Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

USER MANUAL

TC30

USER MANUAL

100817-16 TC30_D.Ver 2 5056.430D

MODEL TC30

SERIES D - Version 2

MODULAR DIRECT VENT

FIREPLACE

WARNING: If the information in these

instructions is not followed exactly, a re or

explosion may result causing property damage,

personal injury or death.

FOR YOUR SAFETY

Installation and service must be performed

by a qualied installer, service agency or the

gas supplier.

WHAT TO DO IF YOU SMELL GAS

• Donottrytolightanyappliance.

• Donottouchanyelectricalswitch.

•Donotuseanyphoneinyourbuilding.

• Immediatelycallyourgassupplierfrom

a neighbour’s phone. Follow the gas

supplier’s instructions.

• Ifyoucannotreachyourgassuppliercall

the re department.

Do not store or use gasoline or other ammable

vapours and liquids in the vicinity of this or

any other appliance.

This appliance may be installed in an aftermarket

permanently located,manufactured home (USA only)

or mobile home, where not prohibited by local codes.

This appliance is only for use with the type of gas

indicated on the rating plate. This appliance is

not convertible for use with other gases, unless a

certied kit is used.

This appliance is suitable for installation in a

bedroom or bed sitting room.

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

Visit www. townandcountryﬁreplaces.net for the most recent version of this manual

HOT GLASS WILL CAUSE

BURNS.

DO NOT TOUCH GLASS UNTIL

COOLED.

NEVER ALLOW CHILDREN TO

TOUCH GLASS.

DANGER

A barrier designed to reduce the risk of burns from the

hot viewing glass is provided with the appliance and

shall be installed for the protection of children and

other at-risk individuals.

2TC30-D ver2_100817-16

5056.430D

Table of Contents

Caution .....................................................................3

Safety .......................................................................3

Lighting Instructions .................................................4

First Fire ....................................................................5

Special Operator Note ..............................................5

Remote Control Operation .......................................5

Fireplace Description...........................................7

Transmitter (Remote Control with LCD Display)..7

IFC Module ..........................................................7

Operating Procedure ...........................................7

Using the Remote Control Transmitter ................8

Temperature indication Display ...........................8

Turn on the Fireplace...........................................8

Turn off the Fireplace...........................................8

Manual Bypass of the Remote Fireplace.............8

Instructions for enabling the

Thermostat function for Canadian users ..................9

Remote Flame Control ........................................9

Smart Thermostat (Transmitter Operation)

if enabled.............................................................9

Room Thermostat (Transmitter Operation) ..........9

Remote dimmer control (Light)..........................10

Continuous Pilot/Intermittent Pilot

(CPI/IPI) selection ..............................................10

Key Lock............................................................10

Low Battery Power Detection............................10

Transmitter.........................................................10

Receiver.............................................................10

Linking Remote Handset and Apple®Device

to Fireplace .............................................................11

Step 1: Procedure for linking / pairing

wall switch to replace ......................................11

Step 2: Procedure for linking / pairing the wall

switch to remote handset..................................12

Step 3: Optional procedure for linking / pairing

a BlueTooth®enabled apple mobile device

to the replace (iOS only). .................................12

Using the TC Fire app........................................13

Maintenance ...........................................................14

Glass Panel:.......................................................14

Annual Inspection:.............................................14

Periodically: .......................................................14

Warranty ...................................................................15

FOR YOUR SAFETY - Do not install or operate your Town & Country

replace without rst reading and understanding this manual. Any

installation or operational deviation from the following instructions voids

the Town & Country Fireplaces Warranty and may prove hazardous.

This appliance and its individual shut off valve must be disconnected

from gas supply piping system during any pressure testing of that sys-

tem at test pressures in excess of 1/2 psig (3.5 kPa).

This appliance must be isolated from the gas supply piping system by

closing its individual manual shut off valve during any pressure testing of

the gas supply piping system at test pressures equal to or less than 1/2

psig (3.5 kPa).

Note: When lit for the rst time, the appliance will emit a slight odour

for a couple of hours. This is due to the curing of paints, sealants

and lubricants used in the manufacturing process. This condition is

temporary. Open doors and windows to ventilate area. Smoke and

fumes caused by the curing process may cause discomfort to some

individuals.

Do not use the replace if any part has been under water. Immediately

call a qualied service technician to inspect the replace and to replace

any part of the control system and any gas control which has been

under water.

Due to high temperatures, this gas appliance should be located out of trafc and away from furniture and

draperies.

Children and adults should be alerted to the hazards of high surface temperatures and should stay away to

avoid burns or clothing ignition.

Young children should be carefully supervised when they are in the same room as the appliance. Toddlers,

young children, and others may be susceptible to accidental contact burns. A physical barrier is recom-

mended if there are at-risk individuals in the house. To restrict access to a replace or stove, install an adjust-

able safety gate to keep toddlers, young children, and other at-risk individuals out of the room and away from

hot surfaces. Clothing or other ammable material should not be placed on or near the appliance.

