Raypak Hydronic Heating Boiler 992BE-2342BE Bedienungsanleitung

Catalog No.: 2000.451E Effective: 11-15-07 Replaces: 1-1-07

Job:

Engineer:

Contractor:

Prepared By: Date:

Model: Indoor/Outdoor: MBTUH Input:

100% Factory Fire Tested

Efficiency: 87%

Maximum Outlet Temperature: 230°F

Minimum Non-Condensing Inlet Temperature: 120°F

Thermal Shock Proof Heat Exchanger

Limited Twenty-Year Thermal Shock Warranty

Limited Ten-Year Closed-System Heat Exchanger

Warranty

Diagnostic Center with Fault History

PolyTuf Powder Coated Cabinet

No Combustible Floor Shield Required

Fan-Assisted

Patented Burner Security Blanket

Heat Exchanger

H Stamp

Headers

Glass-Lined Cast Iron – Standard

Bronze – Option A-1

ASME Inspected and Stamped

160 PSIG Working Pressure

National Board Approved

Fin Tubing

Copper – Standard

Cupro Nickel – Option A-3

ASME Steel Tube Sheet

Silicone High Temp. O-Rings

ASME Pressure Relief Valve

60 PSIG – Standard

PSIG – Optional

Temperature and Pressure Gauge

Water Connections

Left – Standard

Right – Option A-6

Controls

120V, 60Hz, 1∅Power Supply

120/24V 60Hz Transformer

100% Shut-Off/Lockout

Hot Surface Ignition

Remote Flame Sensor

High Limit Control, Manual Reset

On/Off Power Switch

Manual Shut-Off, Front-Mounted

Flow Switch

Blocked Vent Pressure Switch

Combustion Air Proving Switches

Economaster Pump Time Delay

Enable/Disable

Gas Train

Manual Gas Shut-Off Valve(s)

Gas Pressure Regulator

Safety Shut-Off Valve

Firing Control Valve

Low Gas Pressure Switch, Manual

Firing Mode

3-Stage (H8): Model 992BE

4-Stage (H9): Models 1262BE -

2342BE

Fuel

Natural Gas

Propane Gas

4” WC Gas Supply Pressure

G-20

Design Certified ANSI Z21.13/

CSA 4.9

Construction

Indoor/Outdoor Construction

Enclosed Front Controls

Venting

Vent Location

Top – Standard

Rear – Option D-14

Vent Termination Cap

Outdoor D-11

Indoor, Horizontal D-15

Indoor, Vertical (by others)

Combustion Air

In-Line Filter Kit (TruSeal only)

D-17

Air Intake Elbow D-16

Extractor – Optional

By others

Not required

Burner

Ultra-Low NOx: Less than 30 PPM

Temperature Controls

B- TempTracker Digital Controller,

4-Stage

Y-241 Electronic Sequencer, 4-Stage

Y-281 Electronic Sequencer, 8-Stage

Options

C-6 Ignition Module, Manual Reset

D-21 TruSeal®Direct Vent

F-10 Low Water Cut-Off, Remote

Probe

I-1 High Limit Control, Auto Reset

P- Pump: HP, 120V, 1∅,

60Hz

Water Hardness: GPG

Cast Iron Bronze

Mounted Loose

Front Rear

P-26 Cold Water Start (See 2000.49)

S-2 High Gas Pressure Switch,

Manual

X-1 SureRack™ Kit

X-2 SureRack Add-on

Regulatory Agency Requirements

Hi Delta

- Type H

Hydronic Heating Boiler

Models 992BE-2342BE

87% Efficiency

Catalog No.: 2000.451E Effective: 11-15-07 Replaces: 1-1-07

Hi Delta – Type H

Models 992BE-2342BE, 87% Efficiency Model

SPECIFICATIONS

Approx.

MBTUH Firing

mp. Shipping

Model Input Output Stages Width NPT Draw* Wt. (Lbs.)

