Swisher FC14566CPKA Bedienungsanleitung

8/22/2019

COMMERCIAL PRO

66” FAST FINISH

TRAIL MOWER

OWNER’S

MANUAL

SWISHER ACQUISITION INC.

1602 CORPORATE DRIVE, WARRENSBURG MISSOURI 640 3

PHONE 660-747-8183 FAX 660-747-8650

MODEL NO.

FC14566CPKA

FC14566CPKA-CA

Assembly

Operation

Service and Adjustment

Repair Parts

www.swisherinc.com

20 28 REV 18-335

STARTING SERIAL #:

L118-33 001

IMPORTANT

Read and follow all

Safety Precautions

and Instructions

before operating this

equipment.

ade I The

USA

of US and Global Parts

⡆



LIMITED WARRANTY







 

!

As require by CFR § 1060.120, the fuel system relate components, which have been

certifie to this equipment by SAI are to be free of efects in material an workmanship for a

perio of two (2) years from the ate of purchase by the original consumer purchaser.

1) Engine Warranty "#

!"



$

%&$'

()*++),-.)-./.)0)

2) Commercial Use This pro uct has a (12) 34

12"5)&6



3) Limitations This warranty applies only to pro ucts, which have been

properly assemble , a juste , an operate in accor ance with

the instructions containe within this manual. This warranty

oes not apply to any pro uct of Swisher that has been subject

to alteration, misuse, abuse, improper assembly or installation,

shipping amage, or to normal wear of the pro uct.

4) Exclusions Exclu e from this warranty are normal wear, normal

a justments, an normal maintenance.

In the event you have a claim un er this warranty, you must return the pro uct to an

authorize service ealer. All transportation charges, amage, or loss incurre uring

transportation of parts submitte for replacement or repair un er this warranty shall be borne

by the purchaser. Shoul you have any questions concerning this warranty, please contact us

toll-free at 1-800-222-8183. The mo el number, serial number, ate of purchase, an the

name of the authorize Swisher ealer from whom you purchase the mower will be nee e

before any warranty claim can be processe .

THIS WARRANTY DOES NOT APPLY TO ANY INCIDENTAL OR CONSEQUENTIAL

DAMAGES AND ANY IMPLIED WARRANTIES ARE LIMITED TO THE SAME TIME

PERIODS STATED HEREIN FOR ALL EXPRESSED WARRANTIES. Some states o not

allow the limitation of consequential amages or limitations on how long an implie warranty

may last, so the above limitations or exclusions may not apply to you. This warranty gives

you specific legal rights an you may have other rights, which vary from state-to-state. This is

a limite warranty as efine by the Magnuson-Moss Act of 1975.

勰7

SAFETY PRECAUTIONS

•Rea the manual. Learn to operate this machine safely.

•Always isconnect the spark plug wire an place the wire where it cannot contact the spark plug, to prevent

acci ental starting the engine when setting up, transporting, a justing or making repairs.

•Keep all shiel s an guar s in place.

•Un erstan the spee , steering an stability of this machine. Know the positions an operations of all

controls before you operate this machine. Check all of the controls in a safe area before starting to work

with this machine.

•Allow only responsible a ults who are familiar with these instructions to operate this machine. Never allow

chil ren to operate this machine.

•Clear the area of objects such as rocks, toys, wire, etc. that can be picke up an thrown by the bla e.

•Be sure the area is clear of other people before mowing. Be aware of the mower ischarge irection an o

not point at anyone. Stop the machine if anyone enters the mowing area. Chil ren are often attracte to the

machine an the mowing activity. Never assume that children will remain where you last saw them.

Keep chil ren un er the watchful care of another responsible a ult.

•No riders!

•Do not put han s or feet near or un er rotating parts. Keep clear of the ischarge opening at all times.

•Do not mow in reverse. Always look own an behin before an while backing.

•Turn off the bla es when not mowing. Before leaving the machine, turn off the bla es an stop the engine.

•Watch for traffic when operating near or crossing roa ways.

•Do not operate the mower if it has been roppe or amage in any manner or if the mower vibrates

excessively. Excessive vibration is an in ication of amage. Repair mower as necessary.