Any grill, panel or door removed for servicing the unit must be replaced prior to operating. Failure to do so

may create a hazardous condition.

Installation and repair should be done by a qualied service person. The appliance should be inspected

before use and at least annually by a professional service person. More frequent cleaning may be required

due to excessive lint from carpeting, bedding material, etc. It is imperative that control compartments, burners

and circulating air passageways of the appliance be kept clean.

It is our policy that no responsibility is assumed by the Company or by any of its employees or representa-

tives for any damages caused by an inoperable, inadequate, or unsafe condition which is the result, either

directly or indirectly, of any improper operation or installation procedures.

This appliance must not be connected to a chimney ue serving a separate solid fuel burning appliance.

We recommend that our gas

hearth products be installed and

serviced by professionals who are

certied in the United States by the

National Fireplace Institute®(NFI)

as NFI Gas Specialists

TC30-D ver2_100817-16 5056.430D

TC30-D ver2_100817-16

Caution

Safety

FOR YOUR SAFETY READ BEFORE LIGHTING

LIGHTING INSTRUCTIONS

TO TURN OFF GAS APPLIANCE

WARNING:

If you do not follow these instructions exactly, a

fire or explosion may result causing property damage,

personal injury or loss of life.

A.This appliance is equipped with an ignition device which

automatically lights the pilot. Do not try to light the pilot by hand.

B.BEFORE LIGHTING smell all around the appliance area for gas. Be

sure to smell next to the floor because some gas is heavier than

air and will settle on the floor.

WHAT TO DO IF YOU SMELL GAS:

- Do not try to light any appliance.

- Do not touch any electric switch; do not use any phone in your

building.

- Immediately call your gas supplier from a neighbour's phone. Follow

the gas supplier's instructions.

- If you cannot reach your gas supplier, call the fire department.

C.Use only your hand to push in or turn the gas control knob. Never use

tools. If the knob will not push in or turn by hand, don't try to repair it,

call a qualified service technician. Force or attempted repair may

result in a fire or explosion.

D.Do not use this appliance if any part has been under water.

Immediately call a qualified service technician to inspect the

appliance & to replace any part of the control system & any gas

control which has been under water.

1. STOP! Read the safety information above on this label.

2. This appliance is equipped with an ignition device which

automatically lights the pilot. Do not try to light the pilot by hand.

3. Push the "On/ Off" switch to turn the fireplace ON.

- If the burner does light go to step 6.

- If the burner does not light, complete steps 4 through 5.

- If the burner will not light or stay lit after several tries, push the

"On/ Off" switch for the fireplace to OFF, turn off all electric power

to the fireplace and call your service technician or gas supplier.

Note: Sufficient time must be allowed for air to escape from lines if

the unit is being lit for the first time.

4. Push the "On/ Off" switch to the fireplace Off.

5. Allow sufficient length of time (minimum 5 minutes) for any gas in the

combustion chamber to escape. If you still smell gas, STOP! Follow

"B" in the safety information above on this label. If you don't smell

gas, go to step 3.

6. Set fireplace to desired setting by using hand held remote.

Push the "on/ off" switch to the "Off" position.

2. Turn off all electric power to the appliance and remove backup

batteries if service is to be performed or for extended shutdown.

Due to high surface temperatures, keep children, clothing and furniture away. Keep burner and control compartment clean. See installation and

operating instructions accompanying the appliance.

A cause de la temperature elevee des parios, tenir eloignes les enfants, les vetements et les meubles. Maintenir propres le bruleur et le

compartiment de commande. Voir les instructions relatives a l'installation et au fonctionnement qui accompagnent l'appareil.

CAUTION:

Hot while in operation. Do not touch. Severe burns may result. Keep children,

clothing, furniture, gasoline and other liquids having flammable vapours away. Keep burner and control

compartment clean. See installation and operating instructions accompanying the appliance.

ATTENTION:L'appareil est chaud lorsqu'il fonctionne. Ne pas toucher l'appareil. Risque de

brûlures graves. Serveiller les enfants. Garder les vêtements, le meubles, l'essence ou autres liquides

produisant des vapeurs infl ammables loin de l'appareil. S'assurer que le brûleur et le compartiment des

commandes sont propres. Voir les instructions d'installation et d'utilisation qui accompagnent l'appareil.

090713

5051.185

GBWY

4TC30-D ver2_100817-16

5056.430D

Lighting Instructions

First Fire

When lit for the rst time, the replace will emit a slight odor for a couple of hours. This is due to the cur-

ing of paints, sealants and lubricants used in the manufacturing process. This condition is temporary. Open

doors and windows to ventilate area. Odors caused by the curing process may cause discomfort to some

individuals.