992BE 990 861 3 57-1/8 2-1/2 10 10 16-13/16 <12 900

1262BE 1260 1096 4 68-1/2 2-1/2 12 10 20-9/16 <12 1010

1532BE 1530 1331 4 79-7/8 2-1/2 12 10 24-3/8 <12 1225

1802BE 1800 1566 4 91-1/8 2-1/2 14 10 28-1/8 <12 1350

2002BE 1999 1739 4 102-1/2 2-1/2 14 10 31-15/16 <12 1450

2072BE 2070 1801 4 102-1/2 2-1/2 14 10 31-15/16 <12 1450

2342BE 2340 2036 4 113-7/8 2-1/2 16 10 35-11/16 <12 1520

Dimensions are in inches. * Without pump

RATES OF FLOW AND PRESSURE DROPS

20°F ∆T 30°F ∆TMin. Flow Max. Flow

Model GPM ∆P (ft) GPM ∆P (ft) GPM ∆P (ft) ∆T GPM ∆P (ft) ∆T

992BE 86 6.0 57 2.7 43 1.6 40 132 14.0 13

1262BE 110 10.7 73 4.9 55 2.8 40 132 15.5 17

1532BE 132 16.5 89 7.6 67 4.4 40 132 16.5 20

1802BE N/A N/A 104 11.6 78 6.5 40 132 18.0 24

2002BE N/A N/A 116 15.1 87 8.7 40 132 19.5 26

2072BE N/A N/A 120 16.2 90 9.3 40 132 19.5 27

2342BE N/A N/A N/A N/A 102 13.0 40 132 21.0 31

Basis is 30 GPM or 40°F ∆T for minimum flow, 132 GPM for maximum flow.

NOTE: Pump location

varies based on model

and application.

NOTES: 1. Rates shown are for natural or propane gas, and elevations up to 5,000 feet. For installation above 5,000 feet, please contact manufacturer.

2. Required natural gas pressure is 7 – 10.5” WC. Required propane gas pressure is 11 – 13” WC.

Raypak, Inc. 2151 Eastman Avenue, Oxnard, CA 93030 (805) 278-5300 Fax (800) 872-9725 www.raypak.com

Dieses Handbuch passt für folgende Modelle

Andere Raypak Boiler Handbücher

Raypak

Raypak 992B-2342B Handbuch

Raypak

Raypak RSIT30 Handbuch

Raypak

Raypak HI DELTA HD101 THRU 2342B Handbuch

Raypak

Raypak Power Vent Raytherm 2100 Bedienungsanleitung

Raypak

Raypak RAYTHERM 133-4001 Handbuch

Raypak

Raypak 80 and 115 Gallons Bedienungsanleitung

Raypak

Raypak 992C Handbuch

Raypak

Raypak Raytherm WH-2100 Bedienungsanleitung

Raypak

Raypak B0109 Technisches Dokument

Raypak

Raypak 260-401 Bedienungsanleitung

Raypak

Raypak 185 Bedienungsanleitung

Raypak

Raypak XFYRE NINETY PLUS 300 Bedienungsanleitung

Raypak

Raypak 2600401 Handbuch

Raypak

Raypak DEL TA LIMITED 899B Bedienungsanleitung

Raypak

Raypak DELTA LIMITED 2339B Bedienungsanleitung

Raypak

Raypak HI DELTA 122-322 Handbuch

Raypak

Raypak Power Vent Raytherm 2100 Bedienungsanleitung

Raypak

Raypak ECONOPAK WH-260 Bedienungsanleitung

Raypak

Raypak 2004 Bedienungsanleitung

Raypak

Raypak 122-322 Bedienungsanleitung

Raypak

Raypak HI DELTA HD101 THRU 2342B Handbuch

Raypak

Raypak HI DELTA SS HD101 Bedienungsanleitung

Raypak

Raypak B-195 Bedienungsanleitung

Raypak

Raypak 1005-2005 Bedienungsanleitung

Beliebte Boiler Handbücher anderer Marken

Kenmore

Kenmore 153.582400 Bedienungsanleitung

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Bedienungsanleitung

clage

clage E-Mini Series Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-180 Bedienungsanleitung

Bradford White

Bradford White EF Series Bedienungsanleitung

Eccotemp

Eccotemp 40-H Bedienungsanleitung

Dimplex

Dimplex ECSd125-580 Leitfaden

Dux

Dux 32FCR6N Bedienungsanleitung

Noritz

Noritz N-132M Gebrauchsanweisung

TESY

TESY GCV7/4S 10047 Technisches Datenblatt

A.O. Smith

A.O. Smith Gphe 50 Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Fehlerbehebungshandbuch

Koryo

Koryo KWHZF15Y Bedienungsanleitung

Pentair

Pentair PSC-14-4-02 Bedienungsanleitung

GE 40M06AAG Montageanleitung

Thermor

Thermor AEROMAX SPLIT 2 Bedienungsanleitung

American Hometec

American Hometec AHQ-B03X Bedienungsanleitung

PVI

PVI MAXIM Bedienungsanleitung