Travis Industries 864 HO GS Bedienungsanleitung

864 HO GS Fireplace

Featuring the Burner

• Direct Vent Fireplace

• Natural Gas or Propane

• Vent Horizontally or Vertically

• Standard Residential

• Mobile Home Approved

Tested and Listed by

Report # 100162735PRT-001 - ANSIZ21.88

WARNING: If the information in these instructions is not followed exactly, a fire or explosion may result

causing property damage, personal injury or loss of life.

- Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any phone in your building.

• Immediately call gas supplier from a neighbor's phone. Follow the gas supplier's instructions.

• If you cannot reach your gas supplier, call the fire department.

- Installation and service must be performed by a qualified installer, service agency or the gas supplier.

This appliance may be installed in

an aftermarket permanently

located, manufactured home (USA

only) or mobile home, where not

prohibited by local codes.

This appliance is only for use

with the type(s) of gas indicated

on the rating plate. A conversion

kit is supplied with the appliance.

Owner’s Manual

Installer: After installation give this manual to

the home-owner and explain operation

of this heater.

000

4100716

www.travisproducts.com

4800 Harbour Pointe Blvd. SW

Mukilteo, WA 98275

2 Table of Contents

BTU Specifications................................................................................... 5

Dimensions .............................................................................................. 5

Fireplace Placement Requirements ......................................................... 6

Clearances ............................................................................................... 6

Raised Fireplaces .................................................................................... 6

Min. Framing Dimensions......................................................................... 7

Nailing Brackets ....................................................................................... 8

Gas Line Requirements............................................................................ 9

Fuel .......................................................................................................... 9

Gas Line Connection................................................................................ 9

Gas Inlet Pressure ................................................................................... 9

Gas Line Location .................................................................................... 9

Electrical Connection ............................................................................... 10

Vent Requirements .................................................................................. 11

Vent Clearances....................................................................................... 11

Vent Firestop............................................................................................ 11

Altitude Considerations ............................................................................ 11

Approved Vent ......................................................................................... 11

Vent Installation........................................................................................ 11

Approved Vent Configurations ................................................................. 12

Restrictor Position .................................................................................... 12

Exhaust Restrictor.................................................................................... 12

Intake Restrictor ....................................................................................... 13

Vent Configuration: Horizontal Termination (no vertical rise) ................... 14

Vent Configuration: Horizontal Termination (with vertical rise)................. 15

Vent Configuration: Vertical Termination.................................................. 16

Termination Requirements ....................................................................... 17

Hearth Requirements ............................................................................... 18

Floor Mounted Fireplaces......................................................................... 18

Raised Fireplaces .................................................................................... 18

Facing Requirements ............................................................................... 19

Mantel Requirements ............................................................................... 20

Steps for Finalizing the Installation........................................................... 21

Air Shutter Adjustment ............................................................................. 21

Glass Frame Removal and Installation..................................................... 21

Log Installation ......................................................................................... 23

Before You Begin ..................................................................................... 24

Location of Controls ................................................................................. 24

Continuous Pilot / GreenSmart™ Pilot Switch.......................................... 25

Yearly Service Procedure......................................................................... 26

Glass Cleaning......................................................................................... 26

Accent Light Bulb Replacement ............................................................... 26

Replacement Parts List ............................................................................ 27

Wiring Diagram ........................................................................................ 28

LP Conversion Instructions ...................................................................... 29

Safety Precautions 3

Safety Warnings:

•Failure to follow all of the requirements may result in property damage, bodily injury, or even death.

•This unit must be installed by a qualified installer to prevent the possibility of an explosion.

•This appliance must be installed in accordance with all local codes, if any; if not, in U.S.A. follow

ANSI Z223.1 and NFPA 54(88), in Canada follow CSA B149.1.

•All exhaust gases must be vented outside the structure of the living-area. Combustion air is drawn

from outside the living-area structure. The venting must not be connected to a chimney flue serving a

separate solid-fuel burning appliance.

•Notify your insurance company before hooking up this fireplace.

•The room heater should be inspected before use and at least annually by a qualified service person.

More frequent cleaning may be required due to excessive lint from carpeting, bedding material, etc.

•The instructions in this manual must be strictly adhered to. Do not use makeshift methods or

compromise in the installation. Improper installation will void the warranty and safety listing.

•This heater is approved for use with natural gas (NG) or propane (LP). Burning the incorrect fuel will

void the warranty and safety listing and may cause an extreme safety hazard. Direct questions about

the type of fuel used to your dealer.

•Contact your local building officials to obtain a permit and information on any installation restrictions

or inspection requirements in your area.

•If the flame becomes sooty, dark orange in color, or extremely tall, do not operate the heater. Call

your dealer and arrange for proper servicing.

•It is imperative that control compartments, screens, or circulating air passageways of the heater be

kept clean and free of obstructions. These areas provide the air necessary for safe operation.

•Do not operate the heater if it is not operating properly in any fashion or if you are uncertain. Call

your dealer for a full explanation of your heater and what to expect.

•Do not store or use gasoline or other flammable liquids in the vicinity of this heater.

•Do not operate if any portion of the heater was submerged in water or if any corrosion occurs.

Immediately call a qualified service technician to inspect the appliance and to replace any part of the

control system and any gas control which has been under water.

•Do not place clothing or other flammable items on or near the heater. Because this heater can be

controlled by a thermostat there is a possibility of the heater turning on and igniting any items placed

on or near it.

•Light the heater using the built-in igniter. Do not use matches or any other external device to light

your heater.

•Never remove, replace, modify or substitute any part of the heater unless instructions are given in this

manual. All other work must be done by a trained technician. Don't modify or replace orifices.

•The viewing glass should be opened only for conducting service.

•Any safety screen or guard removed for servicing must be replaced prior to operating the heater.

4 Safety Precautions

Safety Warnings (continued):

•Allow the heater to cool before carrying out any maintenance or cleaning.

•Operate the heater according to the instructions included in this manual.

•If the main burners do not start correctly turn the gas off and call your dealer for service.

•This unit is not for use with solid fuel.

•Do not place anything inside the firebox (except the optional artwork).

•Do not throw this manual away. This manual has important operating and maintenance instructions

that you will need at a later time. Always follow the instructions in this manual.

•Young children should be carefully supervised when they are in the same room as the appliance.

Toddlers, young children and others may be susceptible to accidental contact burns. A physical

barrier is recommended if there are at risk individuals in the house. To restrict access to a fireplace

or stove, install an adjustable safety gate to keep toddlers, young children and other at risk individuals

out of the room and away from hot surfaces.

•Children and adults should be alerted to the hazards of high surface temperature and should stay

away to avoid burns or clothing ignition. Do not touch the hot surfaces of the heater. Educate all

children of the danger of a high-temperature heater.

•Due to the high temperature, the heater should be located out of traffic and away from furniture and

draperies.

•Instruct everyone in the house how to shut gas off to the appliance and at the gas main shutoff valve.

The gas main shutoff valve is usually next to the gas meter or propane tank and requires a wrench to

shut off.

•Travis Industries, Inc. grants no warranty, implied or stated, for the installation or

maintenance of your heater, and assumes no responsibility of any consequential damage(s).

Features and Specifications 5

BTU Specifications

Natural Gas Propane

Maximum BTU Input Per Hour 46,700 46,700

Dimensions

36-3/4"

933mm

41"

1041mm

19-3/4"

502mm

44-1/2"

1130mm

29-1/4"

743mm

225 Lbs. (102 Kg)

37"

940mm

35-1/4"

895mm

25mm

8" (203mm) 

48"

1219mm

1/2"

12mm

40-3/4"

1035mm

14"

356mm

Left

 gauche

Front

avant

Right

droit

Rear

arriŁre

(a) Includes ½” Clearance

6 Installation (for qualified installers only)

Fireplace Placement Requirements

•Fireplace must be installed on a level surface capable of supporting the fireplace and vent

•Fireplace must be placed directly on wood or non-combustible surface (not on linoleum or carpet)

•Fireplace should be located out of traffic and away from furniture and draperies.

•Fireplace must be placed so the gaps below and above the glass frame do not become blocked.

•Fireplace may be placed in a bedroom. Please be aware of the large amount of heat this appliance

produces when determining a location.

Clearances

(a) Clearance to Side and Rear of Fireplace 0” (0mm)

(b) When installed, walls in front of the fireplace must be a minimum 5” (127mm) to the side of the

fireplace. Do not place insulation in this space.

Raised Fireplaces

•The fireplace (and hearth, if desired) may be placed on a platform designed to support the fireplace

and vent.

Installation (for qualified installers only) 7

Min. Framing Dimensions

41-1/4"

1048mm

48"

1219mm

20-3/4"

(527mm)

56-3/8"

1432mm

8 Installation (for qualified installers only)

Nailing Brackets

The fireplace has nailing brackets on both sides. Secure the fireplace to the framing.

1/2''(13mm)

5/8''(16mm)

5/8" (16mm)

54-7/8’’

(1394mm)

1/2" (13mm)

Installation (for qualified installers only) 9

Gas Line Requirements

•The gas line must be installed in accordance with all local codes, if any; if not, follow ANSI 223.1 and

NFPA 54(88), in Canada follow CSA B149.1 and the requirements listed below.

•The fireplace and gas control valve must be disconnected from the gas supply piping during any

pressure testing of that system at test pressures in excess of 1/2 psig (3.5 kPA). For pressures

under 1/2 psig (3.5 kPA), isolate the gas supply piping by closing the manual shutoff valve.

•Leak test all gas line joints and the gas control valve prior to and after starting the fireplace.

•The fireplace has an internal shutoff valve. An additional shutoff valve is required. It must be

accessible and within 6’ of the fireplace.

Fuel

•This fireplace is designed either for natural gas or for propane (but not for both).

Gas Line Connection

•Installation must be performed by a qualified installer, service agency or the gas supplier (In Massachusetts a

licensed plumber/gasfitter).

Gas Inlet Pressure Maximum Input Pressure Minimum Input Pressure

Natural Gas 7" W.C. (1.74 kPA) 5.5” W.C. (1.37 kPA)

Propane 13" W.C. (3.23 kPA) 11” W.C. (2.74 kPA)

•If the pressure is not sufficient, make sure the piping used is large enough, the supply regulator is adequately

adjusted, and the total gas load for the residence does not exceed the amount supplied.

•The supply regulator (the regulator that attaches directly to the residence inlet or to the propane tank) should

supply gas at the input pressure listed above. Contact the local gas supplier if the regulator is at an improper

pressure.

Gas Line Location

The gas line is located on the left side of the appliance in the location shown below. The gas inlet

accepts a ½” FPT.

6-1/4"

159mm

10-3/4"

273mm

6-1/4"

159mm

10-3/4"

273mm

10 Installation (for qualified installers only)

Electrical Connection

•The electrical line to the grounded receptacle inside the fireplace must be installed by a qualified

installer and must meet all local codes.

•Make sure the household breaker is shut off prior to working on any electrical lines.

•The appliance, when installed, must be electrically grounded in accordance with local codes or, in the

absence of local codes, with the National Electrical Code, ANSI/NFPA 70, or the Canadian Electrical

Code, CSA C22.1.

•The electrical line must be a min. 14 gauge, and supply 120 Volts, 60 Hz, and 5.7 Amps.

•Route the electrical connection through the junction box cover plate and attach to the hookup wires

pictured below.

Caution: Label all wires prior to disconnection when servicing controls. Wiring errors can cause

improper and dangerous operation.

Do not connect 110-120 VAC to the gas control valve or wiring system of this fireplace.

abcd

Andere Handbücher für 864 HO GS

Inhaltsverzeichnis

Andere Travis Industries Kamin im Innenbereich Handbücher

Travis Industries

Travis Industries 4415 HO GSR2 Bedienungsanleitung

Travis Industries

Travis Industries Xtrordinair ProBuilder 36 CleanFace MV Bedienungsanleitung

Travis Industries

Travis Industries 616 GSR2 Insert Bedienungsanleitung

Travis Industries

Travis Industries 864 HO NB GSR2 Bedienungsanleitung

Travis Industries

Travis Industries 864 HH Bedienungsanleitung

Travis Industries

Travis Industries Flush Wood Plus Bedienungsanleitung

Travis Industries

Travis Industries 4415 HO GSR2 Bedienungsanleitung

Travis Industries

Travis Industries DVS GSR Bedienungsanleitung

Travis Industries

Travis Industries 564 TRV GSR2 Bedienungsanleitung

Travis Industries

Travis Industries 564 LedgeStone Bedienungsanleitung

Travis Industries

Travis Industries Pro Builder Linear Bedienungsanleitung

Travis Industries

Travis Industries 564 Bedienungsanleitung

Travis Industries

Travis Industries 564 DF GSR2 Bedienungsanleitung

Travis Industries

Travis Industries 1750 Wood Bedienungsanleitung

Travis Industries

Travis Industries DVS EF Insert Bedienungsanleitung

Travis Industries

Travis Industries 430 GSR2 Bedienungsanleitung

Travis Industries

Travis Industries Flush Wood Plus Bedienungsanleitung

Travis Industries

Travis Industries DVS GSR NB Insert Bedienungsanleitung

Travis Industries

Travis Industries 36 CF ST/Pier Bedienungsanleitung

Travis Industries

Travis Industries DVS EF Fireplace Bedienungsanleitung

Travis Industries

Travis Industries GreenSmart Fireplace 564 SS Bedienungsanleitung

Travis Industries

Travis Industries DaVinci Bedienungsanleitung

Travis Industries

Travis Industries 864 TRV Bedienungsanleitung

Travis Industries

Travis Industries LOPI X Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch