Whalen WSUC-4C Bedienungsanleitung

Upper Cabinet w/Shelves

WSUC-4C Dark Cherry finish

WSUC-4W White finish

THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION.

PLEASE READ AND KEEP FOR FUTURE REFERENCE.

Whalen Storage Factory No.: 15294 Page #1 of 11

ADULT ASSEMBLY REQUIRED DUE TO THE PRESENCE OF SMALL PARTS, SHARP

POINTS, SHARP EDGES AS RECEIVED

Please call for replacement parts or assistance: 1-866-942-5362

Pacific Standard Time: 8:30 a.m. – 4:30 p.m. Monday to Friday

Or visit our web site www.whalenstorage.com

MAXIMUM RECOMMENDED WEIGHT LOADS

Please call for replacement parts or assistance: 1-866-942-5362

Whalen Storage Factory No.: 15294 Page #2 of 11

MAXIMUM LOAD: 30 LBS. (13.6 KG)

This unit is intended for use only with the maximum weights

indicated. Use with products heavier than the maximum weights indicated may

result in instability causing possible injury.

Serious or fatal crushing injuries can occur from furniture tip-over.

To help prevent tip-over:

zPlace heaviest items in the lowest drawer, shelf.

zDo not set TVs or other heaviest objects on the top of this product.

zNever open more than one drawer at a time and never allow children to climb or

hang on drawers, doors, or shelves.

Use of tip-over restraints may only reduce, but not eliminate, the risk of tip-over.

This is a permanent label. Do not attempt to remove!

WARNING

CAM LOCK SYSTEM OPERATION

HOW THE KD ASSEMBLY SYSTEM WORKS

1. Screw Cam Bolt into the pre-drilled small holes on panel.

2. Insert Cam Lock into pre-drilled hole on panel.

3. Make sure Cam Lock pointed arrow is pointed towards Cam Bolt.

4. Connect both panels together; making sure Cam Bolts goes into pre-drilled hole on the end of

panel with Cam Lock.

5. Once Cam Bolt is connected inside Cam Lock, take Phillips screwdriver and tighten Cam

Lock clockwise. You are now ready to assemble our KD unit.

ASSEMBLY TIPS

Read all instructions BEFORE assembly.

Remove all hardware from box and sort by size.

Check to see that all hardware and parts are present BEFORE assembling.

Ask a friend to assist you with the assembly of this furniture.

To avoid damage, assemble the unit on a sturdy, level and non-abrasive surface.

Please wait until all steps are completed before tightening bolts.

Make sure all bolts are tightly fastened before the unit is used.

Please call for replacement parts or assistance: 1-866-942-5362

Whalen Storage Factory No.: 15294 Page #3 of 11

Parts List

Please read completely through the instructions and verify that all parts listed are present before

beginning assembly.

1- Top Panel (x 1) 2- Upper Front Molding (x 1)

3- Stretcher (x 1) 4- Side Panel Left (x 1)

5- Side Panel Right (x 1) 6- Adjustable Shelf (x 2)

7- Bottom Panel (x 1) 8- Back Panel (x 1)

9- Lower Front Molding (x 1)

Please call for replacement parts or assistance: 1-866-942-5362

Whalen Storage Factory No.: 15294 Page #4 of 11

Hardware List

Please read completely through the instructions and verify that all hardware listed are present

before beginning assembly.

A- Cam Lock (x 12) B- Cam Bolt (x 12)

C- M8 x 30 mm Dowel (x 8) D- Plastic Connector (x 6)

E- #8 x 13 mm Screw (x 12) F- Metal Plate (x 2)

G- #8 x 16 mm Screw (x 8) H- #4 x 19 mm Screw (x 20)

I- Tipping Restraint Hardware (x 1) J- Shelf Pin (x 8)

K- Plastic Cover (x 4) L- M6 x 25 mm Dowel (x 3)

M- Floor Protector (x 4)

Tools required: Rubber mallet, Phillips screwdriver (not provided)

Please call for replacement parts or assistance: 1-866-942-5362

Whalen Storage Factory No.: 15294 Page #5 of 11

Assembly Instructions

1. Connect Lower Front Molding (9) to Bottom Panel (7) by attaching 2 Plastic Connectors (D) at the joint with

#8 x 13 mm Screws (E), using the pilot holes as a reference. Tighten the Screws with the Phillips Screwdriver.

2. Screw 3 Cam Bolts all the way into the small holes located on Side Panel Left (4) as shown below. Insert the

M8 x 30 mm Dowel (C) into the end holes as a guide, attach both Bottom Panel (7) and Stretcher (3) to the

Side Panel Left (4) by engaging Cam Locks (A).

3. Repeat last step with Side Panel Right (5).

Please call for replacement parts or assistance: 1-866-942-5362

Whalen Storage Factory No.: 15294 Page #6 of 11

Assembly Instructions

4. Secure Lower Front Molding (9) to the Side Panels (4 & 5) by attaching 2 Plastic Connectors (D) at the joints

with the #8 x 13 mm Screws (E) into the pilot holes.

5. Attach Upper Front Molding (2) to Top Panel (1) by using three M6 x 25 mm Dowels (L) and 2 Plastic

Connectors (D). Fasten each Plastic Connector (D) by screwing two #8 x 13mm Screws (E) into the pilot holes.

6. Screw 6 Cam Bolts (B) all the way into the pre-drilled small holes of Top Panel (1) as shown below.

Please call for replacement parts or assistance: 1-866-942-5362

Whalen Storage Factory No.: 15294 Page #7 of 11

Assembly Instructions

7. Insert the M8 x 30 mm Dowels (C) into the middle holes as a guide, attach the Top Panel (1) to assembled

frame by engaging 6 Cam Locks (A) as shown below.

8. Expand the Back Panel (8) and lay it onto the back edges of assembled frame making sure the margins along

all edges are equal. Attach the Back Panel in place by using #4 x 19 mm Screws (H) through the pre-drilled

holes of Back Panel.

Please call for replacement parts or assistance: 1-866-942-5362

Whalen Storage Factory No.: 15294 Page #8 of 11

Assembly Instructions

9. Stand the unit upright. Set the Shelf Pins (J) at your desired height at the same level. Tilt and install

Adjustable Shelves (6) in place.

10. Plug Plastic Covers (K) to cover the visible Cam Locks inside the cabinet.

10. Gently tap the Floor Protectors (M) at the bottom of side panels avoiding crack or damage of side panel. If you

plan to use this unit as a hutch (stand this on another unit), please skip this step.

Please call for replacement parts or assistance: 1-866-942-5362

Whalen Storage Factory No.: 15294 Page #9 of 11

Assembly Instructions

NOTE: If you buy more than one unit, the stacking configuration can be available.

11. This cabinet was designed with a feature that allows

stacking two units. Additional units sold separately.

Place second unit on top of base unit making sure it is

centered properly and back edges are even. Secure

units together by attaching the metal plates (F) at both

ends with the #8 x 16 mm screws (G) into the pre-

drilled holes. Use caution to prevent damage to side

panels.

Note: The Metal Plates are provided to prevent

the unit from falling over. You must attach them

to the product in use with all the #8 x 16 mm

Screws.

TIPPING RESTRAINT HARDWARE

We have included one Tipping Restraint Hardware bag for this unit. You must install this hardware to

prevent accidents or injuries from falling unit.

When properly installed, this restraint can provide protection against the unexpected tipping of the storage

rack due to small tremors, bumps or climbing. We strongly recommended mounting this hardware to a

wall stud and your unit.

Please carefully read the instructions printed on the bag.

Note: You must install the Tipping Restraint Hardware with the unit in use to prevent any accidents or

damage to the unit.

Tools Required: Phillips Screwdriver, Mallet, Power Drill, and 3/8” Drill Bit.

Please call for replacement parts or assistance: 1-866-942-5362

Whalen Storage Factory No.: 15294 Page #10 of 11

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Whalen Inneneinrichtung Handbücher

Whalen

Whalen WHA-10005 Bedienungsanleitung

Whalen

Whalen WSWB72-ST-E Bedienungsanleitung

Whalen

Whalen 19WTLD-SPCA Bedienungsanleitung

Whalen

Whalen SPLS-RBK-WH Bedienungsanleitung

Whalen

Whalen Jaxon 3-in-1 XL-27EL Bedienungsanleitung

Whalen

Whalen 53SNR2301BAS Bedienungsanleitung

Whalen

Whalen SFKCWMS Bedienungsanleitung

Whalen

Whalen WF60CVG Bedienungsanleitung

Whalen

Whalen SPUS-LDHL-LF Bedienungsanleitung

Whalen

Whalen Bayside Furnishing 1644994 Bedienungsanleitung

Whalen

Whalen Bayside Furnishings MLTOFBB Bedienungsanleitung

Whalen

Whalen Industrial Audio Tower Bedienungsanleitung

Whalen

Whalen Shelby 60in Bedienungsanleitung

Whalen

Whalen PROL-37 Bedienungsanleitung

Whalen

Whalen Seymour BJAVCLSM-65 Bedienungsanleitung

Whalen

Whalen Montreal Laptop Desk Bedienungsanleitung

Whalen

Whalen BBLAVC54T Bedienungsanleitung

Whalen

Whalen Bayside CUS60AC-1 Bedienungsanleitung

Whalen

Whalen OD-LA60LD Bedienungsanleitung

Whalen

Whalen WMCPRO-9 Bedienungsanleitung

Whalen

Whalen Bayside CSC7PD-8 Bedienungsanleitung

Whalen

Whalen XLDEC54-NV Bedienungsanleitung

Whalen

Whalen TV Console BBAVCL54-SMB Bedienungsanleitung

Whalen

Whalen Aurora ARFP72CRS-6 Bedienungsanleitung

Beliebte Inneneinrichtung Handbücher anderer Marken

Homelegance

Homelegance California 1662PEK-1CK Bedienungsanleitung

Osmond Ergonomics

Osmond Ergonomics FLO Bedienungsanleitung

OVE

OVE ELOISE 42 Bedienungsanleitung

overstock

overstock MF286255 Bedienungsanleitung

Sonoma

Sonoma 160-801 Bedienungsanleitung

BOLERO

BOLERO Wicker Side Chair CF158 Installationsanleitung

Coaster

Coaster 4799N Bedienungsanleitung

Stor-It-All

Stor-It-All WS39MP Programmierhandbuch

Lexicon

Lexicon 194840161868 Bedienungsanleitung

Next AMELIA NEW 462947 Bedienungsanleitung

impekk

impekk Manual II Bedienungsanleitung

Elements

Elements Ember Nightstand CEB700NSE Bedienungsanleitung

JWA

JWA CARY 68429 Bedienungsanleitung

VIPACK

VIPACK AMORI AMKB9014 Bedienungsanleitung

Rowico

Rowico SANNA Bedienungsanleitung

Southern Enterprises

Southern Enterprises CK556000TX Bedienungsanleitung

hygena

hygena 314/5041 Bedienungsanleitung

VINNOVA

VINNOVA Kinsley 536060S Bedienungsanleitung