Instructions

For best results, keep the following in mind when caring for your

STERLING product:

Clean stainless steel at least once a week.

Always apply stainless steel cleaner/polish with a non-abrasive

cloth or sponge, working with, not across, the grain.

Do not use steel wool, wire brushes or abrasive sponge pads.

Cleaners containing chloride are not recommended. If used, rinse

the surface immediately to prevent corrosion.

For detailed cleaning information and products to consider, visit

www.sterlingplumbing.com/care-and-cleaning. To order Care &

Sterling 9 1307771-2-A

Care and Cleaning Instructions (cont.)

Cleaning information, call 1-800-456-4537.

Warranty

Stainless Steel Sinks deeper than 6″- LIFETIME LIMITED

Stainless Steel Sinks less than or equal to 6″deep - 5 YEARS

LIMITED

Based on the classiﬁcation speciﬁed above, STERLING stainless steel

sinks deeper than 6” are warranted to be free of manufacturing defects

for as long as the original consumer purchaser owns his/her home;

STERLING stainless steel sinks less than or equal to 6” in depth are

warranted to be free of manufacturing defects for 5 years from the date

of sale.

Kohler Co. will, at its election, repair, rectify or replace a ﬁxture when

inspection by Kohler Co. discloses any such defects occurring in

normal usage within the time period of coverage stated above. Kohler

Co. is not responsible for removal or installation costs where

replacement is indicated. Damages due to improper handling,

installation or maintenance are not considered manufacturing defects

and are not covered by this warranty. This warranty is valid for the

original, consumer purchaser only.

To obtain warranty service, contact Sterling, either through your

plumbing contractor, home center, wholesaler or dealer, or by calling or

writing Sterling, Consumer Services, 444 Highland Drive, Kohler,

Wisconsin 53044, 1-800-783-7546.

TO THE EXTENT PERMITTED BY LAW, ALL IMPLIED

WARRANTIES INCLUDING THOSE OF MERCHANTABILITY

AND FITNESS FOR A PARTICULAR PURPOSE ARE HEREBY

DISCLAIMED. KOHLER CO. AND SELLER HEREBY DISCLAIM

ANY LIABILITY FOR SPECIAL, INCIDENTAL, OR

CONSEQUENTIAL DAMAGES. Some states/provinces do not allow

limitations on how long an implied warranty lasts, or the exclusion or

limitation of special, incidental or consequential damages, so these

limitations and exclusions may not apply to you. This warranty gives

you speciﬁc legal rights. You may have other rights which vary from

state/province to state/province.

This is the exclusive written warranty for Kohler Co.

1307771-2-A 10 Sterling

Inhaltsverzeichnis

Sprachen:

Andere Kohler Sanitärprodukte Handbücher

Kohler

Kohler K-9436 Bedienungsanleitung

Kohler

Kohler K-8593 Montageanleitung

Kohler

Kohler K-7128 Montageanleitung

Kohler

Kohler Tableau K-14293 Bedienungsanleitung

Kohler

Kohler Family Care 2.0 K-701646T-FM-SHP Bedienungsanleitung

Kohler

Kohler Portrait K-2272 Bedienungsanleitung

Kohler

Kohler R22898-SD-BL Bedienungsanleitung

Kohler

Kohler K-7166-AF Montageanleitung

Kohler

Kohler Sunstruck K-24008-GH Bedienungsanleitung

Kohler

Kohler K-10094 Montageanleitung

Kohler

Kohler 30440 Bedienungsanleitung

Kohler

Kohler K-10121 Bedienungsanleitung

Kohler

Kohler FAMILY CARE Bedienungsanleitung

Kohler

Kohler K-3323X Montageanleitung

Kohler

Kohler K-7401 Montageanleitung

Kohler

Kohler BRIVE+ K-8703IN-1WH Bedienungsanleitung

Kohler

Kohler Mira Event XS Bedienungsanleitung

Kohler

Kohler K-16213 Bedienungsanleitung

Kohler

Kohler K-8998 Montageanleitung

Kohler

Kohler K-9018 Montageanleitung

Kohler

Kohler WaterTile K-8030 Bedienungsanleitung

Kohler

Kohler K-168 Bedienungsanleitung

Kohler

Kohler K-R77748 Montageanleitung

Kohler

Kohler CLICKER DRAIN 7119A Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema

Crosswater

Crosswater Heir 18-31 Bedienungsanleitung

Sanela

Sanela SLVN 07 Bedienungsanleitung

Glacier bay

Glacier bay DORIND HD67478W-6001 Montageanleitung

Sterling Plumbing

Sterling Plumbing C741 Bedienungsanleitung