KVH Industries TracVision 4 Bedienungsanleitung

Satellite Television

KVHTracVision

technical

manual

•Installation

•Configuration

•Maintenance

A Guide to TracVision 4

TracVision 4 Installation and Technical Manual – ADDENDUM

54-0150 Addendum to Rev. E

TracVision 4 Technical

Manual Addendum

(ECO #5416)

The following information applies to Revision E of the

TracVision 4 Installation and Technical Manual (KVH Part

Number 54-0150).

Appendix E

Predefined Satellite

Configurations

Some minor corrections have been made to the table of predefined

satellite configurations for European satellites (corrections are noted in

bold type). The North American satellite data remains unchanged.

As noted previously, your TracVision 4 comes programmed with

the satellite configurations for seven European and seven North

American satellite services. For your reference, those

configurations are listed below. These configurations are current

as of July 1, 2001, and are subject to change by the satellite

service providers.

European Satellites

Satellite F,S,C,ID,P,B,D

Astra 1 11778,27500,34,0x0020,V,H,3

11742,27500,34,0x0020,V,L,3

12344,27500,34,0x0035,H,H,3

11876,27500,34,0x0020,H,L,3

Astra 2N 11778,27500,23,0x0020,V,H,3

00000,27500,34,0x0000,V,L,3

11914,27500,23,0x0020,H,H,3

00000,27500,34,0x0000,H,L,3

Astra 2S 11817,27500,23,0x0020,V,H,3

00000,27500,34,0x0000,V,L,3

11798,27500,23,0x0020,H,H,3

00000,27500,34,0x0000,H,L,3

Hispasat 12152,27500,34,0x0031,V,H,3

11660,27500,34,0x0031,V,L,3

12154,27500,34,0x0031,H,H,3

11522,27500,34,0x0031,H,L,3

Hotbird 12073,27500,34,0x013E,V,H,3

11958,27500,34,0x013E,V,L,3

11862,27500,34,0x013E,H,H,3

11862,27500,34,0x013E,H,L,3

Sirius 12130,27500,34,0x03E8,V,H,3

00000,27500,34,0x0000,V,L,3

12108,27500,34,0x0001,H,H,3

00000,27500,34,0x0000,H,L,3

Thor 12226,28000,78,0x0046,V,H,3

11309,24500,78,0x0046,V,L,3

12322,27800,34,0x0046,H,H,3

11229,24500,78,0x0046,H,L,3

Configuration Definitions

F = Frequency

S = Transponder symbol rate

C = FEC code

ID = Satellite network ID

P = LNB polarization (vertical or

horizontal)

B = LNB band (high, low, or USA)

D = Decoding type (3 = DVB)

54-0150 Rev. E

TracVision 4 Installation and

Technical Manual

This manual provides detailed instructions on the proper

installation, use, and maintenance of the KVH TracVision 4

automatic satellite tracking system.

Throughout this manual, important information is marked for

your attention by these icons:

Direct uestions, comments, or suggestions to:

KVH Industries, Inc. KVH Europe A/S

50 Enterprise Center Ved Klaedebo 12

Middletown, RI 02842 USA 2970 Hoersholm Denmark

tel: +1 401 847-3327 tel: +45 45 16 01 80

fax: +1 401 849-0045 fax: +45 45 86 70 77

e-mail: [email protected] e-mail: [email protected]

Internet: www.kvh.com Internet: www.kvh.com

A helpful tip that either directs you to

a related area within the manual or

offers suggestions on getting the

highest quality out of your system.

An alert to important information

regarding procedures, product

specifications, or product use.

An electrical safety warning to help

identify electrical issues that can be a

hazard to either this KVH product or

a user.

Information about installation,

maintenance, troubleshooting, or

other mechanical issues.

KVH Part # 54-0150 Rev. E

TracVision 4 Serial Number

This serial number will be required

for all troubleshooting or service

calls made regarding this product.

TracVision®and KVH®are registered trademarks

of KVH Industries, Inc.

DIRECTV®is an official trademark of DIRECTV, Inc.,

a unit of GM Hughes Electronics.

DISH Network™is an official trademark of

EchoStar Communications Corporation.

ExpressVu is a property of Bell ExpressVu, a wholly owned

subsidiary of Bell Satellite Services.

