SportsPlay JR SLIDER Bedienungsanleitung

Detail A

(Details Continued

(Details Continued(Details Continued

(Details Continued

on Sheet 2)

on Sheet 2)on Sheet 2)

on Sheet 2)

JR SLIDER

JR SLIDERJR SLIDER

JR SLIDER

543

311-145

311-145311-145

311-145

Sheet 1 of 3

Sheet 1 of 3Sheet 1 of 3

Sheet 1 of 3

I EM NO. PAR

NUMBER DESCRIP ION Q Y.

1 435-600 Slide Bedway 1

2 313-428 Platform 1

3 905-707 Stair 1

4 403-317 Entrance Rail 3

5 403-248 Guard Rail Leg Assembly 2

6 103-306 Slide Leg 1

7 314-460 Leg Holder 1

8 383-461 Right Stair Hand Rail 1

9 383-962 Left Stair Hand Rail 1

10 126-504 5/16" x 1" Carriage Bolt 3

11 435-405 Attachment Bracket 1

12 415-513 1-3/8" " " Clamp 6pr

13 226-602 3/8" Nylon Insert Lock 2

14 126-704 3/8" x 3/4" Button Head Bolt 2

15 116-530 5/16" x 1" Button Head Bolt 12

16 116-604 3/8" x1" Hex Bolt 7

17 326-601 3/8" Lock Washer 7

18 196-802 1/2" x 1/2" Socket Set Screw 2

19 116-545 5/16" x 2-1/2" Button Head Bolt 2

20 316-601 3/8" Flat Washer 15

21 326-501 5/16" Lock Washer 14

22 216-512 5/16" Button Head Nut 10

23 226-501 5/16" Lock Nut 6

24 316-501 5/16" Flat Washer 8

25 416-350 3/16" Socket key 2

26 805-532 Warning Label 2

27 805-534 SportsPlay 2

28 000-000 Maintenance Check List 1

Detail B

Detail C

21 15

*IMPORTANT*

*IMPORTANT**IMPORTANT*

*IMPORTANT*

two bolt connections. In man situations onl one bolt is required.

remove an sharp edges. Go over entire unit to file smooth an sharp

(Details Continued

(Details Continued(Details Continued

(Details Continued

Detail D

Detail G

Detail E

in shipping or installation. T-Clamps are designed for both one and

edges or projections that ma have been caused b rough handling

Detail F

From Sheet 1)

From Sheet 1)From Sheet 1)

From Sheet 1)

and/or replace immediatel .

GENERAL MAINTENANCE INSTRUCITONS:

GENERAL MAINTENANCE INSTRUCITONS:GENERAL MAINTENANCE INSTRUCITONS:

GENERAL MAINTENANCE INSTRUCITONS:

install 1 - 2 degrees off level to facilitate water drainage.

See specific assembl instructions. On products with platforms

include "A Handbook For Public Pla ground Safet ". You can receive

under all pla ground equipment. Appropriate publications, available

GENERAL ASSEMBLY INSTRUCTIONS:

GENERAL ASSEMBLY INSTRUCTIONS:GENERAL ASSEMBLY INSTRUCTIONS:

GENERAL ASSEMBLY INSTRUCTIONS:

our free cop b calling 1-301-504-0580.

of equipment and safet of users. Resilient Surfacing should be used

at NO Charge, from the consumer product Safet Commission,

and/or replacement of damaged parts is necessar for safe operation

cause serious injur . Periodical inspections, maintenance, repair

properl . Pla ground equipment which is improperl maintained can

prevent direct Sun on Slide's Chute.

NOTE: Slide should be installed in shaded areas or face NORTH to

Check MONTHLY for loose bolts, damaged or broken parts. Tighten

SPECIFIC ASSEMBLY INSTRUCTIONS:

SPECIFIC ASSEMBLY INSTRUCTIONS:SPECIFIC ASSEMBLY INSTRUCTIONS:

SPECIFIC ASSEMBLY INSTRUCTIONS:

Please retain this instruction sheets in our files. It contains important

replacement parts information. All equipment should be installed in

accordance with these instructions.

