Medline HCS7000 Bedienungsanleitung

VAC-ASSIST

SUCTION UNIT

HCS7000

CAUTION:

Rx only.

NOTE:

Check ALL parts for shipping damage. If shipping damage is noted, DO NOT use.

Contact medical equipment provider for further instruction.

Index

1. Safety Information........................................................................................................3

2. AC Power Source...........................................................................................................4

3. Electrical..........................................................................................................................4

4. Introduction ...................................................................................................................5

5. Illustration of Important Parts....................................................................................5

6. Set-Up..............................................................................................................................6

7. How to operate your VAC-ASSIST Suction Unit......................................................6

8. Cleaning Instructions....................................................................................................9

9. Maintenance...................................................................................................................9

10. Troubleshooting...........................................................................................................10

11. Disposables and parts for reorder............................................................................11

12. Speciﬁcations/Classiﬁcations...................................................................................12

13. Warranty.......................................................................................................................12

1. Safety information

When using electrical products, especially when children are present, basic safety

precautions should always be followed. Read all instructions before using.

Important information is highlighted by these term

Danger

Urgent safety information for hazards that will cause serious injury or death.

Warning

Important safety information for hazards that might cause serious injury.

Caution

Information for preventing damage to the product.

Note

Information to which you should pay special attention.

Read all user’s manual before using.

Danger

To reduce the risk of electrocution:

1. Do not use while bathing.

2. Do not place or store product where it can fall or be pulled into a tub or sink.

3. Do not place in or drop into water or other liquid.

4. Do not reach for a product that has fallen into water. Unplug immediately.

Warning

To reduce the risk of burns, electrocution, ﬁre or injury to persons:

1. Close supervision is necessary when this product is used by, on, or near children

or invalids.

2. Use this product only for its intended use as described in this guide.

3. Never operate this product if:

a. It has a damaged power cord or plug.

b. It is not working properly.

c. It has been dropped or damaged.

d. It has been dropped into water.

4. Return the product to an authorized VAC-ASSIST medical equipment service

center for examination and repair.

5. Keep the power cord away from heated surfaces.

6. Never use while drowsy or asleep.

Speciﬁc warnings

TO REDUCE THE RISK OF ELECTRICAL SHOCK OR INJURY TO PERSONS, DO NOT

DISASSEMBLE THIS UNIT. Disassembly or attempted repairs if accomplished

incorrectly can create electrical shock hazard. Only qualiﬁed technicians should

perform servicing of this suction unit.

Danger

The VAC-ASSIST Suction Unit is a vacuum suction device designed for the collection

of nonﬂammable ﬂuid materials in medical applications only. Improper use during

medical applications can cause injury or death.

For all medical applications:

1. All suctioning should be done in strict accordance with appropriate procedures

that have been established by a licensed medical authority.

2.Some attachments or accessories may not ﬁt the tubing supplied. All attachments

or accessories should be checked prior to use to assure proper ﬁt.

2. AC Power source

Caution

The Model HCS7000 is used with a power supply allowing operation on AC voltage

(115 VAC, 60 Hz). However the correct power source must be used to connect to

adaptable wall power.

3. Electrical

Compressor:

If the overload protector shuts off the motor frequently, you may have a low

voltage situation. Low voltage can also be suspected when:

1. The motor does not get up to full power or speed.

2.Other motor operated appliances fail to operate properly. Too many motor

operated appliances on same circuit.

Note

The motor of this compressor has a thermal overload protector. If the motor

overheat, the overload protector will shut off the motor. If this occurs, turn the ON/

OFF switch to the OFF position and allow the motor to cool (approximately 5

minutes). Restart compressor. If the compressor fails to start, wait an additional 5

minutes before attempting to restart. If this fails, inspect the fuses on your suction

unit. If the unit still does not restart, call your medical equipment provider

immediately.

Warning

Proper operation of this product is necessary to avoid physical harm. Improper use

can cause personal injury and/or tissue damage. This product should not be used

unless the operator has been instructed by a physician or other qualiﬁed health

care professional.

1. Familiarize yourself with this unit.

2. Place unit on table and push down hard so that suction feet hold unit ﬁrmly in

place.

3. Before plugging power cord into electrical outlet, check if the ON/OFF switch is

in the “O” OFF position.

Note

Before attempting to start a cold unit, let the unit reach room temperature in a

heated area.

4. Introduction

Your VAC-ASSIST Suction Unit is a professional medical suctioning device that

produces a maximum vacuum of 560 mmHg. The unit is equipped with an 800 ml

collection bottle and has been designed for convenient and reliable usages.

Features:

• New hydrophobic ﬁlter design helps contamination.

• High quality vacuum regulator and anti-vibration vacuum gauge setting.

• Oil-less, permanent lubrication.

• Collection bottle with overﬂow protection.

• Superior performance and high reliability for continuous operation design.

• Easy carry and easy cleaning.

Following the recommended operating and maintenance procedures outlined in

this user’s manual will maximize the life of this product. Refer to the diagrams on

page 6.

5. Illustration of Important Parts

1. Vacuum Adjust Knob

2. Vacuum Gauge

3. Hydrophobic Filter

4. Connection Tubing

5. Patient Tubing Connector

6. Patient Tubing

7. 800cc Collection Bottle

8. Holder

9. Base

10. Cord Fixed Support

11. Power Switch

12. Power Cord

13. Fuse

Figure 1

1112

6. Set-Up

1. Connect either end of the connecting tubing (item# 4) to the top of collection

bottle connector then connect the other end to the hydrophobic ﬁlter.

2.The patient tubing should be connected to collection bottle at the outlet labeled

(patient). Please assure that all connections are secure and without leaks before

using.

7. How to operate your vac-assist suction unit

1. Before use, check the speciﬁcation label on the side of the suction unit to ensure

that the voltage and current indicated on the unit correspond with the voltage

and current available. Make sure the power switch located on the side of the unit

is in the “Off” position before connecting the unit to a power source.

"Off" position

Figure 2

Figure 3

2. Switch the power switch to “I” position (on), the unit start running.

"On" position

Figure 4

3. Adjust the vacuum level from 0 to 560 mm Hg by turning the vacuum adjust

knob (clockwise to increase vacuum and counter-clockwise to decrease vacuum).

Referring to the vacuum gauge while setting the desired level of vacuum. To

accurately read the gauge, block the patient end of the hose or cap off the

collection bottle and allow the gauge to reach a stable vacuum reading.

Patient End of the Hose Cap Collection Bottle

Vacuum Gauge

Figure 6

Vacuum Adjust Knob

Figure 5

4. Place the patient tubing to the appropriate position of patient and start to suck

sputum.

5. When the sputum reaches the safe full level of collection bottle (800 cc), the

suctioning will stop sucking automatically (ﬂoat shut-off).

Figure 7

6. Switch the power switch to “O” position (off), shut off the suction motor.

7. Collection canister and sputum should be disposed of per medical waste

disposing regulations.

8. Install a new collection canister and start to run the suction unit again.

Note

1. If the unit sustains a severe drop, validity of the gauge must be checked. Inspect

if the ﬂoat shut-off is still functioning properly when the liquid in the collection

bottle reaches the safe full level.

2. Always transport unit with vacuum adjust knob rotated fully clockwise in case

unit is dropped.

Safe Full

Level

Collection Bottle

8. Cleaning instructions

Figure 8

Clean Suction Unit

1, Disconnect the suction unit from all external power sources.

2, Wipe the suction unit housing, handles, and knobs with any commercial

(bacterial-germicidal) disinfectant.

Caution

Do not submerge in water as this will result in severe damage to the vacuum pump.

Warning

The waste in collection bottle may cause respiratory infection which must be

handled according to medical waste disposing regulation. Operator must wear

gloves and medical class mask before disposing of the collection bottle, tubing and

handle the wasting unit and/or accessories.

9. Maintenance

Suction canister and tubing are disposable.

Inspect suction tubing and collection bottle for leaks, cracks, etc. before each use.

Danger

Electric shock hazard

Do not attempt to open or remove the suction cabinet. If a service is required,

return your suction to an authorized service center. Opening or tampering with the

unit will void warranty.

Hydrophobic Filter Change:

1. Hydrophobic ﬁlter should be replaced every two month. If overﬂow occurs,

Collection

Bottle Lid

Holder

Collection

Bottle

change the ﬁlter immediately.

2. Remove ﬁlter by disconnecting it from tubing connected to pressure adjusting

valve and tubing connected to collection bottle lid assembly.

3. Replace with a new VAC-ASSIST Hydrophobic ﬁlter and connect to above two

tubing. Additional ﬁlters can be purchased from an authorized dealer.

4. Hydrophobic Filter should be replaced every 2 months of use or if canister

overﬂow occurs, dispose of suction ﬁlter assembly and replace with new

assembly.

Figure 9

Note

Use only VAC-ASSIST ﬁlters. Do not substitute any other material for this

hydrophobic ﬁlter. Improper substitution may lead to contamination or poor

performance;

Fuse Change:

1. Use only the same type of fuse to replace the broken fuse.

2. Fuse speciﬁcation: Miniature Glass Fuse 5x20mm, Fast Blow (Quick Acting),

F2A/250V.

10. Troubleshooting

Your VAC-ASSIST Suction Unit contains no user-serviceable parts. If you believe

your unit is not working properly, BEFORE YOU RETURN IT TO THE MEDICAL

EQUIPMENT PROVIDER WHERE YOU PURCHASED IT OR TO VAC-ASSIST, please

take a few moments to check for these possible causes:

Pressure

Adjusting

Valve

Tubing

hydrophobic Filter

Collection Bottle Lid

Andere Handbücher für HCS7000

Inhaltsverzeichnis

Andere Medline Medizinische Geräte Handbücher

Medline

Medline HCSM70C Bedienungsanleitung

Medline

Medline HCSM70P Bedienungsanleitung

Medline

Medline MDS80500 Bedienungsanleitung

Medline

Medline MDS705154 Bedienungsanleitung

Medline

Medline GUARDIAN Bedienungsanleitung

Medline

Medline AEROMIST COMPACT HCS70004RD Bedienungsanleitung

Medline

Medline MDS400SAB Bedienungsanleitung

Medline

Medline Alterra MAXX Bedienungsanleitung

Medline

Medline HEMO-FORCE MDS600INT2 Bedienungsanleitung

Medline

Medline Compat DualFlo 9521437 Bedienungsanleitung

Medline

Medline MDS3003 Bedienungsanleitung

Medline

Medline CompliMates Bedienungsanleitung

Medline

Medline SwivAssist Bar Bedienungsanleitung

Medline

Medline Patient Lift Bedienerhandbuch

Medline

Medline FCEQRHFB Bedienungsanleitung

Medline

Medline MDS400ELB Bedienungsanleitung

Medline

Medline EntraFloH2O Betriebsanleitung

Medline

Medline MDS80600 Bedienungsanleitung

Medline

Medline HUDSON RCI Neptune ConchaSmart HUD42500 Bedienungsanleitung

Medline

Medline ALTERRA 1385 Bedienungsanleitung

Medline

Medline HCSMD400 Bedienungsanleitung

Medline

Medline HCSFSATSPORT Bedienungsanleitung

Medline

Medline HCSM70 Bedienungsanleitung

Medline

Medline EntraFlo Betriebsanleitung

Beliebte Medizinische Geräte Handbücher anderer Marken

TekTone

TekTone Tek-CARE160 Bedienungsanleitung

NeuroMetrix

NeuroMetrix Quell 2.0 Bedienungsanleitung

AMT

AMT XLR8 Bedienungsanleitung

EDAN

EDAN SONOTRAX Pro Bedienungsanleitung

Restorative Therapies

Restorative Therapies RT300 Bedienungsanleitung

Gendex

Gendex Expert DC Bedienungsanleitung

Dexcowin

Dexcowin ADX4000W Bedienungsanleitung

Libelium

Libelium MySignals Bedienungsanleitung

Acelity

Acelity V.A.C.ULTA 4 Bedienungsanleitung

Caputron

Caputron ActivaDose II tDCS Bedienungsanleitung

Plinth 2000

Plinth 2000 93CDT Bedienungsanleitung

GE SENOGRAPHE 800T Bedienungsanleitung

GE Definium 5000 Bedienungsanleitung

Kanmed

Kanmed GE-1380 Bedienungsanleitung

Huntleigh

Huntleigh FD1 Bedienungsanleitung

Stryker

Stryker SPR Plus Bedienungsanleitung

Tobii Dynavox

Tobii Dynavox I-Series Bedienungsanleitung

S-Capepod

S-Capepod Evac Cocoon Bedienungsanleitung