54-0150 Rev. E

Table of Contents

1 TracVision 4 System Overview . . . . . . . . . . . . . . . . . . .1-1

1.1 Materials Provided With TracVision 4 System . . . . . . . . . . . . . .1-1

2 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-1

2.1 Choosing the Best Location and Getting

the Best Reception . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-2

2.2 Installing the Antenna Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-2

2.2.1 Setting the Skew Angle (European Systems Only) . . . . . . .2-6

2.3 Wiring the TracVision 4 System . . . . . . . . . . . . . . . . . . . . . . . . .2-6

2.3.1 Wiring the Antenna Unit Data Cable . . . . . . . . . . . . . . . . . .2-8

2.3.2 Wiring the Antenna Unit Power Cable . . . . . . . . . . . . . . . . .2-8

2.3.3 Connecting to Ship’s Power . . . . . . . . . . . . . . . . . . . . . . . .2-9

2.3.4 IRD Ground Cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-9

2.3.5 Installing the Switchplate . . . . . . . . . . . . . . . . . . . . . . . . .2-10

2.3.6 Connecting an Antenna RF Signal Cable to the IRD . . . . .2-10

2.3.6.1 Connecting the Antenna RF Signal Cables

to a Multiswitch (North American

Systems Only) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-11

2.4 Commissioning the IRD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-13

2.5 Selecting the Active Satellite . . . . . . . . . . . . . . . . . . . . . . . . . .2-14

2.5.1 Installing Your Selected Satellites . . . . . . . . . . . . . . . . . . .2-15

2.5.2 Programming User-defined Satellites . . . . . . . . . . . . . . . .2-16

2.6 Checking Out the System . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-20

3 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-1

3.1 Causes and Remedies for Common Operational Issues . . . . . .3-1

3.1.1 Blown Fuse, Low Power, or Wiring . . . . . . . . . . . . . . . . . . .3-2

3.1.2 Vessel Turning During Startup . . . . . . . . . . . . . . . . . . . . . . .3-2

3.1.3 Incorrect Satellite Configuration

(European Systems Only) . . . . . . . . . . . . . . . . . . . . . . . . . .3-2

3.1.4 Satellite Signal Blocked . . . . . . . . . . . . . . . . . . . . . . . . . . .3-3

3.1.5 Outside Satellite Coverage Zone . . . . . . . . . . . . . . . . . . . .3-3

3.1.6 Radar Interference . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-3

3.1.7 Incorrect or Loose RF Connectors . . . . . . . . . . . . . . . . . . .3-3

3.1.8 Multiswitch Interference (DSS Plus™ IRD Users Only) . . . .3-3

3.1.9 Passive Multiswitch Used (North American

Systems Only) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4

3.2 IRD Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4

3.3 Antenna Gyro and LNB Faults . . . . . . . . . . . . . . . . . . . . . . . . . .3-4

3.4 Computer Diagnostics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4

3.5 Maintenance Port Parser Commands . . . . . . . . . . . . . . . . . . . . .3-5

4 Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1

4.1 Warranty/Service Information . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1

4.2 Preventive Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1

4.3 TracVision 4 Field Replaceable Units . . . . . . . . . . . . . . . . . . . . .4-2

4.4 PCB Removal and Replacement . . . . . . . . . . . . . . . . . . . . . . . . .4-4

4.4.1 CPU Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-5

4.4.2 RF Detector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-5

4.5 Antenna Gyro Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-7

4.6 Elevation Motor and Belt Replacement . . . . . . . . . . . . . . . . . . .4-9

4.6.1 Drive Belt Removal and Replacement . . . . . . . . . . . . . . . . .4-9

4.6.2 Elevation Drive Motor Removal and Replacement . . . . . . .4-10

4.7 Antenna LNB Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-11

4.7.1 European LNB Replacement . . . . . . . . . . . . . . . . . . . . . .4-11

4.7.2 U.S.-style LNB Replacement . . . . . . . . . . . . . . . . . . . . . . .4-11

4.8 Preparation for Shipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-12

Appendix A System Specifications . . . . . . . . . . . . . . . . . .A-1

A.1 Antenna Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .A-1

Appendix B TracVision 4 Baseplate Mounting

Holes Template . . . . . . . . . . . . . . . . . . . . . . .B-1

Appendix C Switchplate Template . . . . . . . . . . . . . . . . . .C-1

Appendix D Comprehensive TracVision 4

System Wiring Diagram . . . . . . . . . . . . . . . . .D-1

Appendix E Predefined Satellite Configurations . . . . . . . . .E-1

Appendix F Startup Data Sequences . . . . . . . . . . . . . . . . .F-1

Appendix G Maintenance Port Parser Commands . . . . . . . .G-1

G.1 System Commands . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .G-1

G.2 Manual Positioning Commands . . . . . . . . . . . . . . . . . . . . . . . . .G-2

