Nilfisk-Advance SDV 4500 Bedienungsanleitung

English

Components Symbols used to mark instructions.............................................4

Attachments Included Attachments.................................................................5

Accessories Included Accessories..................................................................6

Guidance Congratulations...........................................................................7

Getting the best results...............................................................7

Installation Assembly.....................................................................................8

Warnings.....................................................................................8

Operation Switching on the machine...........................................................9

Using the machine......................................................................10

During Use..................................................................................10

Maintenance Daily............................................................................................11

Weekly........................................................................................11

Precautions Do’s & Don’ts..............................................................................11

Service Guarantee...................................................................................12

Technical Technical Data............................................................................13

Troubleshooting Symptom, possible cause & action.............................................14

Modified January 2010

Contents

English

Components

1. Cold Water Tank

2. Detergent Tank

3. Steam Control

4. Collection Tank

5. Filter Panel

6. Vacuum Hose Socket

7. Steam Hose Socket

8. Castor With Brake

9. Wire Basket

10. Serial Number

11. On/Off Switch

12. Mode Switch

13. Heater On LED

14. Steam Ready LED

15. Cold Water Refill LED

16. Temperature Display LED

Dia

ram A

Dia

ram B

English

1. 7. 12.

13.

2. 8.

14.

15..

10.

16.

11.

17.

Attachments

These Parts were carefully packed at Nilfisk. Please check all accessories on receipt. If any parts are missing

or damaged please contact the company in which you purchased this machine, within 7 days of purchase

uotin

our serial number on the back of the machine.

Dia

ram C

1. 2.5 Metre Steam, Detergent & Vacuum Hose 2. Glass Washer

3. Floor Nozzle 300mm 4. Squeegee Insert for Floor Nozzle

5. Carpet Insert for Floor Nozzle 6. Brush Insert for Floor Nozzle

7. Clear Upholstery Tool 8. Extension Tubes x 2

9. Nylon Details Brush x 5 10. Brass Details Brush x 5

11. Short Steam Lance 12. Long Steam Lance

13. Suction Nozzle 150mm 14. Clip on Squeegee 150mm

15. Clip On Brush 150mm 16. Accessory Service Kit

17. Crevice Tool

Also available is Stainless Steel detail brushes (Packs of 10)

English

Accessories

These Parts were carefully packed at Nilfisk. You will find these items in your box with all the attachments. Please check all

accessories on receipt. If any parts are missing or damaged please contact the company in which you purchased this machine,

within 7 da

s of

urchase

uotin

our serial number on the back of the machine.

•Wire Basket

Dia

ram D

•Tubular Handle

•Plastic Wing Nuts x 4

•Back Wheel Assembly

•

Castor with Brake x2

English

We would like to take this opportunity to thank you for your purchase of the Nilfisk combined steam,

detergent and vacuum cleaner.

The SDV4500 is manufactured in the EU to the highest quality Standards

This instruction manual contains all of the necessary information to operate and maintain this

machine. Please read this instruction manual carefully before you start using or carrying out any

maintenance on the machine.

If you use this machine correctly as stated in this instruction manual this machine will fulfil all your

steam cleaning needs.

•This machine is intended for use in a commercial cleaning environment. If you do not follow

the instructions contained in this manual, situations may arise which may be dangerous or

harmful to the machine or the person operating the machine. Read this manual carefully so

that you know when such situations can arise.

•Ensure that all operators of this machine are fully trained on how it works.

•Report any problems or damage to the machine immediately to the supplier or a Nilfisk

approved supplier for this product. Do not operate the machine until the problem or

damage has been resolved.

Guidance

Congratulations

………………………………………………...

Getting the Best Results

………………………………………………...

•Operate the machine in accordance with

the instruction manual

•Maintain the machine in accordance with

instruction manual

•

Use only parts supplied by Nilfisk approved distributors

•Use only detergents and cleaning products in the solution

tank which have been approved by Nilfisk

Keep this manual in a safe place for future reference and ordering of spare parts

English

Installation

•

Lift the machine out of the box.

•Carefully place the machine on its side in order

to assemble the wheels securely.

!! A flat surface is required which will not

scratch or damage the surfaces of the machine.

•Diagram D – Back wheel assembly. Using a 10 mm spanner remove the bolts from the

machine and place the assembly into place towards the back of the machine. Tighten the

bolts securely ensuring no movement on the brackets.

•Diagram D – Casters with Brake x 2. Remove bolts from the machine and position into place

towards front of the machine. Tighten securely ensuring no movement on the brackets.

•Once all the wheels are fully assembled, resume the machine to its upright position.

•Place Tubular Handle (Diagram D) in position on the back of the machine and secure using

the 4 x Plastic Wing Nuts (Diagram D).

!! Do not screw them all the way in at this point.

•Place Wire Basket (Diagram D) over the Wing Nuts and tighten up to secure.

•Check all accessories are present in the box as shown in Diagram C & D.

•This is an electrical product – Do not use in wet weather or allow the machine to get wet.

•Do not discharge steam towards people, danger of scolding. Or towards equipment containing

electrical components

•Never allow children to play with this appliance.

•Do not use the machine for other purposes that it was built for.

•Please remember that the steam cleaner operates at temperatures in excess of 170°C. Never use it

on objects, which cannot resist the temperature (delicate materials, fabrics, plastics, wood etc).

Where any doubt exists check carefully on a part of the material where minor marks will not matter.

•Do not operate the machine or carry out any maintenance out on it

Unless you are trained and authorised to do so

Unless you have read and thoroughly understand this instruction manual.

Warnings

………………………………………………...

This machine has been designed with your safety in mind, however it is important that

you observe the following points for safe operation during the operating procedure

English

Operating Procedure

………………………………………………...

1. Switch mode switch (Number 12 Diagram B) to position 11.

•This will switch on the boiler elements and will enable you to use the handle controls on the

hose once connected.

2. Fill the cold water tank (Number 1 Diagram A) with clean cold water only.

!! Anything other than clean cold water used in the

water tank will void the manufacturers warranty.

3. Fill the detergent tank (Number 2 Diagram A) with Nilfisk approved detergent.

!! Unapproved detergent may be harmful or dangerous to the machine or the operator

using the machine. This may cause irrepairable damage to seals and will void the

manufacturers warranty.

4. Connect the Vacuum Hose to the front of the machine (Number 6 Diagram A) ensuring it locks

into position. To release the vacuum hose from the socket slide the red button upwards at the

same time as pulling the hose out.

!! If the Hose becomes damaged the complete hose must be replaced. Do not

attempt this task yourself, contact a Nilfisk approved supplier for replacement.

5. Connect the Steam Hose to the front of the machine (Number 7 Diagram A) ensuring it is

pushed in all the way and the pin on the flap locks into the hole on the hose.

!! Grease “O” rings on steam pin before connecting.

!! To release the steam hose, lift the flap and pull.

6. Plug the power cable into a 240 Volt supply.

!! Inspect the electric cable before every use. If the cable becomes damaged at

anytime the complete cable must be replaced by a Nilfisk approved distributor.

!! Never touch the power cable or plug with wet hands

!! Always unplug the machine when

i. The machine is not in use

ii. Cleaning the machine

iii. Any maintenance work is being carried out

8. Switch the On/Off switch (Number 11 Diagram B) to the ON position. The Heater On light LED

(Number 13 Diagram B) will illuminate.

9. Allow approximately 5 minutes for the boiler to heat the water

10. When the Steam Ready LED (Number 14 Diagram B) illuminates the machine is ready to be

used.

English

11. The handle controls are now active.

•The red trigger on the hose handle will release steam when pressed.

•The red button on the side of the handle will lock the steam trigger in the off position.

•Pressing the left hand switch on top of the handle will activate the vacuum.

•Pressing the right hand momentary switch located on the top of the handle will

activate the detergent pump. Hold the switch as long as you need to dispense the

detergent. Releasing the switch will stop the detergent supply.

12. The steam output can be adjusted by the steam control knob (Number 3 Diagram A)

13. Choose and fit the required accessory (Diagram C) to the hose handle. Lock the accessory in

place by turning the accessory locking clip.

!! When changing accessories during use please note these will be hot.

During Use

………………………………………………...

Operating Procedure cont….

………………………………………………...

Cold Water Tank Empty(Number 1 Diagram A)

1. Refill the cold water tank when the refill cold water LED (Number 15 Diagram B) is illuminated.

A buzzer will sound and the steam will no longer come out of the nozzle when the steam switch

on the handle is pressed.

2. Always empty the collection tank each time the cold-water tank is refilled.

3. The pumps will not work when the cold-water tank is empty.

4. Once the cold water refill LED is illuminated the boiler heater will remain on for 30 minutes. If the

cold-water tank is not refilled within 30 minutes and the machine is left powered on the boiler

heater will switch off.

Detergent Tank Empty (Diagram A)

1. If the detergent does not come out of the nozzle when the detergent switch on the handle is

pressed, refill the detergent tank (Diagram A)

Collection Tank Full (Number 4 Diagram A)

1. Always empty the collection tank each time the cold-water tank is refilled

2. The pitch of the motor noise changes and there is no suction at the nozzle

3. Switch off the machine, empty the collection tank and rinse clean

Andere Handbücher für SDV 4500

Inhaltsverzeichnis

Andere Nilfisk-Advance Staubsauger Handbücher

Nilfisk-Advance

Nilfisk-Advance GWD 320 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance UZ 930S Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance UZ 934 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance CV 10 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance Smart Series Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance 56315312 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance GD 930 Q Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance Coupe Neo Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance VHS110 Z22 V230 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance IVB 965-0L SD XC Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance ReliaVac 12 DC Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance VP100 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance Multi 20 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance GD 930 Leitfaden

Nilfisk-Advance

Nilfisk-Advance Coupe Neo Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance VP300 SERIES Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance ReliaVac 12 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance SMART Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance One Series Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance GD 930 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance Neo Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance ATTIX 50 M Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance Bravo Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance T22 Plus Bedienungsanleitung

Beliebte Staubsauger Handbücher anderer Marken

Bissell

Bissell LittleGreen Proheat 1425 Series Bedienungsanleitung

Panasonic

Panasonic MC-YL637S147-AE Bedienungsanleitung

LG A9 Series Bedienungsanleitung

Oreck

Oreck Cordless Captura BK51700 Series Bedienungsanleitung

Kogan

Kogan KAVACROBVWA Bedienungsanleitung

Kränzle

Kränzle VENTOS 50 ID Benutzerhandbuch

NEFF

NEFF N17XH10 0 Series Bedienungsanleitung

EVVO

EVVO Ai35 Bedienungsanleitung

DeWalt

DeWalt DWH200D Bedienungsanleitung

Pontec

Pontec Pondomatic Vacuum Cleaner Bedienungsanleitung

Cleanmaxx

Cleanmaxx PC-P007E Bedienungsanleitung

RIDGID

RIDGID WD1685AU0 Bedienungsanleitung

Ezviz

Ezviz RE4P Bedienungsanleitung

STG global

STG global TANVAC HDV3000 Bedienungsanleitung

Shark

Shark ROTATOR PRO COMPLETE NV550 Series Bedienungsanleitung

Factory

Factory M3340 Bedienungsanleitung

Shop-Vac

Shop-Vac VN92 SERIES Bedienungsanleitung

Nobles

Nobles 608669 Produkthandbuch