Thermo Scientific 3950 Betriebsanleitung

Model 3950 and 3951

Forma 29 cu. ft. Reach-In Incubator

Operating and Maintenance Manual 7003950 Rev. 21

Visit us online to register your warranty

www.thermoscientific.com/labwarranty

Thermo Scientific

Manual Number 7003950

21 29318//IN-4272 12/14/12 Clarified usage on exploded drawing 3950-08-4 list ccs

20 28773/IN-4231 10/8/12 Updated Figure 1-6 to current ccs

19 28267 2/20/12 Added cautions for running high RH or temps ccs

18 24921/IN-3939 2/16/12 Removed accessory list - pg 7-2 ccs

17 27292/IN-4073 9/29/11 Updated component mount assy drawing - spacers (pg 8-7 & 8-8) ccs

16 27398/IN-4107 9/13/11 Updated float sw 360171 to 1900471 assy with pins 370397 - pg 8-1 ccs

15 25421/IN-3917 3/25/09 Corrected Mode Menu list pg 1-3 ccs

14 24975 10/31/08 Updated water specs on page 1-6 ccs

Preface

Reach-In Incubator i

* T/C is a thermal conductivity sensor.

** All units are 50/60 Hz.

Covered

Models CO2Sensor* Voltage**

3950 T/C 100-120

3951 T/C 200-230

Thermo Scientificii Reach-In Incubator

Preface

Important Read this instruction manual. Failure to read, understand and follow the instructions in this manual

may result in damage to the unit, injury to operating personnel, and poor equipment performance. s

Caution All internal adjustments and maintenance must be performed by qualified service personnel. s

Warning If the incubator is not used in the manner specified in this operating manual, the protection provided

by the equipment design may be impaired. s

Caution When operating this unit under high temperatures and/or relative humidity (RH), caution must be

observed when the unit is shut down, unexpectedly or by choice. Condensate can form on the interior of the

chamber as it cools. This includes the heating element surfaces. Heavy condensate can bridge the ceramic

insulators and cause a temporary electrical short to ground. This electrical circuit is protected by a circuit breaker.

However, to avoid this contingency if these conditions occur, open the door of the unit and allow it to stand

open until the water vapor disperses. s

Material in this manual is for information purposes only. The contents and the product it describes are subject to

change without notice. Thermo Fisher Scientific makes no representations or warranties with respect to this

manual. In no event shall Thermo be held liable for any damages, direct or incidental, arising out of or related to

the use of this manual.

Thermo Scientific Reach-In Incubator iii

Preface

Important operating and/or maintenance instructions. Read the accompanying text carefully.

Potential electrical hazards. Only qualified persons should perform procedures associated with this

symbol.

Equipment being maintained or serviced must be turned off and locked off to prevent possible injury.

Hot surface(s) present which may cause burns to unprotected skin, or to materials which may be

damaged by elevated temperatures.

Marking of electrical and electronic equipment, which applies to electrical and electronic equipment

falling under the Directive 2002/96/EC (WEEE) and the equipment that has been put on the market

after 13 August 2005.

This product is required to comply with the European Union’s Waste Electrical & Electronic

Equipment (WEEE) Directive 2002/96/EC. It is marked with the WEEE symbol. Thermo Fisher

Scientific has contracted with one or more recycling/disposal companies in each EU Member State

European Country, and this product should be disposed of or recycled through them. Further

information on Thermo’s compliance with this directive, the recyclers in your country and information

on Thermo Scientific products will be available at www.thermofisher .com.

4Always use the proper protective equipment (clothing, gloves, goggles, etc.)

4Always dissipate extreme cold or heat and wear protective clothing.

4Always follow good hygiene practices.

4Each individual is responsible for his or her own safety.

Thermo Scientificiv Reach-In Incubator

Preface

Do You Need Information or Assistance on

Thermo Scientific Products?

If you do, please contact us 8:00 a.m. to 6:00 p.m. (Eastern Time) at:

1-740-373-4763 Direct

1-800-438-4851 Toll Free, U.S. and Canada

1-877-213-8051 FAX

http://www.thermoscientific.com Internet Worldwide Web Home Page

service.led.marietta@thermofisher.com Tech Support Email Address

Certified Service Web Page

Thermo Fisher Scientific

401 Millcreek Road, Box 649

Marietta, OH 45750

Our staff can provide information on pricing and give you quotations. We can

take your order and provide delivery information on major equipment items or make

arrangements to have your local sales representative contact you. Our products are listed on the

Internet and we can be contacted through our Internet home page.

Our staff can supply technical information about proper setup, operation or

troubleshooting of your equipment. We can fill your needs for spare or replacement parts or

provide you with on-site service. We can also provide you with a quotation on our Extended

Warranty for your Thermo Scientific products.

Whatever Thermo Scientific products you need or use, we will be happy to discuss your

applications. If you are experiencing technical problems, working together, we will help you

locate the problem and, chances are, correct it yourself...over the telephone without a service

call.

When more extensive service is necessary, we will assist you with direct factory trained

technicians or a qualified service organization for on-the-spot repair. If your service need is

covered by the warranty, we will arrange for the unit to be repaired at our expense and to your

satisfaction.

Regardless of your needs, our professional telephone technicians are available to assist you

Monday through Friday from 8:00 a.m. to 6:00 p.m. Eastern Time. Please contact us by

telephone or fax. If you wish to write, our mailing address is:

International customers, please contact your local Thermo Scientific distributor.

Sales Support

Service Support

www.unitylabservices.com

Thermo Scientific Reach-In Incubator v

Preface

Warranty Notes

Information You Should Know Before Requesting Warranty Service

•Locate the model and serial numbers. Aserial tag is located on the unit itself.

•For equipment service or maintenance, or with technical or special application inquiries, contact Technical

Services at 1-800-438-4851 or 1-740-373-4763 (USA and Canada). Outside the USA, contact your local

distributor.

Repairs NOT Covered Under Warranty

•Calibration of control parameters. Nominal calibrations are performed at the factory; typically ±1°Cfor

temperature, ±1% for gases, and ±5% for humidity. Our service personnel can provide precise calibrations as

abillable service at your location. Calibration after awarranty repair is covered under the warranty.

•Damage resulting from use of improper quality water, chemicals or cleaning agents detrimental to

equipment materials.

•Service calls for improper installation or operating instructions. Corrections to any of the following

are billable services:

1) electrical service connection

2) tubing connections

3) gas regulators

4) gas tanks

5) unit leveling

6) room ventilation

7) adverse ambient temperature fluctuations

8) any repair external to the unit

•Damage resulting from accident, alteration, misuse, abuse, fire, flood, acts of God, or improper

installation.

•Repairs to parts or systems resulting from unauthorized unit modifications.

•Any labor costs other than that specified during the parts and labor warranty period, which may

include additional warranty on CO2sensors, blower motors, water jackets, etc.

Reach-In Incubator viThermo Scientific

Table of Contents

Installation and Start-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-1

Control Panel Keys, Displays, & Indicators . . . . . . . . . . . . . . . . . . . .1-2

Keypad Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-3

Unit Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-4

Preliminary Cleaning and Disinfecting . . . . . . . . . . . . . . . . . . . . . .1-4

Installing the Shelves . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-5

Leveling the Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-5

Attaching the Drain Lines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-5

The Water Supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-6

Filling the Humidity Reservoir . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-6

Connecting the Unit to Electrical Power . . . . . . . . . . . . . . . . . . . . .1-7

Connecting the CO2Gas Supply . . . . . . . . . . . . . . . . . . . . . . . . . .1-8

Incubator Start-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-9

Setting the Operating Temperature . . . . . . . . . . . . . . . . . . . . . . . . .1-9

Setting the Overtemp Setpoint . . . . . . . . . . . . . . . . . . . . . . . . . . .1-10

Setting the CO2Setpoint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-10

Calibration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-1

Calibrating the Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-1

Calibrating the CO2System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-2

Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-1

Disable the ADD WATER Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . .3-1

Turn All Audible Alarms ON/OFF . . . . . . . . . . . . . . . . . . . . . . . . . .3-1

Set an Access Code . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-2

Set a Low Temp Alarm Limit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-2

Enable Temp Alarms to Trip Relay Contacts . . . . . . . . . . . . . . . . . . .3-3

Set Low CO2Alarm Limit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-3

Set High CO2Alarm Limit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4

Enable CO2Alarms to Trip Relay Contacts . . . . . . . . . . . . . . . . . . . .3-4

Set New Zero No. for New CO2Sensors . . . . . . . . . . . . . . . . . . . . . .3-5

Set New Span No. for CO2Sensors . . . . . . . . . . . . . . . . . . . . . . . . . .3-5

Enable the High Humidity Feature . . . . . . . . . . . . . . . . . . . . . . . . . .3-6

Select a Primary Tank w/ Gas Guard Option . . . . . . . . . . . . . . . . . . .3-6

Disable the Gas Guard System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-7

Set RS485 Address . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-7

Section 1

Section 2

Section 3

vii Reach-In Incubator Thermo Scientific

Alarms . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1

Sensor Fault Alarms . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-2

Preventive Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-3

Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-1

Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-1

Cleaning the Glass Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-1

Cleaning the Humidity Reservoir . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-2

Replacing the Power Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-3

Discarding/Removing Incubator from Service . . . . . . . . . . . . . . . . . .5-3

FactoryOptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6-1

Connect the Remote Alarm Contacts . . . . . . . . . . . . . . . . . . . . . . . . .6-1

Connect the RS485 Interface (P/N 190523) . . . . . . . . . . . . . . . . . . .6-2

Connect Analog Output Boards (P/N 190512, 190543, & 190544) .6-3

CO2Gas Guard (P/N 1900000) . . . . . . . . . . . . . . . . . . . . . . . . . . . .6-4

Connect CO2Gas Supplies . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6-5

De-activate Gas Guard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6-5

Operation of CO2Gas Guard . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6-5

Inner Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6-6

Shaker Support Shelves . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6-6

Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7-1

Spare Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8-1

Assembly Drawings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8-2

Exploded Parts Drawings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8-3

Electrical Schematics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9-1

Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-1

Table of Contents

Section 4

Section 5

Section 6

Section 8

Section 7

Section 9

Section 10

Reach-In Incubator 1-1Thermo Scientific

Section 1 Installation and Start-Up

Figure 1-1. Front View Figure 1-2. Side View

Figure 1-3. BackView

Figure 1-4. Top View

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Thermo Scientific Zubehör Handbücher

Thermo Scientific

Thermo Scientific Thermo Fisher 3900 Series Betriebsanleitung

Thermo Scientific

Thermo Scientific 2862 Betriebsanleitung

Thermo Scientific

Thermo Scientific 8000DH Series Bedienungsanleitung

Thermo Scientific

Thermo Scientific 3010 Betriebsanleitung

Thermo Scientific

Thermo Scientific Unity Lab Services 3307 Bedienungsanleitung

Thermo Scientific

Thermo Scientific BB 150 Bedienungsanleitung

Thermo Scientific

Thermo Scientific Heracell 150i Bedienungsanleitung

Thermo Scientific

Thermo Scientific 61-12C Service-Handbuch

Thermo Scientific

Thermo Scientific Phadia 100 Bedienungsanleitung

Thermo Scientific

Thermo Scientific Heracell 240i Bedienungsanleitung

Thermo Scientific

Thermo Scientific 8000DH Series Betriebsanleitung

Thermo Scientific

Thermo Scientific 314 Bedienungsanleitung

Thermo Scientific

Thermo Scientific 61-12N-64P Service-Handbuch

Thermo Scientific

Thermo Scientific AquaSensors AnalogPlus Bedienungsanleitung

Thermo Scientific

Thermo Scientific 3554-35A Montage- und Wartungsanleitung

Thermo Scientific

Thermo Scientific Cytomat 2 Bedienungsanleitung

Thermo Scientific

Thermo Scientific Smart-Vue Gebrauchs- und Pflegehandbuch

Thermo Scientific

Thermo Scientific 3110 Betriebsanleitung

Thermo Scientific

Thermo Scientific Lab-Line Imperial 3 Betriebsanleitung

Thermo Scientific

Thermo Scientific 60-12 Service-Handbuch

Thermo Scientific

Thermo Scientific 370 Betriebsanleitung

Thermo Scientific

Thermo Scientific IMH 60 Bedienungsanleitung

Thermo Scientific

Thermo Scientific 3403 Bedienungsanleitung

Thermo Scientific

Thermo Scientific HERACELL VIOS 160i Bedienungsanleitung

Beliebte Zubehör Handbücher anderer Marken

Hillco

Hillco 2810 Bedienungsanleitung

Siemens

Siemens QSA2700D Bedienerhandbuch

Contours

Contours ZY024 Bedienungsanleitung

Saivod

Saivod VS621 Bedienungsanleitung

Virtuox

Virtuox VirtuCLEAN 2.0 Bedienungsanleitung

SCE

SCE ENVIRO-THERM SCE-TE170B24VSS Bedienungsanleitung

Z-Wave

Z-Wave HSD-200Z Bedienungsanleitung

turck

turck FMX-IM-2UPLI63FX Bedienungsanleitung

Decagon Devices

Decagon Devices 10HS Bedienungsanleitung

UPPAbaby

UPPAbaby Cup Holder Bedienungsanleitung

Elko

Elko SmartSensor Leakage Wireless Bedienungsanleitung

Grizzly

Grizzly H8371 Bedienungsanleitung

Panasonic

Panasonic HG-T Series Bedienungsanleitung

IFM Electronic

IFM Electronic Efector 250 Series Referenzhandbuch

DigiDesign

DigiDesign 888/24 I/O Bedienungsanleitung

PROZIS

PROZIS QUAY Bedienungsanleitung

patagonia

patagonia PSI Vest Bedienungsanleitung

SFC Energy

SFC Energy EFOY GO! Bedienungsanleitung