G.3 Operational Commands . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .G-3

G.4 Tracking and Conical Scan Commands . . . . . . . . . . . . . . . . . . .G-4

G.5 RF Board Commands . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .G-5

G.6 Installation Commands . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .G-7

G.7 Debug Commands . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .G-8

List of Figures

Figure 1-1 TracVision 4 System Configuration . . . . . . . . . . . . . . . . . .1-1

Figure 2-1 Antenna Unit Dimensions . . . . . . . . . . . . . . . . . . . . . . . . .2-4

Figure 2-2 Baseplate/Foam Seal Orientation (Bottom View) . . . . . . . .2-4

Figure 2-3 Baseplate Connector Assignments . . . . . . . . . . . . . . . . . .2-5

Figure 2-4 Bolting the Antenna Unit to the Deck (Side View) . . . . . . .2-5

Figure 2-5 Adjusting the European LNB Skew Angle . . . . . . . . . . . . .2-6

Figure 2-6 Skew Angle Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-6

Figure 2-7 Switchplate Panel Cutout Dimensions . . . . . . . . . . . . . . . .2-7

Figure 2-8 Correctly Securing Wires within the

Switchplate Connectors . . . . . . . . . . . . . . . . . . . . . . . . . .2-7

Figure 2-9 Data Cable Wiring Arrangement . . . . . . . . . . . . . . . . . . . .2-8

Figure 2-10 Wiring the Antenna Unit Power Cable

and Indicator Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-9

Figure 2-11 Wiring the Switchplate to Ship’s Power . . . . . . . . . . . . . . .2-9

Figure 2-12 Mounting the Switchplate Support Frame

and Front Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-10

iii

54-0150 Rev. E

Figure 2-13 Single Multiswitch Installation (North

American Systems Only) . . . . . . . . . . . . . . . . . . . . . . . .2-12

Figure 2-14 Multiple Multiswitch Installation (North

American Systems Only) . . . . . . . . . . . . . . . . . . . . . . . .2-12

Figure 3-1 Troubleshooting Matrix . . . . . . . . . . . . . . . . . . . . . . . . . . .3-1

Figure 3-2 DB9 Connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-5

Figure 4-1 TracVision 4 Antenna Unit (Baseplate Cut Away) . . . . . . .4-3

Figure 4-2 PCB Cover Plate Removal . . . . . . . . . . . . . . . . . . . . . . . .4-4

Figure 4-3 PCB Connector Locations (Rear View) . . . . . . . . . . . . . . .4-4

Figure 4-4 PCB Mounting (Top View) . . . . . . . . . . . . . . . . . . . . . . . . .4-5

Figure 4-5 Data and RF Flash Cables . . . . . . . . . . . . . . . . . . . . . . . .4-5

Figure 4-6 RF Cable Ferrules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-6

Figure 4-7 New RF Board Installation . . . . . . . . . . . . . . . . . . . . . . . .4-6

Figure 4-8 Elevation Drive Mechanism . . . . . . . . . . . . . . . . . . . . . . .4-9

Figure 4-9 European LNB Removal . . . . . . . . . . . . . . . . . . . . . . . . .4-11

Figure 4-10 U.S.-style LNB Removal . . . . . . . . . . . . . . . . . . . . . . . . .4-11

Figure 4-11 Shipping Restraint Placement . . . . . . . . . . . . . . . . . . . . .4-12

List of Tables

Table 1-1 TracVision 4 Packing List . . . . . . . . . . . . . . . . . . . . . . . .1-1

Table 2-1 Installation Process . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-1

Table 2-2 Lengths of Provided Below-decks Cables . . . . . . . . . . .2-2

Table 2-3 Antenna Unit Kitpack Contents . . . . . . . . . . . . . . . . . . .2-3

Table 2-4 Key IRD Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-13

Table 2-5 Available Satellite Pairs – Europe

(European LNB required) . . . . . . . . . . . . . . . . . . . . . .2-14

Table 2-6 Available Satellite Pairs – North America

(U.S.-style LNB required) . . . . . . . . . . . . . . . . . . . . . . .2-14

Table 2-7 SATCONFIG Parser Command . . . . . . . . . . . . . . . . . .2-17

Table 2-8 Satellite Transponder Data Sequence . . . . . . . . . . . . .2-18

Table 2-9 Satellite Transponder Default Data . . . . . . . . . . . . . . . .2-18

Table 2-10 Sample Satellite Configuration Data . . . . . . . . . . . . . .2-19

Table 4-1 TracVision 4 Field Replaceable Units . . . . . . . . . . . . . . .4-2

Table A-1 TracVision 4 Antenna Physical Specifications . . . . . . . .A-1

Table A-2 TracVision 4 Power Specifications . . . . . . . . . . . . . . . . .A-1

Table A-3 TracVision 4 Performance Specifications . . . . . . . . . . . .A-1

Table G-1 System Commands . . . . . . . . . . . . . . . . . . . . . . . . . . .G-1

