MacDon R113 Bedienungsanleitung

R113/R116 Self-Propelled Disc Mower Quick Card MD #214620 Rev. A

Supplement to R113/R116 SP Disc Mower Operator’s Manual

R113/R116 SP Quick Card Subject to change without notice.

Use this card as a guide only. Refer to your Operator’s Manual

for detailed settings and adjustment procedures.

Light / Thin Crop

Light or Heavy / Tough Crop

Disc Speed

Rear Baffle Deflector Fins

Controls material distribution across windrow. Narrower windrow.

1. Remove fins from storage position (on top of baffle).

2. Position deflector fin (A) under baffle.

3. Secure with existing bolt and nut (B) (bolt head facing down).

4. Adjust to approximately 60 degree angle (as shown).

5. Torque nut to 69 Nm (51 lbf-ft). Repeat on other side.

Rear Baffle Plate

Controls windrow height. Directs crop flow that affects width.

1. Remove lynch pin (A).

2. Pull adjustment lever (B) inboard to disengage from bracket (C).

3. Move lever forward—raise baffle—narrow swath.

4. Move lever backward—lower baffle—wide swath.

5. Release lever so tab engages the notch in bracket (C).

6. Secure lever with lynch pin (A).

Controls windrow width and placement.

1. Loosen locking handle (A).

2. Slide adjuster bar (B) along adjuster

plate (C) to desired position.

3. Engage bar (B) into a notch in the

adjuster plate.

4. Tighten locking handle (A).

5. Repeat for other side to the same

position.

6. Adjust rear baffle as required.

Wide swath (A)

Deflectors are angled

outboard.

Narrow swath (B)

Deflectors are angled

inboard.

Side Deflectors—Roll Conditioner

Smooth / level / firm ground: 16 km/h (10 mph)

and higher, or until cutting and conditioning quality

are compromised.

Rocks / ridges / loose ground: Slow to minimize

bouncing, uneven stubble, and damage to the

cutterbar.

(A) acres/hr (B) hectares/hr (C) km/h (D) mph (E) R116 (F) R113

Ground Speed

Windrow

R113/R116 Self-Propelled Disc Mower Quick Card MD #214620 Rev. A

Supplement to R113/R116 SP Disc Mower Operator’s Manual

R113/R116 SP Quick Card Subject to change without notice.

Use this card as a guide only. Refer to your Operator’s Manual

for detailed settings and adjustment procedures.

Shallow Angle Steep Angle

Rocks / ridges / loose ground:

Shallow angle High stubble / rocks / cane:

Lower position

Short stubble / smooth ground:

Upper position

Skid Shoes

Upper Position Lower Position

Cutting Height

Roll Gap

Increase conditioning:

1. Loosen jam nut (A).

2. Turn lower nut (B) counterclockwise to decrease roll gap (C).

3. Tighten jam nut (A).

Decrease conditioning:

1. Loosen jam nut (A).

2. Turn lower nut (B) clockwise to increase roll gap (C).

3. Tighten jam nut (A).

Roll Tension

Light crops—less tension:

1. Loosen jam nut (A).

2. Turn bolt (B) counterclockwise to increase exposed thread (C).

3. Tighten jam nut (A).

Heavy / tough crops—more tension:

1. Loosen jam nut (A).

2. Turn bolt (B) clockwise to decrease exposed thread (C).

3. Tighten jam nut (A).

Conditioning

Smooth / level / firm ground:

Steep angle

Header Angle

M1170

1. Turn scroll knob (A) to highlight left float (B) or right float (C).

2. Press knob (A) to activate selection.

3. Rotate scroll knob to adjust float setting.

4. Press scroll knob when finished.

M155 / M155E4

1. Coarse adjust float with drawbolt (A):

• clockwise to increase float (makes header lighter).

• counterclockwise to decrease float (makes header heavier).

2. Fine adjust left float with switch (B) or right float with switch (C):

• Setting displays at (D).

• Press + to increase or — to decrease float.

Float

NOTE: Check float after significantly changing header angle.

NOTE: Adjust float in small increments.

Andere Handbücher für R113

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere MacDon Landwirtschaftliche Geräte Handbücher

MacDon

MacDon FlexDraper FD1 Series Bedienungsanleitung

MacDon

MacDon R216 Bedienungsanleitung

MacDon

MacDon HC10 Leitfaden

MacDon

MacDon M155 Bedienungsanleitung

MacDon

MacDon M1170NT5 Bedienungsanleitung

MacDon

MacDon Swath Compressor Leitfaden

MacDon

MacDon D1XL Series Bedienungsanleitung

MacDon

MacDon FlexDraper FD2 Series Bedienungsanleitung

MacDon

MacDon NEW HOLLAND D2 Series Bedienungsanleitung

MacDon

MacDon A40-D Bedienungsanleitung

MacDon

MacDon R85 Bedienungsanleitung

MacDon

MacDon FlexDraper FD1 Series Bedienungsanleitung

MacDon

MacDon R113 SP Bedienungsanleitung

MacDon

MacDon A30-D Bedienungsanleitung

MacDon

MacDon FD75 Bedienungsanleitung

MacDon

MacDon A30-D Bedienungsanleitung

MacDon

MacDon M1 Series Bedienungsanleitung

MacDon

MacDon 625 Bedienungsanleitung

MacDon

MacDon R113 Bedienungsanleitung

MacDon

MacDon M155 Bedienungsanleitung

MacDon

MacDon 3020 Bedienungsanleitung

MacDon

MacDon A30-S Bedienungsanleitung

MacDon

MacDon 9200 Bedienungsanleitung

MacDon

MacDon C Series Bedienungsanleitung

Beliebte Landwirtschaftliche Geräte Handbücher anderer Marken

GSi

GSi PNEG-2314 Bedienungsanleitung

Checchi & Magli

Checchi & Magli TEXDRIVE Bedienungsanleitung

Amazone

Amazone Cenius 4003-2TX Bedienungsanleitung

MASSEY FERGUSON

MASSEY FERGUSON MF 9313S Bedienungsanleitung

Cima

Cima BLITZ Bedienungs- und Wartungsanleitung

Amazone

Amazone CombiDisc 3000 Montageanleitung

HE-VA

HE-VA Disc-Roller XL Contour Bedienungsanleitung

AGT

AGT AGT-SSFM Bedienungsanleitung

Milestone

Milestone 72-84 Bedienungsanleitung

KUHN

KUHN Hector 3000 Bedienungsanleitung

Krone

Krone X-Disc 6200 Bedienungsanleitung

Eliet

Eliet DZC450 Bedienungsanleitung

Taarup

Taarup BIO+ B4000 Bedienungsanleitung

Garland

Garland SHAKER 310 DPG Bedienungsanleitung

stable comfort

stable comfort StableWall System Bedienungsanleitung

Raven

Raven AccuBoom Bedienungsanleitung

International

International 710 Bedienungsanleitung

Ashland

Ashland HDW-3217-14 Bedienungsanleitung