It is normal for replaces fabricated of steel to give off some expansion and/or contraction noises during the

start up or cool down cycle. Similar noises are found with your furnace heat exchanger or cook stove oven.

Remote Control Operation

Blue back lit LCD display

ON/OFF Key

THERMOSTAT Key

UP/DOWN Arrow Key

MODE Key

NOTE: Fireplace may

take up to 30 seconds

to ignite each time the

“ON” button has been

selected.

Special Operator Note

Figure 1: Proame 2 handset.

TC30-D ver2_100817-16 5056.430D

TC30-D ver2_100817-16

OFF

SMART

MAX MAX

KEY LOCK

LOW BATTERY ALARM

ROOM

TEMPERATURE

CPI MODE

DIMMER ONFLAME LEVEL

OFF / ON

SET POINT:

TEMPERATURE/LEVEL/STATE

THERMOSTAT OFF/

ON/SMART

TRANSMISSION

* SEE NOTICE REGARDING

THERMOSTAT USE

Attention!

• Turn off the main gas supply for the appliance during installation or

maintenance of the receiver/module device.

• Turn off main gas supply for the appliance prior to removing or rein-

serting the batteries.

• In case of remote control malfunction, turn off the replace using

the “on/off” main switch located on the wall.

• For installation/maintenance, turn off the replace at the on/off

switch located on the wall and at the replace power supply circuit

breaker.

NOTICE: The thermostat function is disabled by default. Thermostat function is not

permissible in the USA but is permissible in Canada. (See “Instructions for enabling

the Thermostat function for Canadian users” on page 9)

Figure 2: Proame 2 LCD screen details.

6TC30-D ver2_100817-16

5056.430D

Fireplace Description

The Proame 2 Remote Control Fireplace consists of three elements:

1. Proame 2 Remote Control Transmitter.

2. Proame Integrated Fireplace Control (IFC Module) board and a wiring harness to connect the IFC to the gas

valve and stepper motor.

3. Wall mounted Remote Control Receiver (Figure 3) & (Figure 4).

Transmitter (Remote Control with LCD Display)

The Proame 2 Transmitter uses a streamline design with a simple key layout and an informative LCD display

(Figure 2). The remote control transmitter is powered by 3 AAA batteries. A mode key is provided to index

between the features and a thermostat key is used to turn on/off or index through thermostat functions (Figure

1).

IFC Module

The Proame 2 Integrated Fireplace Control (IFC) module is a device that allows automatic ignition and pilot

ame supervision and commands the functions of the replace. It’s congured to control the ON/OFF main

burner operation, giving the choice of both IPI (intermittent pilot ignition), and CPI (continuous pilot ignition)

modes. The Proame 2 IFC module controls and connects directly to the pilot assembly and the automatic

valve using low electric power.

The IFC module can be powered by both an AC power supply, and battery pack for back up. The Proame

2 offers the added ability to control the comfort fan speed from OFF through six (6) speeds, and a remotely

actuated auxiliary outlet and a dimmable light outlet. The external batteries can provide DC power to the IFC

allowing the batteries to be used only when line power is interrupted or lost, and if the replace does not use a

combustion fan.

Operating Procedure

The replace must rst be linked to the wall switch. Then the wall switch must be linked to the remote hand-

set. Instructions for both of these procedures including instructions for enabling a Blue Tooth® enabled apple

mobile device to the replace, (See “Linking Remote Handset and Apple® Device to Fireplace” on page 11).

TC30-D ver2_100817-16 5056.430D

TC30-D ver2_100817-16

Program button

Using the Remote Control Transmitter

Temperature indication Display

With the remote control transmitter in the “OFF” position, press the thermostat

and mode keys at the same time. Look at the LCD screen on the remote control

transmitter to verify that a C or F is visible to the right of the room temperature

display (Figure 7) & (Figure 8).

Turn on the Fireplace

With the replace OFF, press the ON/OFF key on the remote control transmitter.

The remote control transmitter display will show the active icons on the screen.

At the same time the wall switch will activate the replace via the IFC module. A

single “beep” from the IFC module will conrm reception of the command.

Turn off the Fireplace

With the replace ON, press the ON/OFF key on the remote control transmit-

ter. The remote control transmitter LCD display will only show the room tem-

perature (Figure 7) & (Figure 8). At the same time the IFC module will turn off

the replace. A single “beep” from the IFC module conrms reception of the

command.

Manual Bypass of the Remote Fireplace

If the batteries of the remote control transmitter are low or depleted, the re-

place can be turned off manually using ON/OFF switch located on Town &

Country wall switch. This will bypass the remote control transmitter.

Figure 3: Wall switch -

electronics side.

Figure 4: Wall switch -

battery side.

Figure 5: T&C Wall switch

plate.

Figure 6: Proame 2 remote

control battery bay.

Figure 7: Display in

fahrenheit.

Figure 8: Display in celcius.

Instructions for enabling the Thermostat function for Canadian users

8TC30-D ver2_100817-16

5056.430D

Remote Flame Control

The Proame 2 has six (6) ame levels (Figure 9). With the replace

turned on, and the ame level at maximum height, press the down arrow

key once to reduce the ame height by one step until the ame is turned

off.

The up arrow key will increase the ame height each time it is pressed. If

the up arrow key is pressed while the replace is on but the ame is off,

the ame will come on in the high position. A single “beep” will conrm

reception of the command.

Smart Thermostat (Transmitter Operation) if enabled

The Smart Thermostat function adjusts the ame height in accordance

to the difference between the set point and the room temperatures. As

the room temperature gets closer to the set point, the Smart Function

will modulate the ame down. If the room temperature is cool, the Smart

Function will modulate the ame up. To activate this function, press the

THERMOSTAT button (Figure 1) until the word “SMART” appears to the

right of the temperature icon (Figure 11). To adjust the set point, press

the up or down arrow buttons until the desired set point temperature is

displayed on the LCD screen of the remote control transmitter (Figure

11) & (Figure 12).

Flame Off

Flame level 5

Flame level Max

Flame level 1

Figure 9: Flame level control.

Figure 10: Room temperature. Figure 11: Smart ame

function MAX temp.

Figure 12: Smart ame

adjusting temperature.

The thermostat key (Figure 1) on the remote handset needs to be held down. Keep it pressed down and

remove one of the three batteries from the remote handset. Simply re-install the battery that was removed and

the feature is activated. Use the same procedure to disable the thermostat function.

Instructions for enabling the Thermostat function for Canadian users

Room Thermostat (Transmitter Operation)

The remote control transmitter can operate as a room thermostat. The thermostat can be set to a desired

temperature to control the comfort level in a room. To activate this function, press the thermostat key (Figure

1), the LCD display on the remote control transmitter will change to show that the room thermostat is “ON”

and the set temperature is now displayed (Figure 10). To adjust the set point, press the up or down arrow keys

until the desired set point temperature is displayed on the LCD screen of the remote control transmitter.

TC30-D ver2_100817-16 5056.430D

TC30-D ver2_100817-16

Low Battery Power Detection

Transmitter

The life span of the remote control batteries depends on various factors: quality of

the batteries used, the number of ignitions of the Heater, the number of changes to

the room thermostat set point, etc.

When the remote batteries are low, an icon will appear on the LCD display of the

remote (Figure 16) before all battery power is lost. When the batteries are replaced

this icon will disappear.

Receiver

The life span of the IFC module batteries depends on various factors: quality of the batteries used, the num-

ber of ignitions of the Heater, the number of changes to the room thermostat set point, etc.

When the IFC batteries are low, a “double-beep” will be emitted from the IFC module when it receives a com-

mand from the remote. This is an alert for a low battery condition for the IFC board. When the batteries are

replaced, a single “beep” will be emitted from the IFC module when a key is pressed.

Key Lock

This function will lock the keys to avoid unsupervised operation. To activate this func-

tion, press the MODE and UP keys at the same time (Figure 1).The lock icon will

appear (Figure 15).

To de-activate this function, press the MODE and UP key at the same time.

Remote dimmer control (Light)

The auxiliary function controls the AUX power outlet by the

dimmable light control. To activate this function use the

Mode Key (Figure 1) to index to the light bulb icon (Figure

13). The intensity of the output can be adjusted through six

(6) levels. Use the Up/Down Arrow Keys (Figure 1) adjust the

output level. A single “beep” will conrm reception of the

command.

Continuous Pilot/Intermittent Pilot (CPI/IPI) selection

With the system in the “OFF” position, press the Mode Key

(Figure 1) to index to the CPI mode icon (Figure 14). Pressing

the Up Arrow Key will activate the Continuous Pilot Ignition

mode (CPI). Pressing the Down Arrow Key will return to IPI. A

single “beep” will conrm the reception of the command.

Figure 13: Dimmer light control.

Figure 14: IPI - CPI control.

Figure 15: Key lock.

Figure 16: Low battery.

10 TC30-D ver2_100817-16

5056.430D

Andere Handbücher für TC30 Black Diamond

Inhaltsverzeichnis

Andere Town & Country Fireplaces Kamin im Innenbereich Handbücher

Town & Country Fireplaces

Town & Country Fireplaces TC54.CE2 Series C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42.NG01 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces T120.RHKIT Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces D2 Series Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36STD2 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCW120 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.CSTE3 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54 SERIES DMODULAR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54DST Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54 SERIES DMODULAR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces Series C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 SEE-THRUC SERIES Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54STOK Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54NG04.C2 Technisches Handbuch

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Gebrauchsanweisung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54ST SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.D Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch