Travis Industries 564 HO Bedienungsanleitung

564 HO Ember-Fyre Burner and Log Set

Installation Instructions (sku 96900116)

Page 1 of 9 17601655 — 11/14/12 © Travis Industries, Inc.

Packing List

Burner Assembly

Grate Assembly

Log Set

Intake Restrictor



Air Deflectors, NG and LP

(2) Andiron Clips

(2) Rivets for burner

Burner Support Bracket

Bag of embers

Installation Tips

If using propane (LP), convert the appliance before installing the burner.

Make sure to have the firebacks for the appliance on hand. They will be

installed during burner installation.

Installation Warnings

The logs are fragile, especially after being exposed to heat.

Make sure the gas control valve is OFF and the heater is cool before

servicing.

Failure to position the parts in accordance with these diagrams or failure to

use only parts specifically approved with this appliance may result in

property damage or personal injury.

The burner must be correctly positioned before installing the logs. Make sure

the burner is fully seated and the pilot is properly aligned.

Andiron Clips

NOTE: Two andiron clips are included for

those installations using andirons. See the

directions to the right to install.

5/32 Hex

Wrench

11/32" Nutdriver

564 HO Ember-Fyre Burner and Log Set

Installation Instructions (sku 96900116)

Page 2 of 9 17601655 — 11/14/12 © Travis Industries, Inc.

Log Set Installation

1. Remove both accent lights from the brackets and place them on the firebox floor, as shown below.

2. Install the burner support bracket, as shown below.

NOTE: The notch in the bracket faces inward.

3. Install the intake restrictor as shown below. Use the screws pre-installed on the rear wall of the firebox. The

intake restrictor is located behind the accent lights, on the rear wall of the firebox. Set the intake restrictor to

the correct setting for the vent configuration; see the owner’s manual for details.

564 HO Ember-Fyre Burner and Log Set

Installation Instructions (sku 96900116)

Page 3 of 9 17601655 — 11/14/12 © Travis Industries, Inc.

4. Install the firebacks as shown below.

Place the rear fireback in place.

Remove the clip located on the

firebox ceiling near the front (both

sides). The side fireback clip has

a keyhole slot. It can be removed

by loosening the screw and

sliding the clip out.

Place the side firebacks

in place.

Replace the clips removed in

firebacks.

Place the fireback

so the vertical grout line on

the edge of the fireback is

facing the rear.

1/4” Nutdriver

NOTE:

Place the floor firebacks in place. step “a” to secure the side

564 HO Ember-Fyre Burner and Log Set

Installation Instructions (sku 96900116)

Page 4 of 9 17601655 — 11/14/12 © Travis Industries, Inc.

5. Replace the Accent Lights. The fireplace should now look as shown below.

6. Install the burner inside the firebox.

7. Install the grate on top of the burner. Note how the grate slides into metal clips on the sides of the burner.

564 HO Ember-Fyre Burner and Log Set

Installation Instructions (sku 96900116)

Page 5 of 9 17601655 — 11/14/12 © Travis Industries, Inc.

8. Install the correct air deflector as shown below. Note how the dimple inserts into a slot on the burner (“a”).

Figure 1: Deflector Replacement

9. Install the rivets on the burner as shown below.

Figure 2: Rivets Placement

NG LP a

NLL

564 HO Ember-Fyre Burner and Log Set

Installation Instructions (sku 96900116)

Page 6 of 9 17601655 — 11/14/12 © Travis Industries, Inc.

10. Install the Rear Log onto the 2 pins at the rear of the firebox, as shown below. The log rests against the back

wall or fireback.

NOTE: NG and LP configurations require different log placement settings. For NG pull the rear log forward for

maximum glow. For LP push the rear log to the back to avoid sooting.

Figure 3: Rear Log Location

Figure 4: Rear Log Installed

Figure 5: Rear Log – Top View

Figure 6: Rear Log - Bottom View

11. Install the Left Log onto the 2 pins at the left of the firebox, as shown below. Note how the pin and metal post

insert into the holes on the log.

Figure 7: Left Log Location

Figure 8: Left Log Installed

Figure 9: Left Log – Top View

Figure 10: Left Log - Bottom View

564 HO Ember-Fyre Burner and Log Set

Installation Instructions (sku 96900116)

Page 7 of 9 17601655 — 11/14/12 © Travis Industries, Inc.

12. Install the Right Log onto the 2 pins at the right of the firebox, as shown below. Note how the two pins on the

burner insert into the holes on the log.

Figure 11: Right Log Location

Figure 12: Right Log Installed

Figure 13: Right Log – Top View

Figure 14: Right Log - Bottom View

13. Install the Center Ember Chunk as shown below. Note how the pin inserts into the hole on the log.

Figure 15: Center Ember Chunk Location

Figure 16: Center Ember Chunk Installed

Figure 17: Center Ember Chunk - Top View

Figure 18: Center Ember Chunk - Bottom View

564 HO Ember-Fyre Burner and Log Set

Installation Instructions (sku 96900116)

Page 8 of 9 17601655 — 11/14/12 © Travis Industries, Inc.

14. Install the Right Log Chunk as shown below. Note how it rests on the grate and fireback.

Figure 19: Right Log Chunk Location

Figure 20: Right Log Chunk Installed

Figure 21: Right Log Chunk – Top View

Figure 22: Right Log Chunk - Bottom View

15. Install the Left Log Chunk as shown below. Note how the flat portion of the log rests on the grate.

Figure 23: Left Log Chunk Location

Figure 24: Left Log Chunk Installed

Figure 25: Left Log Chunk – Top View

Figure 26: Left Log Chunk - Bottom View

564 HO Ember-Fyre Burner and Log Set

Installation Instructions (sku 96900116)

Page 9 of 9 17601655 — 11/14/12 © Travis Industries, Inc.

16. Install the Right Twig as shown below. Note how the flat side of the twig fits on the right log and the pin on the

rear log.

Figure 27: Right Twig Pin

Figure 28: Right Twig Installed

Figure 29: Right Twig – Top View

Figure 30: Right Twig -- Bottom View

17. Remove the embers from their bag and place them around the front of the firebox, as shown below.

Figure 31: Embers Placed

Andere Handbücher für 564 HO

Andere Travis Industries Kamin im Innenbereich Handbücher

Travis Industries

Travis Industries 864 See Through GS2 Bedienungsanleitung

Travis Industries

Travis Industries 430 Ember-Glo GSR2 Bedienungsanleitung

Travis Industries

Travis Industries Interior Bedienungsanleitung

Travis Industries

Travis Industries GreenSmart Fireplace 564 SS Bedienungsanleitung

Travis Industries

Travis Industries Pro Builder Linear Bedienungsanleitung

Travis Industries

Travis Industries Green Smart Bedienungsanleitung

Travis Industries

Travis Industries 864 Clean Face Bedienungsanleitung

Travis Industries

Travis Industries DVL Insert Bedienungsanleitung

Travis Industries

Travis Industries 4415 HO GSR2 Bedienungsanleitung

Travis Industries

Travis Industries GreenSmart Fireplace 564 SS Bedienungsanleitung

Travis Industries

Travis Industries Medium Flush Wood Hybrid Fyre Insert Bedienungsanleitung

Travis Industries

Travis Industries 864 ST GSR2 Bedienungsanleitung

Travis Industries

Travis Industries DVS GSR Bedienungsanleitung

Travis Industries

Travis Industries 430 GSR2 Bedienungsanleitung

Travis Industries

Travis Industries Lopi Pro Builder 72 GSB2 Bedienungsanleitung

Travis Industries

Travis Industries 864 HO GS Bedienungsanleitung

Travis Industries

Travis Industries DVS GSR2 NB Insert Bedienungsanleitung

Travis Industries

Travis Industries 1750 Bedienungsanleitung

Travis Industries

Travis Industries 21 TRV GreenSmart Bedienungsanleitung

Travis Industries

Travis Industries X-96 Bedienungsanleitung

Travis Industries

Travis Industries Fireplace Xtrordinair 864 GSR2 Bedienungsanleitung

Travis Industries

Travis Industries DVS GSR Ember-Fyre Bedienungsanleitung

Travis Industries

Travis Industries 33 DVI Bedienungsanleitung

Travis Industries

Travis Industries 1924 Illuminations Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch