Oase AquaMax Eco Classic 2500 Bedienungsanleitung

31164/06-13

AquaMax Eco Classic

2500/3500/5500/8500/11500/14500/17500

31164 GAW_AquaMax_Eco_Classic_A5_end_. 17.06.13 09:33 Seite 2

- -

- GB -

Translation of the original Operating Instructions

Information about these operating instructions

Welcome to OASE Living Water. You made a good choice with the purchase of this productAquaMax Eco Classic

2500/3500/5500/8500/11500/14500/17500.

Prior to commissioning the unit, please read the instructions of use carefully and fully familiarise yourself with the unit.

Ensure that all work on and with this unit is only carried out in accordance with these instructions.

Adhere to the safety information for the correct and safe use of the unit.

Keep these instructions in a safe place! Please also hand over the instructions when passing the unit on to a new

owner.

Symbols used in these instructions

The symbols used in this operating manual have the following meanings:

Risk of injury to persons due to dangerous electrical voltage

This symbol indicates an imminent danger, which can lead to death or severe injuries if the appropriate meas-

ures are not taken.

Risk of personal injury caused by a general source of danger

This symbol indicates an imminent danger, which can lead to death or severe injuries if the appropriate meas-

ures are not taken.

Important information for trouble-free operation.

Intended use

AquaMax Eco Classic 2500/3500/5500/8500/11500/14500/17500, in the following termed "unit", and all other parts

from the delivery scope may be used exclusively as follows:

•For pumping normal pond water for filters, waterfalls and water courses.

•Operation under observance of the technical data.

The following restrictions apply to the unit:

•Do not use in swimming ponds.

•Never use the unit to convey fluids other than water.

•Never run the unit without water.

•Do not use for commercial or industrial purposes.

•Do not use in conjunction with chemicals, foodstuff, easily flammable or explosive substances.

•Do not connect to the domestic water supply.

Safety information

Hazards to persons and assets may emanate from this unit if it is used in an improper manner or not in accordance

with its intended use, or if the safety instructions are ignored.

This unit can be used by children from the age of 8 and by persons

with physical, sensory or mental impairments or lack of experience

and knowledge, as long as they are supervised or instructed on how

to use the unit safely and are able to understand the potential haz-

ards. Do not allow children to play with the unit. Do not allow children

to clean or maintain the unit without close supervision.

- GB -

Hazards encountered by the combination of water and electricity

•The combination of water and electricity can lead to death or severe injury from electrocution, if the unit is incorrectly

connected or misused.

•Prior to reaching into the water, always switch off the mains voltage to all units used in the water.

Correct electrical installation

•Electrical installations must meet the national regulations and may only be carried out by a qualified electrician.

•A person is regarded as a qualified electrician, if, due to his/her vocational education, knowledge and experience, he

or she is capable of and authorised to judge and carry out the work commissioned to him/her. This also includes the

recognition of possible hazards and the adherence to the pertinent regional and national standards, rules and regu-

lations.

•For your own safety, please consult a qualified electrician.

•The unit may only be connected when the electrical data of the unit and the power supply coincide. The unit data is

to be found on the unit type plate or on the packaging, or in this manual.

•Ensure that the unit is fused for a rated fault current of max. 30 mA by means of a fault current protection device.

•Extension cables and power distributors (e. g. outlet strips) must be suitable for outdoor use.

•Ensure that the power connection cable cross section is not smaller than that of the rubber sheath with the identifi-

cation H05RN-F. Extension cables must meet DIN VDE 0620.

•Protect the plug connections from moisture.

•Only plug the unit into a correctly fitted socket.

Safe operation

•Never operate the unit if either the electrical cables or the housing are defective!

•Do not carry or pull the unit by its electrical cable.

•Route cords/hoses/lines in a way that they are protected against damage, and ensure that they do not present a

tripping obstacle.

•Only open the unit housing or its attendant components, when this is explicitly required in the operating instructions.

•Only execute work on the unit that is described in this manual. If problems cannot be overcome, please contact an

authorised customer service point or, when in doubt, the manufacturer.

•Only use original spare parts and accessories for the unit.

•Never carry out technical modifications to the unit.

•The power connection cables cannot be replaced. When the cable is damaged, the unit or the component needs to

be disposed of.

•Only operate the unit if no persons are in the water!

•Keep the socket and power plug dry.

Important! The unit is equipped with a permanent magnet. The magnetic field may affect the function of pace-

makers.

Installation and connection

A

Attention! Dangerous electrical voltage.

Possible consequences: Death or serious injuries due to operation of this unit in a swimming pond.

Protective measures:

•Do NOT use this unit in a swimming pond.

•Adhere to national and regional regulations.

Attention! Dangerous electrical voltage.

Possible consequences: Death or severe injury.

Protective measures:

•Before reaching into the water, disconnect all units located in the water from the mains.

•Disconnect the unit from the mains before performing any work on the unit.

•Secure the unit to prevent unintentional switching on.

- GB -

Aquamax Eco Classic 2500

Installation

Always place the unit below water level.

Place the unit horizontally on the ground ensuring its stable position.

Operating the unit in the pond

B

The pump is in the pond. The return system, e.g. a pond filter, is connected to the pump outlet.

How to proceed:

C

1. Screw the stepped hose adapter to the outlet.

2. Shorten the stepped hose adapter to the diameter of the hose used if necessary.

−This reduces pressure losses.

3. Connect the hose with the stepped hose adapter and secure with a hose clip.

Aquamax Eco Classic 3500/5500/8500/11500/14500/17500

Installation

The unit can be placed submerged or dry.

Always place the unit below water level.

Place the unit horizontally on the ground ensuring its stable position.

Operating the unit in the pond

B

The pump is in the pond. The return system, e.g. a pond filter, is connected to the pump outlet.

How to proceed:

D

1. Screw the stepped hose adapter including union nut and sealing ring to the outlet.

2. Shorten the stepped hose adapter to the diameter of the hose used if necessary.

−This reduces pressure losses.

−Align the stepped hose adapter prior to tightening the union nut.

3. Connect the hose with the stepped hose adapter and secure with a hose clip.

Install the unit at a dry place

E

Install the unit so that it is not exposed to direct sun radiation (max. 40 ºC).

How to proceed:

F

1. Remove screws.

−The screws are used as transport protection and not required for operation.

2. Actuate the engagement hook and fold up the strainer top casing.

3. Remove pump.

4. Screw the stepped hose adapter including sealing ring onto the inlet.

5. Shorten the stepped hose adapter to the diameter of the hose used if necessary.

−This reduces pressure losses.

6. Connect the hose with the stepped hose adapter and secure with a hose clip.

−Align the stepped hose adapter prior to tightening the union nut.

7. Screw the stepped hose adapter including union nut and sealing ring to the outlet.

8. Shorten the stepped hose adapter to the diameter of the hose used if necessary.

−This reduces pressure losses.

−Align the stepped hose adapter prior to tightening the union nut.

9. Connect the hose with the stepped hose adapter and secure with a hose clip.

- GB -

Start-up

Attention! Sensitive electrical components.

Possible consequence: The unit will be destroyed.

Protective measure: Do not connect the unit to a dimmable power supply.

This is how to connect the power supply:

Switching on: Connect the unit to the mains. The unit switches on as soon as the power connection is established.

Switching off: Disconnect the unit from the mains.

Aquamax Eco Classic 3500/5500/8500/11500/14500/17500

When started up, the pump automatically performs a pre-programmed self-test of approx. two minutes length (Envi-

ronmental Function Control (EFC)). The pump detects if it is running dry / blocked or submerged. The pump

switches off automatically after approx. 90 seconds if it runs dry (is blocked). In the event of a malfunction, disconnect

the power supply and flood the pump or remove the obstacle. Following this, the unit can be restarted.

Remedy of faults

Malfunction Cause Remedy

Pump does not start No mains voltage −Check mains voltage

−Check supply lines

Pump does not deliver Filter housing clogged −Clean strainer casings

Filter housing clogged −Clean strainer casings

Insufficient delivered quantity

Excessive loss in the supply lines −Select larger hose diameter

−Adapt stepped hose adapter to hose diame-

ter

−Reduce hose length to reduce frictional loss

−Avoid unnecessary connection elements

Excessively soiled water −Clean pump. The pump automatically

switches on again once the motor has cooled

down.

Water temperature too high −Note maximum water temperature of + 35°C.

The pump automatically switches on again

once the motor has cooled down.

Impeller unit blocked −Disconnect the power supply and remove

obstacle. Then switch the pump on again.

Pump switches off after a short running period

Pump has run dry −Flood pump. Fully submerge the unit when

operated in the pond.

Maintenance and cleaning

Attention! Dangerous electrical voltage.

Possible consequences: Death or severe injury.

Protective measures:

•Before reaching into the water, disconnect all units located in the water from the mains.

•Disconnect the unit from the mains before performing any work on the unit.

•Secure the unit to prevent unintentional switching on.

Cleaning the unit

If necessary, clean the unit with clear water using a soft brush.

•Never use aggressive cleaning agents or chemical solutions. These could attack the housing surface or impair the

function.

•In the event of stubborn furring (calcium deposits), a common household cleaner free from vinegar and chlorine can

be used. Subsequently, clean the pump thoroughly using clear water.

- GB -

Aquamax Eco Classic 2500

•In the event of the filter housing capacity reducing, clean the unit under running water using a brush.

Clean pump

10.

How to proceed:

G

1. Screw off the stepped hose adapter.

2. Remove screws.

−The screws are used as transport protection and not required for operation.

3. Actuate the engagement hook and fold up the strainer top casing.

4. Remove pump.

5. Unscrew the pump housing and pull out the impeller unit.

−Clean all components under running water using a soft brush, replace damage parts.

6. Reassemble the unit in the reverse order.

−Place the pump cable into the cable opening of the bottom strainer casing such that the cable will not be crushed

when closing the filter housing.

Aquamax Eco Classic 3500/5500/8500/11500/14500/17500

•In the event of the filter housing capacity reducing, clean the unit under running water using a brush.

Clean pump

How to proceed:

H

1. Screw off the stepped hose adapter.

2. Remove screws.

−The screws are used as transport protection and not required for operation.

3. Actuate the engagement hook and fold up the strainer top casing.

4. Remove pump.

5. Remove screws.

6. Remove the pump housing including its holding ring, sealing and impeller unit.

−Clean all components under running water using a soft brush, replace damage parts.

7. Reassemble the unit in the reverse order.

−Place the pump cable into the cable opening of the bottom strainer casing such that the cable will not be crushed

when closing the filter housing.

Wear parts

The impeller unit is a wearing part and does not fall under the warranty.

Storage/Over-wintering

Remove the unit at temperatures below zero degrees centigrade. Thoroughly clean and check the unit for damage.

Store the unit immersed in water or filled with water in a frost-free place. Do not flood the power plug!

Repair

A damaged unit cannot be repaired and must be put out of operation. Dispose of the unit in accordance with the

regulations.

Disposal

Do not dispose of this unit with domestic waste! For disposal purposes, please use the return system provided.

Disable the unit beforehand by cutting off the cables.

115

DE Typ Bemessungsspannung Leistungsaufname Förderleistung Wassersäule Tauchtiefe Kabellänge Gewicht Wassertemperatur

GB Type Rated voltage Power consumption Max. flow rate Max. head height Immersion depth Cable length Weight Water temperature

FR Type Tension de mesure Puissance absorbée Capacité de refoule-

ment

Colonne d'eau Profondeur d'immer-

sion

Longueur de câble Poids Température de

l’eau

NL Type Dimensioneringsspanning Vermogensopname Pompcapaciteit Waterkolom Dompeldiepte Kabellengte Gewicht Watertemperatuur

ES Tipo Tensión asignada Consumo de potencia Capacidad de

elevación

Columna de agua Profundidad de

inmersión

Longitud del cable Peso Temperatura del

agua

PT Tipo Voltagem considerada Potência absorvida Débito Coluna de água Profundidade de

imersão

Comprimento do

cabo

Peso Temperatura da

água

IT Tipo Tensione di taratura Potenza assorbita Portata Colonna d'acqua Profondità d'immersio-

Lunghezza cavo Peso Temperatura dell'ac-

qua

DK Type Nominel spænding Effektforbrug Transportkapacitet Vandsøjle Bassindybde Ledningslængde Vægt Vandtemperaturen

NO Type Merkespenning Effektopptak Kapasitet Vannsøyle Nedsenkningsdybde Kabellengde Vekt Vanntemperatur

SE Typ övre märkspänning Effekt Matningsprestanda Vattenpelare Doppningsdjup Kabellängd Vikt Vattentemperatur

FI Tyyppi mitoitusjännite Ottoteho Syöttöteho Vesipylväs Upotussyvyys Kaapelin pituus Paino Veden lämpötila

HU Típus mért feszültség Teljesítményfelvétel Szállítási teljesítmény Vízoszlop Merülési mélység Kábelhossz Súly Vízhőmérséklet

PL Typ napięcie znamionowe Pobór mocy Wydajność

pompowania

Słup wody Głębokość zanurzenia Długość kabla Ciężar Temperatura wody

CZ Typ domezovací napětí Příkon Dopravní výkon Vodní sloupec Hloubka ponoření Délka kabelu Hmotnost Teplota vody

SK Typ dimenzačné napätie Príkon Dopravný výkon Vodný stĺpec Hĺbka ponorenia Dĺžka kábla Hmotnost’ Teplota vody

SI Tip dimenzionirana napetost Poraba moči Črplana zmogljivost Vodni steber Potopna globina Dolžina kabla Teža Temperatura vode

HR Tip gornji nazivni napon Potrošnja energije Protočni kapacitet Vodeni stup Dubina uranjanja Duljina kabela Masa Temperatura vode

RO Tip tensiunea măsuratăPutere consumatăDebit de pompare Coloanăde apăAdâncime de imersie Lungime cablu MasăTemperatura apei

BG Тип номинално напрежение Потребявана мощност Дебит Воден стълб дълбочина на

потапяне

Дължина на

кабелите

Тегло Температурата на

водата

UA Тип розрахункова напруга Споживання

електроенергії

Продуктивність Водяний стовп Глибина занурення Довжина кабелю Вага Температура води

RU Тип расчетное напряжение Потребление мощности Производительность Водяной столб Глубина погружения Длина кабеля Вес Температура воды

CN 型号设计电压功耗输送能力水柱潜水深度电缆长度重量水温

2500 40 W ≤40 l/min ≤2.0 m max. 2 m 1.9 kg

3500 45 W ≤60 l/min ≤2.2 m

5500 60 W ≤88 l/min ≤2.8 m 3.2 kg

8500 80 W ≤138 l/min ≤3.2 m 4.4 kg

11500 100 W ≤183 l/min ≤3.3 m

14500 135 W ≤227 l/min ≤3.4 m

Aquamax

Eco

Classic

17500

230 V AC / 50 Hz

170 W ≤290 l/min ≤3.7 m

max. 4 m 10 m

5.0 kg

+4 … +35 ºC

Andere Handbücher für AquaMax Eco Classic 2500

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Oase Wasserpumpe Handbücher

Oase

Oase Aquarius Universal Premium Series Bedienungsanleitung

Oase

Oase Aquarius Universal Classic 600 Bedienungsanleitung

Oase

Oase promax cleardrain 7000 Bedienungsanleitung

Oase

Oase Atlantis 30 Handbuch

Oase

Oase Water Trio Bedienungsanleitung

Oase

Oase AquaMax Eco Classic 9000 C Bedienungsanleitung

Oase

Oase AquaMax Eco Expert 20000/12V Bedienungsanleitung

Oase

Oase promax cleardrain 7000 Bedienungsanleitung

Oase

Oase ProMax Pressure Automatic 5500/5 Bedienungsanleitung

Oase

Oase SwimSkim 25 Leitfaden

Oase

Oase Aquarius Solar 700 Bedienungsanleitung

Oase

Oase Aquarius Eco Expert 28000 Bedienungsanleitung

Oase

Oase OptiMax 250 Installationsanleitung

Oase

Oase Aquamax Eco 4000 CWS Bedienungsanleitung

Oase

Oase AQUARIUS UNIVERSAL 80 Bedienungsanleitung

Oase

Oase ProMax MudDrain 7000 Bedienungsanleitung

Oase

Oase Aquamax Dry 6000 Bedienungsanleitung

Oase

Oase biOrb AIR 30 Bedienungsanleitung

Oase

Oase Optimax 10.000 Bedienungsanleitung

Oase

Oase Aquarius Universal Classic 600 Bedienungsanleitung

Oase

Oase HeatUp 150 Bedienungsanleitung

Oase

Oase Aquarius Fountain Set Classic Series Bedienungsanleitung

Oase

Oase Aquarius Universal Classic 600 Bedienungsanleitung

Oase

Oase ProMax MudDrain 25000 Bedienungsanleitung

Beliebte Wasserpumpe Handbücher anderer Marken

Neptun

Neptun NPHW 5500 Bedienungsanleitung

Sensidyne

Sensidyne Gilian BDX-II Montage- und Bedienungsanleitung

Draper

Draper 47808 Bedienungsanleitung

Trolla

Trolla 12820 Bedienungsanleitung

Sunfab

Sunfab SVH Series Bedienungsanleitung

WilTec

WilTec 50740 Bedienungsanleitung

Fieldmann

Fieldmann FVC 5015 EK Bedienungsanleitung

Everbilt

Everbilt EFSUB5-122HD Bedienungsanleitung

Graco

Graco Husky 3300e Bedienungsanleitung

esotec

esotec 101018 Bedienungsanleitung

Becker

Becker BASIC VASF 2.80/1-0.AC230 Bedienungsanleitung

Sykes AmeriPumps

Sykes AmeriPumps GP100M Fehlerbehebungshandbuch

DUROMAX

DUROMAX XP WX Series Bedienungsanleitung

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Bedienungsanleitung

Franklin Electric

Franklin Electric IPS Bedienungsanleitung

Xylem

Xylem e-1532 Series Bedienungsanleitung

Milton Roy

Milton Roy PRIMEROYAL Bedienungsanleitung

STA-RITE

STA-RITE ST33APP Bedienungsanleitung