Swisher ZT2452A-CA Bedienungsanleitung

ZT2452A & ZT2452A-CA

24 HP - 52" CUT

CELEBRATING 65 YEARS OF INNOVATION

1602 CORPORATE DRIVE, WARRENSBURG, MISSOURI 64093

PHONE: (660) 747-8183 FAX: (660) 747-8650

MANUFACTURING QUALITY LAWN CARE EQUIPMENT SINCE 1945

OWNER'S MANUAL

STARTING SERIAL # L111-002001

17469 REV. 11-039

MADE IN THE

USA

The manufacturer’s warranty to the original consumer purchaser is:

This product is free from defects in materials and workmanship for a period of two (2) years

from the date of purchase by the original consumer purchaser.

As required by CFR § 1060.120, the fuel system related components, which have been

certified to this equipment by SAI are to be free of defects in material and workmanship for a

period of two (2) years from the date of purchase by the original consumer purchaser.

We will repair or replace, at our discretion, parts found to be defective due to materials or

workmanship. This warranty is subject to the following limitations and exclusions:

1) Engine Warranty

All engines utilized on our products have a separate warranty extended to them by the

individual engine manufacturer. Any engine service difficulty is the responsibility of the engine

manufacturer and in no way is Swisher or its agents responsible for the engine warranty. The

Briggs & Stratton Engine Service Hot-Line is 1-800-233-3723.

2) Commercial Use

This product is not intended for commercial use and carries no commercial warranty.

3) Limitation

This warranty applies only to products which have been properly assembled, adjusted, and

operated in accordance with the instructions contained within this manual. This warranty does

not apply to any product of Swisher, that has been subject to alteration, misuse,abuse,

improper assembly or installation, shipping damage, or to normal wear of the product.

4) Exclusions

Excluded from this warranty are normal wear, normal adjustments, normal maintenance, and

battery

(see battery section.)

In the event you have a claim under this warranty, you must return the product to an authorized

service dealer. All transportation charges, damage, or loss incurred during transportation of

parts submitted for replacement or repair under this warranty shall be borne by the purchaser.

Should you have any questions concerning this warranty, please contact us toll-free at 1-800-

222-8183.

The model number, serial number, date of purchase, and the name of the

authorized Swisher dealer from whom you purchased the mower will be needed before

any warranty claim can be processed.

THIS WARRANTY DOES NOT APPLY TO ANY INCIDENTAL OR CONSEQUENTIAL

DAMAGES AND ANY IMPLIED WARRANTIES ARE LIMITED TO THE SAME TIME

PERIODS STATED HEREIN FOR ALL EXPRESSED WARRANTIES.

Some states do not

allow the limitation of consequential damages or limitations on how long an implied warranty

may last, so the above limitations or exclusions may not apply to you. This warranty gives you

specific legal rights and you may have other rights, which vary from state-to-state. This is a

limited warranty as defined by the Magnuson-Moss Act of 1975.

LIMITED WARRANTY

17469 2 REV. 11-039

LIMITED WARRANTY

....................2

TABLE OF CONTENTS

..................3

INTRODUCTION

..........................4-5

General....................................4

Before Operating.....................4

Uncrating & Assembly.............5

TABLE OF CONTENTS

17469 3 REV. 11-039

SYMBOLS AND DECALS

.............

SAFETY INSTRUCTIONS

...............

General use & Safety rules.....7

Child Safety & Slope...............8

Precautions.............................8

CUSTOMER

RESPONSIBILITY

........................10-13

Operator Presence..................10

Tires.........................................10

Blade Maintenance..................10

Battery.................................10-11

V-Belts......................................12

Engine......................................12

Overall Unit Care......................12

Transporting Safety..................12

Specifications...........................12

Maintenance.............................13

WIRING SCHEMATIC

...............22-23

PARTS BREAKDOWN

...............24-35

TROUBLESHOOTING

................36-37

MOWER IDENTIFICATION

............38

WARRANTY RIGHTS

......................39

SWISHER HISTORY

........................40

SERVICE & ADJUSTMENTS

...........18

Adjust Deck Height..................18

Deck Level...............................18

Parking Brake..........................18

Deck Belt Replacement.......19-20

Hydro Belt Replacement.....19-20

Seat Adjustment.......................21

Travel Adjustment....................21

OPERATION

................................14-17

Features...............................14-15

Starting....................................16

Grass Height of Cut.................16

Parking Brake..........................16

Controls...................................17

CONGRATULATIONS!

Thank you for purchasing a Swisher Zero Turn mower. This machine is built for the greatest

efficiency and rapid mowing of large areas. Conveniently located controls and dual hydrostatic

transmissions regulated by steering levers, contribute to the machine’s performance.

This manual is a valuable document. Following the instructions for use, service,

maintenance, etc. can greatly increase the life-span of your machine .

GENERAL

In this operator’s manual, left and right, backward and forward are used in relation to the

normal operators position.

READ BEFORE OPERATING

This machine is constructed only for mowing grass on lawns and other free and even ground

without obstacles. This machine is not intended for commercial use. The manufacturer’s

directions concerning operation, maintenance, and repairs must be carefully followed.

This machine must only be operated, maintained, and repaired by persons that are familiar with

the machine’s special characteristics and who are well versed in safety instructions.

Accident prevention regulations, other general safety regulations, occupational safety rules,

and traffic regulations must be followed without fail.

Unauthorized modifications to the design of the machine may absolve the manufacturer from

liability for any resulting personal injury or property damage.

~Read the engine manufacturer’s operating and maintenance instructions.

~Read and observe all safety instructions on your mower and in the manual.

~Check the engine oil.

~Check the fuel cap to be sure that it is tight and in place.

~Know how to set the parking brake.

~Be sure the mower blades are turned off – PTO switch pushed down.

~Know how to stop the engine – Turn the key to off

~Know how to stop the unit – Return control handles to neutral

~Know the process of how to start the engine

INTRODUCTION

17469 4 REV. 11-039

NOTE:

If you have never used a Zero Turn mower

before, refer to the Operation Controls

section of this manual before attempting to

operate one for the first time.

UNCRATING AND ASSEMBLY

Tools Required

~2 - ½” Wrenches or ½” Socket with drive ratchet

~Tire pressure gauge

~Nail bar or claw hammer

~Wire snips

To Remove The Mower From The Crate

~Dispose of top and side panels of the crate.

~Remove loose parts and packing material.

~Cut any banding or strapping that may be holding the mower to the crate.

~Disengage spark plug wire and place where it cannot make a connection.

~Raise the mower deck to its highest position.

~Install steering levers. Remove the bolts from the control arms on the mower. Align the holes

in the lever with the holes in the control arms and attach with the bolts provided.

Make sure

both bolts on both handles are tight.

~Install the seat. Remove the bolts from the seat bracket that is attached to the frame. Line up

the seat bracket and reinstall the bolts. Securely tighten. Plug in the lead from the wiring

harness to the bottom of the seat. It may be necessary to move the seat via the seat slide to

gain access to pluging in the connector the seat switch.

~Disengage the parking brake by moving the lever to the "Disengage" position as indicated by

the decal.

~Open the transmission valves at the rear of the unit by pulling the release handles and

locking them in place.

SEE INSTRUCTION DECAL AT

THE REAR OF THE UNIT

~Carefully push the mower off the crate to a safe and level area.

~Check the engine oil. All engines are filled with oil and tested at the factory. Verify oil level

and add if necessary before starting engine.

SEE ENGINE OWNER’S MANUAL

~Check the battery. If the battery is put into service after the “month & year” of the date on the

battery, then it may need to be charged with a 12 volt charger for a minimum of 1 hour, but no

more than 2 hours at a rate of 6 to 10 amps.

~Attach battery cables to battery.

Always attach the positive terminal first.

Close the transmission valves at the rear of the unit.

SEE INSTRUCTION DECAL AT THE

REAR OF THE UNIT

~Reconnect the spark plug wire.

~Check tire pressure on all four wheels.

REFER TO UNIT SPECIFICATIONS TABLE

INTRODUCTION

17469 5 REV. 11-039

SYMBOLS AND DECALS

17469 6 REV. 11-039

SAFETY INSTRUCTIONS

17469 7 REV. 11-039

These instructions are for your safety. Read them carefully.

General Use

~Read all instructions in this operator’s manual and on the machine before starting it. Ensure that you understand

them and then abide by them.

~Learn how to use the machine and its controls safely and learn how to stop quickly. Also learn to recognize the

safety decals.

~Only allow the machine to be used by adults who are familiar with its use.

~Make sure nobody else is in the area of the machine when you start the engine, engage the drive, or run the

machine.

~Stop the machine if someone enters the work area.

~Clear the area of objects such as stones, toys, steel wire, etc. that may become caught in the blades and thrown

out.

~Do Not Use this machine without the Discharge Chute in place.

~Stop the engine and disconnect the spark plug before cleaning the discharge deck.

~Never take passengers. The machine is only intended for use by one person.

~Always look around before and during reversing maneuvers.

~Slow down before turning.

~Shut down the mower deck when not mowing.

~Be careful when rounding fixed objects, so that the blades do not hit them.

~Only operate the machine in daylight or other well-lit conditions.

~Keep the machine a safe distance from holes or other irregularities in the ground.

~Never use the machine if you are tired, if you have consumed alcohol, or if you are taking other drugs or

medications that can affect your vision, judgment, or coordination.

~Beware of traffic when working near or crossing a road.

~Never leave the machine unsupervised with the engine running. Always shut down the blades, engage the

parking brake, stop the engine, and remove the ignition key before leaving the machine.

~Never allow children or other persons not trained in the use of the machine to use or service it. Local laws may

regulate the age of the user.

~Make sure that you have first aid equipment close at hand when using the machine.

~Never use the machine when barefoot. Always wear protective shoes or boots.

SAFETY INSTRUCTIONS

17469 8 REV. 11-039

General Use Continued…

~Always wear approved protective glasses or a full visor when

assembling or driving.

~Ear Protection is recommended

~Never wear loose clothing that can get caught in moving parts.

Children:

~Serious accidents may occur if you fail to be on guard for children

in the area of the machine. Children are often attracted to the

machine and mowing work.

~Never assume that children will stay put where you last saw

them.

~Keep children away from the mowing area and under close

supervision by another adult.

~Shut off the machine if children enter the work area.

~Never allow a child to ride with you.

~Never allow children to operate the machine.

~Be extra cautious near corners, bushes, trees, or other objects

that block your view.

Slope Operation:

~Remove obstacles such as stones, tree branches, etc.

~Mow up and down, not side to side. Never drive the rider on

terrain that slopes more than 10 degrees.

~Avoid starting or stopping on a slope. If the tires begin to slip,

shut down the blades and drive slowly down the slope.

~Always drive evenly and slowly on slopes.

~Make no sudden changes in speed or direction.

~Avoid unnecessary turns on slopes, and if it proves necessary,

turn slowly and gradually downward, if possible.

~Watch for holes, ruts, or bumps. On uneven terrain, the machine

can tip more easily. Long grass can hide obstacles.

~Drive slowly and use small movements of the steering controls.

Do not mow wet grass. It is slippery, and the tires can loose their

grip, so that the machine slides.

~Do not try to stabilize the machine by putting a foot on the

ground.

Towing:

~This machine is rated at a 50 lb maximum tongue capacity and a

250 lb maximum towing capacity. Powered pull behind

accessories are not recommended for use with this vehicle.

SAFETY INSTRUCTIONS

17469 9 REV. 11-039

17469 10 REV. 11-039

CUSTOMER RESPONSIBILITIES

Operator Presence System

~Be sure the operator presence and interlock systems are working properly. If your mower does not function as described,

repair the problem immediately.

~The engine should not start unless the parking brake is engaged, the control handels are placed in their outward positions,

and the PTO (Blade Engagement – See OPERATION FEATURES section of this manual) switch is disengaged (pressed

down).

~When the engine is running, the operator should never leave the seat without first setting the parking brake and shutting off

the engine.

~When the engine is running and the PTO switch is engaged, any attempt by the operator to leave the seat without first

disengaging the PTO switch, should shut off the engine.

~When the engine is running and the control levers are rotated in, the operator should never attempt to leave the seat without

rotating the control levers out, shutting off the engine and engaging the parking brake.

~The PTO switch should never engage without the operator on the seat.

Tires:

~Maintain proper air pressure in all tires ( SEE SPECIFICATIONS section)

~Keep tires free of gasoline, oil, or insect control chemicals which can harm rubber.

~Avoid stumps, stones, deep ruts, sharp objects and other hazards that may cause tire damage.

Blade Maintenance:

~Stop the engine and remove ignition key for safety. Disconnect the spark plug wire. Wear heavy, thick gloves when holding

onto blade. Avoid the sharp edge of the blade.

~ For best results, mower blades must be kept sharp. Replace bent or damage blades.

~Safely raise front of mower. SEE WARNING

~Hold or block blade from turning.

~Loosen blade nut and remove blade.

~Replace blade, (SEE SPECIFICATIONS).

Battery:

To clean battery and terminals

~Remove terminal guard.

~Disconnect the BLACK battery cable first, then the RED battery cable and remove the battery.

~Rinse the battery with plain water and dry.

~Clean terminals and battery cable ends with wire brush until shiny.

~Coat terminals with grease or petroleum jelly

~Reinstall battery

~Reconnect the battery cables

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Swisher Rasenmäher Handbücher

Swisher

Swisher POL1250F Bedienungsanleitung

Swisher

Swisher ZT1436B, ZT18542, ZT2250 Bedienungsanleitung

Swisher

Swisher T11544 Bedienungsanleitung

Swisher

Swisher WB11542F Bedienungsanleitung

Swisher

Swisher ZT2766 Bedienungsanleitung

Swisher

Swisher FC10544BS Bedienungsanleitung

Swisher

Swisher Trim-N-Mow Bedienungsanleitung

Swisher

Swisher Trim-Max STD4422HO Bedienungsanleitung

Swisher

Swisher POL 10550 Bedienungsanleitung

Swisher

Swisher The Predator WB11524 Bedienungsanleitung

Swisher

Swisher ZT2452 Bedienungsanleitung

Swisher

Swisher ZT2454K Bedienungsanleitung

Swisher

Swisher ST60022Q Bedienungsanleitung

Swisher

Swisher AZ Series Bedienungsanleitung

Swisher

Swisher RT1250E Bedienungsanleitung

Swisher

Swisher T11544A Bedienungsanleitung

Swisher

Swisher ZT2866 Bedienungsanleitung

Swisher

Swisher POL10544C Bedienungsanleitung

Swisher

Swisher Predator WB924 Bedienungsanleitung

Swisher

Swisher POL11550 Bedienungsanleitung

Swisher

Swisher Z-MAX ZT2560 Bedienungsanleitung

Swisher

Swisher T1260, T1360, T1460 Bedienungsanleitung

Swisher

Swisher ZT2452A Bedienungsanleitung

Swisher

Swisher FC14560CL Gebrauchs- und Pflegehandbuch

Beliebte Rasenmäher Handbücher anderer Marken

RHINO

RHINO 1958 Bedienungsanleitung

Wolf Garten

Wolf Garten Compact plus 40 B Bedienungsanleitung

Cub Cadet

Cub Cadet LTX 1045 Bedienungsanleitung

GGP ITALY SPA

GGP ITALY SPA CR/CS 434 SERIES Bedienungsanleitung

Challenge

Challenge CH18V2 Betriebsanleitung

TALEN TOOLS

TALEN TOOLS AVR HGM30 Bedienungsanleitung

DEWEZE

DEWEZE ATM-725 Bedienungsanleitung

Weed Eater

Weed Eater 180083 Bedienungsanleitung

Husqvarna

Husqvarna Poulan Pro PP185A42 Bedienungsanleitung

Better Outdoor Products

Better Outdoor Products Quick Series Bedienungsanleitung

Cub Cadet

Cub Cadet 23HP Z-Force 60 Betriebsanleitung

MTD

MTD 795, 792, 791, 790 Bedienungsanleitung

Toro

Toro Groundsmaster 3505-D Bedienungsanleitung

Dennis

Dennis FT 610 Bedienungsanleitung

MTD

MTD 126-220-000 Bedienungsanleitung

Toro

Toro 74806 Bedienungsanleitung

Stihl

Stihl RMA 443 PV Bedienungsanleitung

Yard-Man

Yard-Man 3700-0 Bedienungsanleitung