Nilfisk-Advance Selectspray 2700G Bedienungsanleitung

Nilfisk-Advance Select Spray 2700G Operator’s Manual 1

5/00 Form Number 56041502

SelectSpray™2700G

English

Instructions for use and parts list

Kent MODEL 56011782

2Nilfisk-Advance Select Spray 2700G Operator’s Manual

TABLE OF CONTENTS

INTRODUCTION 3

IMPORTANT SAFETY WARNINGS 4-7

FIRE & VENTILATION PRECAUTIONS 4

SPRAY PRECAUTIONS 5

DETERGENT CLEANING PRECAUTIONS 6

MISCELLANEOUS SAFETY PRECAUTIONS 6

ADJUSTMENT PRECAUTIONS 7

FEATURES DRAWING 8

SAFETY DECALS 9

INSTALLATION & PREPARATION 10-13

ATTIRE 10

SETUP 10

ENGINE FUEL TANK 10

NOZZLE REVIEW 11

NOZZLE CONNECTION 11

WATER SUPPLY 12

UNLOADER 12

HEAT DUMP VALVE 12

PRE-START INSPECTION PROCEDURES 13

OPERATING INSTRUCTIONS 14-15

PRIMING THE PUMP 14

START-UP 14

CLEANING WITH DETERGENTS 15

SHUTDOWN 15

STORAGE & MAINTENANCE 16-17

SPECIFIC MAINTENANCE 16

WINTERIZING 17

TROUBLESHOOTING 18

PARTS LISTING 20-25

STATEMENT OF WARRANTY BACK COVER

WARNING

The engine exhaust from this product

contains chemicals known to the State

of California to cause cancer, birth

defects or other reproductive harm.

Nilfisk-Advance Select Spray 2700G Operator’s Manual 3

INTRODUCTION

Congratulations on the purchase of your new Nilfisk-Advance®pressure washer! You can be assured your Nilfisk-Advance®

pressure washer was constructed with the highest level of precision and accuracy. Each component has been rigorously

tested by technicians to ensure the quality, endurance and performance of this unit.

This operator's manual was compiled for your benefit. By reading and following the simple safety, installation, operation,

maintenance and troubleshooting steps described in this manual, you will receive years of trouble free operation from your

new Nilfisk-Advance®pressure washer. The contents of this manual are based on the latest product information available at

the time of publication. Nilfisk-Advance®reserves the right to make changes in price, color, materials, equipment,

specifications or models at any time without notice.

! IMPORTANT !

THESE PARAGRAPHS ARE SURROUNDED BY A "SAFETY ALERT BOX". THIS BOX IS USED TO

DESIGNATE AND EMPHASIZE SAFETY WARNINGS THAT MUST BE FOLLOWED WHEN

OPERATING THIS PRESSURE WASHER. ACCOMPANYING THE SAFETY WARNINGS ARE

"SIGNAL WORDS" WHICH DESIGNATE THE DEGREE OR LEVEL OF HAZARD SERIOUSNESS.

THE "SIGNAL WORDS" USED IN THIS MANUAL ARE AS FOLLOWS:

DANGER

: INDICATES AN IMMINENTLY HAZARDOUS SITUATION WHICH, IF NOT

AVOIDED, WILL RESULT IN DEATH OR SERIOUS INJURY.

WARNING

: INDICATES A POTENTIALLY HAZARDOUS SITUATION WHICH, IF NOT

AVOIDED, COULD RESULT IN DEATH OR SERIOUS INJURY.

CAUTION

: INDICATES A POTENTIALLY HAZARDOUS SITUATION WHICH, IF NOT

AVOIDED MAY RESULT IN MINOR OR MODERATE INJURY.

THE SYMBOLS SET TO THE LEFT OF THIS PARAGRAPH ARE "SAFETY ALERT SYMBOLS".

THESE SYMBOLS ARE USED TO CALL ATTENTION TO ITEMS OR PROCEDURES THAT COULD

BE DANGEROUS TO YOU OR OTHER PERSONS USING THIS EQUIPMENT.

ALWAYS PROVIDE A COPY OF THIS MANUAL TO ANYONE USING THIS EQUIPMENT. READ

ALL INSTRUCTIONS BEFORE OPERATING THIS PRESSURE WASHER AND ESPECIALLY POINT

OUT THE "SAFETY WARNINGS" TO PREVENT THE POSSIBILITY OF PERSONAL INJURY TO

THE OPERATOR.

Once the unit has been uncrated, immediately write in the serial number of your unit in the space provided below.

SERIAL NUMBER_________________________________

Inspect for signs of obvious or concealed freight damage. If something appears to be damaged, file a claim with the

transportation company immediately. Be sure that all damaged parts are replaced and that the mechanical problems are

corrected prior to operation of the unit. If you require service, contact Nilfisk-Advance®Customer Service Representative at:

800-989-2235

Please have the following information available for all service calls:

1. Model Number

2. Serial Number

3. Date and Place of Purchase

4Nilfisk-Advance Select Spray 2700G Operator’s Manual

IMPORTANT SAFETY WARNINGS

FIRE & VENTILATION PRECAUTIONS:

1. This unit was designed for outdoor use only. NEVER operate this unit in an

enclosed area. ALWAYS make certain there is adequate air (oxygen) for

combustion as well as ventilation to prevent the presence of poisonous carbon

monoxide gases. Beware of poorly ventilated areas or exhaust fans which

can cause inadequate combustion or engine overheating.

2. NEVER operate this unit in the presence of flammable vapors or combustible

dust, gases or other combustible materials. (A spark may cause an explosion

or fire.) When servicing this machine, be especially careful to properly dispose

of any flammable materials. DO NOT spray flammable liquids.

3. ENGINE FUEL TANK:

a. DO NOT SMOKE WHILE FILLING ENGINE FUEL TANK

b. NEVER fill the engine fuel tank while the unit is running or hot. Allow the

engine to cool two minutes before refueling.

c. DO NOT refuel indoors or in a poorly ventilated area.

d. ALWAYS refuel slowly to avoid the possibility of spilled fuel which may

cause a risk of fire.

4. DO NOT operate the unit if gasoline is spilled. Wipe unit clean and move the

unit away from the spill. Avoid creating any ignition until the gasoline has

evaporated.

5. DO NOT store the unit near an open flame or any equipment such as a stove,

furnace, water heater, etc., which utilizes a pilot light or devices which can

create a spark.

IMPORTANT

The following is required by California State law, Section 4442 of the California

Public Resources Code. Other states may have similar laws. Federal laws

apply on federal lands.

A spark arrester must be added to the muffler of this engine if it is

to be used on any forest covered, brush covered or grass covered

unimproved land. The arrester must be maintained in effective

working order by the operator.

See your engine or equipment dealer for spark arrester muffler options.

EXPLOSION.TIF/D1PIC-CIG.TIF/D1 PIC-HOUS.TIF/D1

Nilfisk-Advance Select Spray 2700G Operator’s Manual 5

IMPORTANT SAFETY WARNINGS

SPRAY PRECAUTIONS:

DANGER

RISK OF INJECTION OR SEVERE CUTTING INJURY!

KEEP CLEAR OF NOZZLE!

DO NOT DIRECT DISCHARGE STREAM AT PERSONS OR PETS!

ONLY TRAINED OPERATORS SHOULD USE THIS PRODUCT. WHEN

OPERATING THIS UNIT, BASIC PRECAUTIONS SHOULD ALWAYS BE

OBSERVED INCLUDING THE FOLLOWING:

1. KEEP AWAY FROM THE SPRAY:

a. Because of the high pressure and velocity of the spray, fluids can

penetrate the skin, causing serious injury.

b. Never point the gun at yourself or anyone else. Never put your hand,

fingers or body directly over the spray nozzle. Always keep operating

area clear of all persons. Use extreme caution when operating near

children.

c. If an accident does occur and the spray appears to have penetrated the

skin, SEEK EMERGENCY MEDICAL CARE. DO NOT TREAT AS A

SIMPLE CUT. If you are using cleaning agents, be prepared to tell a

physician exactly what kind.

2. ALWAYS wear protective goggles when operating the unit to shield the eyes

from flying debris and detergents. Other protective equipment such as rubber

suits, gloves and respirators are advisable, especially when using cleaning

detergents. Use extreme caution when operating near children.

3. Stay alert-watch what you are doing. Do not operate the unit when fatigued

or under the influence of alcohol or drugs.

4. NEVER squeeze the trigger unless securely braced. The thrust from the

water traveling through the nozzle may be powerful enough to cause the

operator to lose balance if unprepared. DO NOT overreach or stand on

unstable support. Wet surfaces can be slippery, wear protective foot gear

and keep good footing and balance at all times. NEVER trigger the gun

while on a ladder or roof.

5. Caution should be used when directing spray toward fragile materials such

as glass. Shattering could result in serious injury.

6. ALWAYS hold on firmly to the gun/wand assembly when starting and operating

the unit. Failure to do so can cause the wand to fall and whip dangerously.

NEVER operate the gun with the trigger wired in the open position. To

prevent accidental discharge, the trigger gun should be securely locked when

not in use.

7. DO NOT direct spray on or into electrical installations of any kind! This

includes electrical outlets, light bulbs, fuse boxes, transformers, etc. Severe

electrical shock may occur.

8. Even after you shut off the unit, there is high pressure water left in the pump,

hose and gun until you release it by triggering the gun. Before removing the

spray nozzle or servicing the unit, ALWAYS shut off the unit and trigger the

gun to release trapped pressure.

PIC-OUTL.TIF/D1 PIC-GUN.TIF/D1 PIC-LADD.TIF/D1 PIC-WAND.TIF/D1

ANSIATTI.TIF/D5

6Nilfisk-Advance Select Spray 2700G Operator’s Manual

IMPORTANT SAFETY WARNINGS

DETERGENT CLEANING PRECAUTIONS:

1. DO NOT use solvents or highly corrosive detergents or acid type cleaners

with this pressure washer. Use only mild detergents.

2. KNOW YOUR DETERGENTS! Be prepared to tell a physician exactly what

you are using in the event of an emergency. Read the Material Safety Data

Sheet (MSDS) provided with your detergent and all detergent labels. Follow

all appropriate instructions regarding preparation use, safety and transportation.

Keep ALL detergents out of the reach of children.

3. DO NOT use this pressure washer to dispense hazardous detergents.

4. DO NOT alter the detergent injection feature in any manner not prescribed in

this manual. Use only genuine Nilfisk-Advance®replacement parts for

necessary repairs.

MISCELLANEOUS SAFETY PRECAUTIONS:

1. NEVER ALLOW CHILDREN OR ADOLESCENTS TO OPERATE THIS UNIT!

2. Read and follow all handling, operations, maintenance and safety instructions

listed in this manual and the Engine Operator's manual that accompanies

this unit, and provide such information to ANYONE who will be operating this

unit.

3. In freezing temperatures, the unit must always be warm enough to ensure

there is no ice formation in the pump. DO NOT start this unit if it has been

transported in an open or underheated vehicle without first allowing the pump

to thaw.

4. When connecting the water inlet to the water supply mains, local regulations

of your water company must be observed. In some areas the unit must not

be connected directly to the public drinking water supply. This is to ensure

that there is no feedback of the detergents into the water supply. (Direct

connection is permitted if a back flow preventer is installed.)

5. DO NOT allow any part of your body or the high pressure hose to make

contact with the muffler. Avoid dragging the hose over an abrasive surface

such as cement. This causes wear and eventual rupturing.

6. High pressure hoses should be inspected daily for signs of wear. If evidence

of failure exists, promptly replace all suspect hoses to prevent the possibility

of injury from the high pressure spray. If a hose or fitting is leaking , NEVER

place your hand directly on the leak.

7. DO NOT operate the unit without all protective covers in place.

8. NEVER run the unit with the governor disconnected or operate at excessive

speeds.

9. To reduce the risk of injury, maintain a safe distance for persons while operating

this unit. Close supervision is necessary when operating the unit near children.

10. DO NOT leave pressurized unit unattended. Shut off the unit and release

trapped pressure before leaving.

11. DO NOT move the unit by pulling on the hose.

PIC-BOOK.TIF/D1

PIC-HOT.TIF/D1

Nilfisk-Advance Select Spray 2700G Operator’s Manual 7

! SAVE THESE INSTRUCTIONS !