•Dress properly. Do not operate the mower when barefoot or wearing open san als. Wear only soli shoes

with goo traction when mowing.

•Do not operate the machine while un er the influence of alcohol or rugs.

•Do not operate on slopes greater than 15 egrees.

•Never tamper with safety evices. Check their proper operation regularly.

•Stop an inspect the equipment if you strike an object. Repair, if necessary, before restarting.

•Never make a justments or repairs with the engine running.

•Mower bla es are sharp an can cut. Wrap the bla es or wear gloves, an use extra caution when servicing

them.

This Safety Alert Symbol indicates important messages in this

manual. When you see this symbol, carefully read the message that

follows and be alert to the possibility of personal injury.

Read this manual completely. This machine can amputate hands, feet, and throw

objects. Failure to observe the following safety instructions could result in serious

injury or death.

䅐8

SAFETY DECALS

Replace ecals imme iately if amage .Or er by part number from Swisher

OD45- Warning Decal

OD11- No step Decal

OD55- Triangle Danger Decal

OD33- Spee Decal

OD29- Danger Decal

OD43- Flying Debris Decal

REQUIRED ASSEMBLY

FRONT WHEEL CASTER ASSEMBLY

1.Remove single nut an washers from caster shaft.

2.Place one washer on the shaft of the caster/wheel sub-assembly.

3.Sli e same shaft through the bearing/frame with wheel towar s the groun .

4.Place the other washer on the shaft; it shoul be resting on the top bearing.

5.Threa nyloc jam nut onto shaft.

6.Tighten nut snuggly, making sure shaft threa s enter the nyloc of the nut.

Over-tightening this nut will bind caster.

7.Repeat process for other front si e.

REAR WHEEL ASSEMBLY

1.Remove cotter pin from axle.

2.Sli e washer (NB149) if necessary an wheel (valve stem out) onto axle an replace

cotter pin.

3.Ben cotter pin so it will not fall out.

4.Repeat process for other wheel.

OFFSET & CENTER TOW HITCH BAR ASSEMBLY

1.Lay out parts accor ing to the iagram.

2.Insert part 661A into part 12543 an pin with the hitch pin (H11).

3.Insert part 20954 into part 661A. Choose from the 3 holes to set the esire hitch length.

Pin with a hitch pin.

4.Part 12543 sli es into the front tube of the frame. Choose from the 5 holes to arrange

esire offset. Pin with a hitch pin (H11).

5.Eliminate step 2 for hitching from the center bracket. Only one metho can be use at a

time.

Bent Pin, Hair Pin

an Receiver

supplie by others.

Existing Rear Hitch.

ATV or Utility

Vehicle Attachment

Instructions

쇰;

OPERATING YOUR TRAIL MOWER

INTENDED USE

This Trail Mower is esigne to pro uce a quality finish cut on lawns, golf courses, etc. It is

not esigne to clear brush or cut saplings. Your Trail Mower shoul be towe behin an

ATV, a golf cart, lawn tractor, or similar approve vehicle. It is not meant for spee s

excee ing 5 mph.

ATTACHING TRAILMOWER TO TOW VEHICLE

•Place mower behin vehicle an back vehicle up to esire attaching position.

•When offsetting Trail Mower o so to si e opposite the ischarge of the tow vehicle.

•Attach tow hitch (661) to the swivel hitch with hitch pin (H11). Make certain hitch

pin goes completely through each piece an is clippe to prevent acci ental

separation.

•Attach re safety tether (6736) to both the towing vehicle an to the TrailMower

toggle switch (685SP), locate on the throttle housing (6013). Its purpose is to

manually stop mower engine or to stop mower engine in case the two machines

become separate . (See Motor Base Detail #20).

•It is extremely important the safety tether is secured properly to both the toggle

switch and the towing vehicle.

STARTING THE ENGINE

See engine manufacturer’s instructions for the type an amount of oil an fuel use . Trail

Mowers with electric start engines will nee a battery (sol separately). Swisher recommen s

using a stan ar “U1” lawn & gar en battery.

The operation of any mower can pro uce foreign objects to be thrown into the

eyes, resulting in severe eye amage. Always wear certifie safety glasses or

wi e-vision safety goggles over spectacles before starting any cutting machine an

while operating such a machine.

The operation of any cutter pro uces soun waves that are amaging to the

human ear. Ear protection is recommen e .

CAUTION!

Tragic acci ents can occur if the operator is not alert to the presence of

chil ren. Chil ren are often attracte to the machine an the mowing

activity. Never assume that children will remain where you last saw them.

IMPORTANT: <= 

26>2$...3)

))?

혠@

•

Engine must be level to accurately check an fill oil. Do not overfill.

•Make sure the tow vehicle parking brake is set, mower is level, an bla es are isengage .

•Bla es must be isengage .

•Check spark plug wire, oil, an fuel.

•Check all electrical connections (See Schematics).

•Make sure toggle switch is turne “ON” an the re tether is properly attache .

•Set engine i le to “CHOKE” position.

•With feet clear of mower eck, turn key switch to the “START” position an release when

engine begins to run.

•Set engine i le at esire RPM.

BREAKING IN YOUR MOWER

•Set vehicle parking brake or chock wheels to prevent acci ental rolling.

•Start engine properly.

•Slowly, engage bla e control.

•In a safe environment, i.e. no chil ren, allow bla es to rotate an engine to i le for 5

minutes. This breaks in the belts an the engine.

•Stop mower properly.

MOWER HEIGHT ADJUSTMENT

•A just while mower is not running.

•The cutting range is approximately 1” to 5.5”. The height shoul be measure from the

groun to the bla e tip without the engine running.

•

Rotate height a just crank han les (H7N) in a clockwise irection to lift the mower eck. A

counter-clockwise irection is use to lower the mower eck.

•Make sure the height a justment is the same at si e crank han les. For best results, see

“SUGGESTED PRACTICE” section. Gra uate scales are for reference only, not the

actual cutter height.

•Place crank han le in a retracte position to maintain height a justment.

STARTING TO MOW

•A just the cutting height.

•Double check vehicle to mower attachment.

•Start mower engine properly.

•Slowly, activate the bla e engage lever by rotating it forwar an left until the lever locks

into place.

•Carefully mount tow vehicle an start mowing slowly.

STOPPING THE MOWING SESSION

•Pull safety tether to shut toggle switch “OFF”. If the engine fails to stop or if the safety

tether has become inoperable, then use Alternative Stopping Metho .

CAUTION!

SHUT OFF MOWER ENGINE AND REMOVE SPARK PLUG WIRE FROM

SPARK PLUG BEFORE MAKING ANY ADJUSTMENTS TO THE MOWER.

ฐA

ALTERNATIVE STOPPING METHOD

•Bring vehicle to complete stop, shut off engine, an set parking brake.

•Disengage bla e engage lever.

•Manually shut toggle an key switches to their “OFF” positions.

•Always remember to remove keys to avoi irresponsible usage.

TRANSPORTING MOWER

•Stop mower properly.

•Place mower eck in its highest position.

•If transporting without the use of a tow vehicle, remove spark plug wire an place

where it cannot contact the spark plug.

SUGGESTED MOWING PRACTICES

•Operate mower engine at full throttle to assure the best cutting performance an

maximum material ischarge.

•Allow wet grass to ry. Clumps of wet grass will collect un er the mowing eck.

•Mowing shoul be starte with tow vehicle in low gear an increase only as safe

mowing con itions permit. This spee shoul not excee 5 mph.

•

The average lawn shoul be cut to approximately 2.5” uring the cool season an to

over 3” uring the hot months.

•For a healthier lawn an better aesthetics, your lawn shoul be mowe often an

after mo erate growth.

•When cutting high or ense grass areas go slowly. Some areas may nee to be

mowe twice. The secon cut shoul be at 90 egrees to the first, if possible.

•Mowing thick or high grass. Raise rear height crank han les to .5”-.75” a

bove the

other two han les.

•Creating a manicured lawn. Lower rear height crank han le to .25”-.5” below

front of eck. This allows grass bla es to be cut twice. It also continually cuts

clippings to pro uce a mulching effect.

GENERAL TROUBLE SHOOTING

•The mower is not cutting level.

oLevel eck, making sure the si e crank-han les are equal.

oCheck air pressure of all tires; make sure they are equal an to

manufacturers specifications.

oExamine bla es for amage, while mower engine is not running.

•The engine will not start.

o

Disengage bla es, turn toggle switch to “ON” position, check battery an all

other electrical connections, an inspect spark plug an wire.

oCheck for fuel in the engine.

•Engine runs poorly.

oSee engine manual.

oCheck throttle a juster.

oReplace fuel, clean fuel filter an fuel line.

IF PROBLEMS PERSIST HAVE A QUALIFIED MECHANIC SERVICE THE

MOWER. NEVER ATTEMPT TO MAKE AN ADJUSTMENT THAT YOU ARE

NOT SURE IS CORRECT. DOING SO CAN CAUSE OTHER PROBLEMS.

MOWER MAINTENANCE

GENERAL RECOMMENDATIONS

The warranty on this Trail Mower oes not cover items that have been subjecte to operator abuse or negligence.

To receive full value from the warranty, operator must maintain unit as instructe in this manual.

Some a justments will nee to be ma e perio ically to maintain your unit properly.

All a justments in this manual shoul be checke at least once each season.

BEFORE EACH USE

•Check engine oil level on a level surface. Check twice to insure an accurate rea ing.

•Check con ition of air filter; clean an replace as necessary.

•Check bla e operation; keep bla es in goo con ition.

•Check for loose fasteners an tighten them as nee e .

AFTER EACH USE

•Keep bla es sharp.

•Remove fresh grass clippings with gar en hose.

•Grass clippings can har en to the un ersi e shoul be scrape out with a putty knife.

•Keep flui s at proper levels.

•Cover unit to prevent rain or other ebris buil up. Definitely cover the engine.

BEFORE AND/OR AFTER EACH SEASON

•Replace the spark plug.

•Clean or replace the air filter.

•A new spark plug an clean air filter assure proper air-fuel mixture an help your engine run better an

last longer.

•Check bla es an belts for wear. Replace as necessary.

STORAGE RECOMMENDATIONS

CAUTION! Do not store engine in oors or other poorly ventilate area. Keep engine away from gas

appliances where fumes coul contact open flame, pilot lights, or sparks.

If engine is to be stored for 30 or more days, prepare unit as follows:

•Drain fuel outsi e into an approve container.

•Start engine properly an run until unit is out of fuel.

•Let engine cool.

•Remove remaining gasoline from carburetor an fuel tank to prevent gum eposits from forming

within the engine. Gum eposits can cause malfunction in the engine.

•Store mower with bla es isengage to prevent belts from being permanently stretche .

BLADE CARE AND SERVICE

For best results bla es must be kept sharp. The bla es can be sharpene with a few strokes of a file or grin ing

wheel. Do not attempt to sharpen bla es while they are on the mower. Disconnect spark plug wire before

servicing unit.

Important: Replace blades that have been damaged or deeply nicked.

Important: Check blade and spindle hardware on a regular basis to make sure nuts are tight.

Only a qualifie mechanic shoul be use for any

a justments, isassembly or other kin of repairs.

쇰;

FRAME DETAIL

When or ering replacement parts

*USE PAINT CODE: GT=GRAY TK=BLACK

Item # Description Part #

( 2C)3D/E2$ (*33(

3 C)3DE2 (*3(.

, 5)5,F*)(-G4 5H(*3

. I)C&6"F2">HE (*,,(J

D H)$C(F.)3/K(,F. (*3,-

- H)C (*33D

+ )$"&C(F. 5H3+.

* 5)5(F.)3/G4 5H(*/

L M)$N,F*)(-K3.,+K, (3..+

ONLY INCLUDED ON “CA” MODELS

CALIFORNIA COMPLIANT)

Item # Qty Description Part #

( . $)(/)3.K,F.6'G6 /3.3/,

3 3 H)22G (+(3+

, . 5)(/)3.51 /3.L//

. ( 22)3D/E,F(-1 (*33.

D 3 2)22 (*3(L

GAS TANK ASSEMBLY DETAIL

Items 19-22 are included in service part H7N

Item # Description Part #

( ,F.)(-55 5H(33

3  5H(LD

, H HL*

. &!' (3D.,J

D 2C --DJ

- DF*)((K+H 5H-3.

+ $'6 '((

* $$' --("J

L H)$CDF(-)(*K3(F. 5H-33

(/ 6)2 3((D3J

(( 6)2H 3((D,J

(3 5)$CDF(-)(* 5H(+/

(, )' 3/LD,J

(. DF*)((315 5HDLD

(D DF*=OK(?O(/E 5H(+*

(- $ --,1

(+ 2F" (*.,/

(* '" ' '+5

(L DF(-6"15 5H((+

3/ 6% '+%

3( 2" &$3(.

33 '"  '+5(J

3, H (/D+L

3. >"! (3D3-

3D &H (//,*

3- DF*=OK(?O(.E 5H(.L

3+ FFH C.(D+%

3* C (3D(,J

3L 26 5H(3-

,/ 2 /L.-(*

,( )C (+!(LD

5?$'?5 '=O ?O.(

Items 9-13 are included in kit 20954

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Swisher Rasenmäher Handbücher

Swisher

Swisher ZT17542 Bedienungsanleitung

Swisher

Swisher T1360T Bedienungsanleitung

Swisher

Swisher POL1250F Bedienungsanleitung

Swisher

Swisher 97-056001 Bedienungsanleitung

Swisher

Swisher ZT2766KP-CA Bedienungsanleitung

Swisher

Swisher QUADBOSS QBT18560 Bedienungsanleitung

Swisher

Swisher ZT2866A-CA Bedienungsanleitung

Swisher

Swisher ZT2760A Bedienungsanleitung

Swisher

Swisher WB80042F Bedienungsanleitung

Swisher

Swisher Z-MAX ZT2560 Bedienungsanleitung

Swisher

Swisher T11044, T11544, T10544BSPB, T1 Bedienungsanleitung

Swisher

Swisher L118-236001 Bedienungsanleitung

Swisher

Swisher L116-245001 Bedienungsanleitung

Swisher

Swisher TWR10532BS Bedienungsanleitung

Swisher

Swisher ZT13536, ZT17542B, ZT20050 Bedienungsanleitung

Swisher

Swisher ST60022Q Bedienungsanleitung

Swisher

Swisher ST50022STDQ Bedienungsanleitung

Swisher

Swisher POSTMASTER PST67522 Bedienungsanleitung

Swisher

Swisher Z-MAX ZT2560 Bedienungsanleitung

Swisher

Swisher WB942 Bedienungsanleitung

Swisher

Swisher QUADBOSS QBT1360 Bedienungsanleitung

Swisher

Swisher ZT2350 Bedienungsanleitung

Swisher

Swisher FC11544BS Bedienungsanleitung

Swisher

Swisher ZT2452A-CA Bedienungsanleitung

Beliebte Rasenmäher Handbücher anderer Marken

RHINO

RHINO 1958 Bedienungsanleitung

Wolf Garten

Wolf Garten Compact plus 40 B Bedienungsanleitung

Cub Cadet

Cub Cadet LTX 1045 Bedienungsanleitung

GGP ITALY SPA

GGP ITALY SPA CR/CS 434 SERIES Bedienungsanleitung

Challenge

Challenge CH18V2 Betriebsanleitung

TALEN TOOLS

TALEN TOOLS AVR HGM30 Bedienungsanleitung

DEWEZE

DEWEZE ATM-725 Bedienungsanleitung

Weed Eater

Weed Eater 180083 Bedienungsanleitung

Husqvarna

Husqvarna Poulan Pro PP185A42 Bedienungsanleitung

Better Outdoor Products

Better Outdoor Products Quick Series Bedienungsanleitung

Cub Cadet

Cub Cadet 23HP Z-Force 60 Betriebsanleitung

MTD

MTD 795, 792, 791, 790 Bedienungsanleitung

Toro

Toro Groundsmaster 3505-D Bedienungsanleitung

Dennis

Dennis FT 610 Bedienungsanleitung

MTD

MTD 126-220-000 Bedienungsanleitung

Toro

Toro 74806 Bedienungsanleitung

Stihl

Stihl RMA 443 PV Bedienungsanleitung

Yard-Man

Yard-Man 3700-0 Bedienungsanleitung