It is important to use and maintain all public pla ground equipment

Check all the parts and hardware with the packing list to be sure ou

have received ever thing needed to assemble this product. Contact

Your Local Distributor with notification of an missing or damaged

parts. Contact must be make within 10 da s of receipt of our order.

Onl hand-tighten nuts & bolts on initial assembl . Final tightening

should be done EVENLY after final assembl when unit has been

plumbed & leveled. After assembl is complete, an ends of bolts

protruding be ond nuts should be cut off and/or peened over to

NOTE: All threaded ends of bolts protruding be ond nuts must be

cut off and/or peened to eliminate sharp edges. NO more

than two threads should extend be ond face of nut.

All washers, "T" nuts, and other fastener hardware used on

round pipe or tubing must be hammered down to conform to

the curved underl ing surface to eliminate catch points.

JR SLIDER

JR SLIDERJR SLIDER

JR SLIDER

543

311-145

311-145311-145

311-145

Sheet 2 of 3

Sheet 2 of 3Sheet 2 of 3

Sheet 2 of 3

1'-0"

2'-0"

1'-0"

3'-0"

24'-6"

6'-0" 3'-0" 3'-0" 6'-6" 78

2'-0" 1'-6"

6'-0"

15'-0"

6'-0"

JR SLIDER

JR SLIDERJR SLIDER

JR SLIDER

543

311-145

311-145311-145

311-145

Resilient

Safety

Surfa ing

Pipe

Top of

Non

Safety

Surfa ing

2'-0"

Dia.

1'-0"

or removed. Conta t your distributor for repla ement Labels.

Step 6: Plumb & Level. Tighten all nuts & bolts so that lo k washers

GENERAL USE/FALL ZONE & FOOTING RECOMMENDATIONS:

GENERAL USE/FALL ZONE & FOOTING RECOMMENDATIONS:GENERAL USE/FALL ZONE & FOOTING RECOMMENDATIONS:

GENERAL USE/FALL ZONE & FOOTING RECOMMENDATIONS:

in a lo ation where they are learly visible and legible and

bra es, installing Resilient Surfa ing & using equipment.

Step 7: Atta h Warning Label and Manufa turer's Identifi ation

Labels must be repla ed if they be ome illegible, destroyed

away from normal hand and foot pla ement areas. The

Varying soil & limati onditions may require deeper & heavier

PERMANENT INSTALLATION:

PERMANENT INSTALLATION:PERMANENT INSTALLATION:

PERMANENT INSTALLATION:

satisfa tory in most appli ations for pipe sizes up to 2-3/8" diameter.

footings in some areas. Che k Lo al Building Codes.

Label to a lean surfa e. The Labels should be atta hed

are flat. Pour Con rete. Wait 48 hours before removing

Sheet 3 of 3

Sheet 3 of 3Sheet 3 of 3

Sheet 3 of 3

Step 1: Mark & dig footing holes per footing diagram.

Step 2: Assemble Platform on the ground. Atta h Guardrail Leg

Assemblies. See Detail A. Atta h Slide Leg. See Detail E

& F.

Step 3: Turn right side up & bra e in footing holes. Length of pipe

below intended level of Resilient Surfa ing should be 24"

Atta h Slide Entran e Rail. See Detail G.

Step 4: Atta h Stair Assembly & Stair Hand Rails to Guardrail Leg

Assembly. See Detail B & C.

Step 5: Atta h plasti Slide to Platform. See Detail D.

Stationary & Portable Equipment - Use/Fall Zones should extend

a minimum of 6 feet in al dire tions from the perimeter of the equip-

ment ground spa e. This area should be overed with the required

amount of Resilient Safety Surfa ing Material. For some equipment

Use/Fall Zones an overlap. See onsumer produ t safely omm-

ission guidelines. Diameter & depth of footing illustration are

*If Resilient Surfa ing is to be less than 12", then additional pipe

should be put in on rete to maintain proper finish grade for

equipment.*

Surfa ing

Resilient

Safety

Upright

UprightUpright

Upright

Con rete

Con reteCon rete

Con rete

Footing

FootingFooting

Footing

Angled

AngledAngled

Angled

Pipe

Footing

FootingFooting

Footing

Con rete

Con reteCon rete

Con rete

Top of

Non

Safety

Surfa ing

Dia.

1'-0"

FOOTING DIAGRAM

FOOTING DIAGRAMFOOTING DIAGRAM

FOOTING DIAGRAM

Dieses Handbuch passt für folgende Modelle

Andere SportsPlay Spielgeräte und Spielplatzausstattung Handbücher

SportsPlay

SportsPlay Jeremy 911-116-N Bedienungsanleitung

SportsPlay

SportsPlay 581-230-8F Bedienungsanleitung

SportsPlay

SportsPlay 581-638M Bedienungsanleitung

SportsPlay

SportsPlay 911-255 Bedienungsanleitung

SportsPlay

SportsPlay 581-830H Bedienungsanleitung

SportsPlay

SportsPlay MODERN BIPOD ADA SWING Bedienungsanleitung

SportsPlay

SportsPlay 581-230F Bedienungsanleitung

SportsPlay

SportsPlay MUSHROOM KOTTAGE Bedienungsanleitung

SportsPlay

SportsPlay 581-438F Bedienungsanleitung

SportsPlay

SportsPlay 511-114 Bedienungsanleitung

SportsPlay

SportsPlay Miss Abby Installations- und Betriebshandbuch

SportsPlay

SportsPlay 511-102 Bedienungsanleitung

SportsPlay

SportsPlay 902-795 Bedienungsanleitung

SportsPlay

SportsPlay 902-293 6' IND. SECTIONAL SLIDE Bedienungsanleitung

SportsPlay

SportsPlay Value Series Bedienungsanleitung

SportsPlay

SportsPlay 581-240HD Bedienungsanleitung

SportsPlay

SportsPlay 801-312-H Bedienungsanleitung

SportsPlay

SportsPlay 581-842HD Bedienungsanleitung

SportsPlay

SportsPlay 511-107C Bedienungsanleitung

SportsPlay

SportsPlay 902-875 Bedienungsanleitung

SportsPlay

SportsPlay 382-404H Bedienungsanleitung

SportsPlay

SportsPlay 581-830-8F Bedienungsanleitung

SportsPlay

SportsPlay 581-440HD Bedienungsanleitung

SportsPlay

SportsPlay Seth Mega Installations- und Betriebshandbuch

Beliebte Spielgeräte und Spielplatzausstattung Handbücher anderer Marken

FUNormous

FUNormous Disney Junior MICKEY MOUSE Bedienungsanleitung

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Bedienungsanleitung

PoolMaster

PoolMaster 72775 Bedienungsanleitung

Palmako

Palmako 4743142009857 Installationshandbuch

BOERPLAY

BOERPLAY PSTE000.019 Bedienungsanleitung

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Benutzerhandbuch

stilum

stilum Erika Bedienungsanleitung

Costway

Costway NP10816 Bedienungsanleitung

Trigano

Trigano VABI Bedienungsanleitung

Outward

Outward OUT116 Bedienungsanleitung

GALOPIN

GALOPIN ARC02 Bedienungsanleitung

stilum

stilum levis Technische Daten

Ledon

Ledon BASIC Bai LB012 Bedienungsanleitung

BOERPLAY

BOERPLAY PSTE115.002 Bedienungsanleitung

Europlay

Europlay S306 Programmierhandbuch

SportsPlay Equipment

SportsPlay Equipment 361-509H Bedienungsanleitung

Ledon

Ledon 302250 Bedienungsanleitung

Costway

Costway NP10441 Bedienungsanleitung