IMPORTANT SAFETY WARNINGS

ADJUSTMENT PRECAUTIONS:

1. NEVER alter or modify the equipment, be sure any accessory items and

system components being used will withstand the pressure developed.

Use ONLY genuine Nilfisk-Advance®parts for repair of your pressure washer.

Failure to do so can cause hazardous operating conditions and will void

warranty.

2. NEVER make adjustments to the machinery while it is connected to the

engine without first removing the ignition cable from spark plug. Turning

the machinery over by hand during adjustment or cleaning might start the

engine and machinery with it, causing serious injury to the operator.

3. Know how to stop the pressure washer and bleed pressures quickly. Be

thoroughly familiar with controls.

4. Before servicing the unit; turn the unit off, relieve the water pressure, and

allow the unit to cool down. Do not make repairs while unit is running.

Service in a clean, dry, flat area. Block the wheels to prevent the unit from

moving.

5. Follow the maintenance instructions specified in this manual.

8Nilfisk-Advance Select Spray 2700G Operator’s Manual

SELECT SPRAY 2700G FEATURES

PDJP005/022797/JTR

1. Decal-Warning/Caution/Operating

2. Decal-Caution: Engine Fuel

3. Decal-Warning: Muffler Hot

4. Engine

5. Pump

6. Water Inlet Strainer

7. Water Inlet

8. Water Outlet

9. Heat Dump Valve

10. Detergent Strainer

11. Detergent Hose

12. Oil Sight Glass

13. Adjustable Unloader Knob

14. High Pressure Discharge Hose

15. Gun Assembly

16. Decal-Warning: Risk of Injection

17. Quick Connect Nozzle

FEATURES LISTING

NOTE: This drawing is referenced throughout the manual.

Locations of specific items will be noted by listing the REFERENCE # in parenthesis.

Example: Engine (4)

Nilfisk-Advance Select Spray 2700G Operator’s Manual 9

Reference #1 Decal: Warning/Caution/Operating Statements (Part 56623233)

Reference #2 Decal: Caution-Engine Fuel (Part 56623222)

Reference #16 Decal: Warning-Risk of Injection (Part 56633325)

Reference #3 Decal: Warning-Muffler Hot (Part 56623220)

SAFETY DECALS & PLACEMENT FOR SELECT SPRAY 2700G.

!!!DO NOT REMOVE SAFETY DECALS FROM UNIT

UNLESS REPLACING WITH MOST CURRENT SAFETY DECAL!!!

REFER TO PAGE 8 FOR PLACEMENT

10 Nilfisk-Advance Select Spray 2700G Operator’s Manual

INSTALLATION & PREPARATION

ATTIRE:

1. Proper attire is essential to your safety. It is advised to utilize whatever

means necessary to protect eyes, ears, and skin. Additional safety attire

(such as respiratory mask) may be required when using detergent cleaning

agents with this washer.

ANSIATTI.TIF/D5

SETUP:

1. This unit should only be placed on a level surface to ensure proper lubrication

for the engine and water pump while operating.

2. Do not use unit in an area:

-with insufficient ventilation.

-where there is evidence of oil or gas leaks.

-where flammable gas vapors may be present.

3. Be certain to block the wheels to prevent the unit from moving while operating.

4. Do not allow the unit to be exposed to rain, snow or freezing temperatures. If

any part of the unit becomes frozen, excessive pressure may build up in the

unit which could cause it to burst resulting in possible serious injury to the

operator or bystanders.

5. Once properly installed, check the oil sight glass (12) on the pump crankcase.

Make certain the oil level is in the center of the sight glass before each use.

If the level appears low, use SAE 30W non-detergent pump oil. DO NOT

OVERFILL!

DANGER

RISK OF EXPLOSION OR FIRE!

DO NOT PLACE UNIT IN AN AREA

WHERE FLAMMABLE GAS

VAPORS MAY BE PRESENT. A

SPARK COULD CAUSE AN

EXPLOSION OR FIRE!

RISK OF UNIT BURSTING!

DO NOT STORE/OPERATE UNIT

IN A FREEZING ENVIRONMENT!

WARNING

RISK OF ASPHYXIATION!

DO NOT OPERATE IN AN

ENCLOSED AREA. USE THIS

PRODUCT ONLY IN WELL

VENTILATEDAREAS!

THEEXHAUSTFROMTHEENGINE

CONTAINSCARBON MONOXIDE,

A POISONOUS, ODORLESS AND

INVISIBLE GAS. BREATHING

THIS GAS CAN CAUSE SERIOUS

INJURY, ILLNESS & POSSIBLE

DEATH.

WARNING

RISK OF EXPLOSION OR FIRE!

ALWAYS STORE FUEL AWAY

FROM THE WASHER WHILE THE

UNIT IS RUNNING OR HOT.

DANGER

RISK OF FIRE!

DONOTSMOKEWHILE FUELING!

DO NOT FILL THE FUEL TANK

WHILEUNITISRUNNINGORHOT.

ALLOW UNIT & ENGINE TO COOL

FOR TWO MINUTES BEFORE

REFUELING.

DO NOT FILL FUEL TANK TO

POINT OF OVERFLOWING.

ALLOW APPROXIMATELY 1/4"

OF TANK SPACE FOR FUEL

EXPANSION.

ENGINE FUEL TANK:

1. Review "Fire & Ventilation Precautions" pg. 4, before fueling.

2. Locate the Safety Decals on your unit and heed their warnings. (1-3, 16)

3. A minimum of 86 octane fuel is recommended for use with this unit. DO NOT

MIX OIL WITH GASOLINE.

4. Purchase fuel in quantities that may be used within 30 days. Use of clean,

fresh lead free gasoline is recommended. Leaded gasoline may be used if

lead-free is unavailable. DO NOT use gasoline containing methanol or alcohol.

5. Check the engine oil level before starting the engine. (See Engine manual.)

6. Fill the fuel tank according to accompanying engine manual instructions.

7. Occasional carburetor and choke adjustments will be necessary for the engine.

Refer to the engine manual supplied with this unit for proper adjustment

procedures.

8. Review the engine manual accompanying this pressure washer for

correct engine start-up and maintenance procedures.

Inhaltsverzeichnis

Andere Nilfisk-Advance Hochdruckreiniger Handbücher

Nilfisk-Advance

Nilfisk-Advance SH SOLAR G Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance MC 2C-180 PE Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance SelectSpray 1500E 56011781 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance MH 3C Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance Core 150 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance MC 8P Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance C 110.3 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance SelectSpray 1500EH Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance SelectSpray 1250E Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance MH 1C Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance SH AUTO Series Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance MC 2C Series Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance Gerni 2302A Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance MH 3M Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance N/G-6900A/C Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance MC DE Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance Core 125 Betriebsanleitung

Nilfisk-Advance

Nilfisk-Advance P 130.2 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance VL500 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance ALPHA BOOSTER 3 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance Hybrid 7 MH42 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance NEPTUNE 4 FA Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance Nilfisk C 120.3 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance E130.3 X-TRA Betriebsanleitung

Beliebte Hochdruckreiniger Handbücher anderer Marken

Shark

Shark RG-232637 Bedienungsanleitung

Shakti Technology

Shakti Technology S3 Bedienungsanleitung

Kärcher

Kärcher K 4 Pure Bedienungsanleitung

Porter-Cable

Porter-Cable D25806-025-2 Bedienungsanleitung

REM POWER

REM POWER HDEm 662 Bedienungsanleitung

Landa

Landa HS-3000 Bedienungsanleitung

Craftsman

Craftsman 580.752270 Bedienungsanleitung

HIKOKI

HIKOKI AW 100 Bedienungsanleitung

Delco

Delco DC 1302 Bedienungsanleitung

Kärcher

Kärcher K 3 Full Control Bedienungsanleitung

BIEMMEDUE

BIEMMEDUE 120/10 - 170/13 Bedienungsanleitung

ARKSEN

ARKSEN 014-HG-14141-HR Bedienungsanleitung

Black & Decker

Black & Decker PW1700SPX Bedienungsanleitung

Kärcher

Kärcher 595 - SPARE Leitfaden

Kranzle

Kranzle B 10 200 Bedienungsanleitung

Stihl

Stihl RE 90 Bedienungsanleitung

PowR-Quip

PowR-Quip PQ-2600 Bedienungsanleitung

Hotsy

Hotsy 5645 Bedienungsanleitung