Table G-2 Manual Positioning Commands . . . . . . . . . . . . . . . . . . .G-2

Table G-3 Operational Commands . . . . . . . . . . . . . . . . . . . . . . . .G-3

Table G-4 Tracking and Conical Scan Commands . . . . . . . . . . . . .G-4

Table G-5 RF Board Commands . . . . . . . . . . . . . . . . . . . . . . . . . .G-5

Table G-6 Installation Commands . . . . . . . . . . . . . . . . . . . . . . . . .G-7

Table G-7 Debug Commands . . . . . . . . . . . . . . . . . . . . . . . . . . . .G-8

54-0150 Rev. E

Andere Handbücher für TracVision 4

Inhaltsverzeichnis

Andere KVH Industries Satellitenfernsehsystem Handbücher

KVH Industries

KVH Industries Vision C3 Bedienungsanleitung

KVH Industries

KVH Industries TracVision M3 Bedienungsanleitung

KVH Industries

KVH Industries TracVision M3 Bedienungsanleitung

KVH Industries

KVH Industries LF Bedienungsanleitung

KVH Industries

KVH Industries TracVision R4 Bedienungsanleitung

KVH Industries

KVH Industries TracVision TV1 Bedienungsanleitung

KVH Industries

KVH Industries TracVision HD7 Bedienungsanleitung

KVH Industries

KVH Industries TracVision R5SL Leitfaden

KVH Industries

KVH Industries TracVision HD11 Bedienungsanleitung

KVH Industries

KVH Industries TracVision 4 Bedienungsanleitung

KVH Industries

KVH Industries TracVision L3 Bedienungsanleitung

KVH Industries

KVH Industries TracVision 4 Bedienungsanleitung

KVH Industries

KVH Industries TracVision M7 Bedienungsanleitung

KVH Industries

KVH Industries antenna system Bedienungsanleitung

KVH Industries

KVH Industries TracVision M9 Leitfaden

KVH Industries

KVH Industries TracVision R5SL Bedienungsanleitung

KVH Industries

KVH Industries TracVision G4 Bedienungsanleitung

KVH Industries

KVH Industries TracVision M5 Bedienungsanleitung

KVH Industries

KVH Industries TracVision M5 Bedienungsanleitung

KVH Industries

KVH Industries TracVision R1ST Bedienungsanleitung

KVH Industries

KVH Industries TracVision C3 Bedienungsanleitung

KVH Industries

KVH Industries KVHTRACVISION G4 Bedienungsanleitung

KVH Industries

KVH Industries TracVision S2 Bedienungsanleitung

KVH Industries

KVH Industries TRACVISION SA Bedienungsanleitung

Beliebte Satellitenfernsehsystem Handbücher anderer Marken

Dish TV

Dish TV DVB-S6800PLUS Bedienungsanleitung

Avermedia

Avermedia AVer3D R889 Bedienungsanleitung

Kathrein

Kathrein MobiSet 2 Digital CAP 600 Bedienungsanleitung

Philips

Philips DSX 5250 Bedienungsanleitung

Winegard

Winegard RMFLDM4 Bedienungsanleitung

DefineSat

DefineSat VM55 Bedienungsanleitung

Dish Network

Dish Network 112182 Bedienungsanleitung

Thrane&Thrane

Thrane&Thrane sailor 60 Technisches Handbuch

JRC

JRC NJT8304 Series Bedienungsanleitung

Bell

Bell EXPRESSVU Bedienungsanleitung

Promax

Promax SATHUNTER Bedienungsanleitung

SatKing

SatKing PRO MAX Bedienungsanleitung

Dish Network

Dish Network Satellite Television Bedienungsanleitung

Uniden

Uniden SQ530 Bedienungsanleitung

VuQube

VuQube V20 Bedienungsanleitung

VIARK

VIARK SAT 4K Bedienungsanleitung

KING

KING Tailgater VQ4500 Bedienungsanleitung

Apollo Entertainment

Apollo Entertainment KiwiSat Leitfaden