Whalen Shelby 60in Bedienungsanleitung

THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION.

PLEASE READ AND KEEP FOR FUTURE REFERENCE.

Date 2020-06-05 Rev. 0001-B

Shelby 60in Fireplace Console

Model # WSF60SY26C

# WSF60SY26M

ADULT ASSEMBLY REQUIRED

If you have any questions regarding assembly or if parts are missing, DO NOT return this item to the

store where it was purchased. Please call our toll-free customer service number and have your

instructions and parts list ready to provide the model name, part name or factory number:

1-866-942-5362

Pacific Standard Time: 8:30 a.m. - 4:30 p.m., Monday - Friday

Or visit our web site 24 hours a day, 7 days a week for product assistance at

www.whalenfurniture.com

Or e-mail your request to parts@whalenfurniture.com

LOT NUMBER:

DATE PURCHASE

QUALITY GUARANTEE

We are confident that you will be delighted with your Whalen Furniture purchase.

Should this product be defective in workmanship or materials or fail under normal use, we will repair or

replace it for up to one (1) year from date of purchase. Every Whalen Furniture product is designed to meet

your highest expectations. We guarantee that you will immediately see the value of our fine furniture.

This warranty gives you specific legal rights and you may also have other rights which vary from state to state

or province to province

Whalen Furniture Manufacturing,

1578 Air Wing Road

San Diego CA, 92154 USA

Customer Service: 1-866-942-5362

8:30 a.m. - 4:30 p.m., PST, Monday to Friday

www.whalenfurniture.com

MANUFACTURER: Whalen Furniture Manufacturing

CATALOG : Shelby 60in Fireplace Console

MODEL # WSF60SY26C / WSF60SY26M

M A X I M U M R E C O M M E N D E D W E I G H T L O A D S

THIS UNIT IS NOT INTENDED FOR USE WITH CRT TVS. USE ONLY WITH FLAT

PANEL TVS AND AUDIO/VIDEO EQUIPMENT MEETING RECOMMENDED SIZE AND WEIGHT LIMITS.

NEVER USE WITH LARGER/HEAVIER THAN RECOMMENDED FLAT PANEL TVS OR EQUIPMENT. TO

AVOID INSTABILITY, PLACE FLAT PANEL TV IN THE CENTER OF THE UNIT; THE BASE OF THE

TELEVISION MUST BE ABLE TO REST ON THE SUPPORTING SURFACE OF THE UNIT WITHOUT

OVER-HANGING THE EDGES. IMPROPERLY POSITIONED FLAT PANEL TVS, OR FLAT PANEL TVS

INCLUDING OTHER EQUIPMENT THAT EXCEED RECOMMENDED SIZE AND WEIGHT LIMITS

COULD FALL OFF OR BREAK THE UNIT, CAUSING POSSIBLE SERIOUS INJURY. FOR USE WITH

TELEVISIONS WEIGHING 80LBS (36.3 KG) OR LESS. USE WITH HEAVIER TELEVISIONS MAY RESULT IN

INSTABILITY CAUSING TIP OVER RESULTING IN DEATH OR SERIOUS INJURY.

FITS UP TO MOST 177.8 cm / 70 in

FLAT PANEL TVS

MAXIMUM LOAD 36.3 kg / 80 lb

MAXIMUM LOAD 22.7 kg / 50 lb

IMPORTANT

Before you begin: Open, identify and count all parts prior to assembly. Lay out parts on a flat and non-

abrasive surface. You will need the parts identified on page 4 and 5 of this instruction manual.

NOTE: IT IS VERY IMPORTANT TO USE GLUE WITH THE DOWELS. EXCESS GLUE CAN BE

WIPED OFF WITH A DAMP CLOTH.

Insert Dowel at least halfway by tapping lightly with a rubber mallet (not included), IF NECESSARY.

CAM LOCK SYSTEM OPERATION

HOW THE KNOCK DOWN (KD) ASSEMBLY SYSTEM WORKS

1. Screw the Cam Bolt into the pre-drilled small holes on the panel. Connect both panels together; making sure

the Cam Bolt goes into the pre-drilled hole at the end of the panel with the Cam Lock.

2. Insert the Cam Lock into the pre-drilled large hole in the panel. Make sure the arrow on the Cam Lock is

pointed towards the Cam Bolt.

3. Once the Cam Bolt is connected inside the Cam Lock, take a Phillips screwdriver (not included) and

tighten the Cam Lock clockwise.

4. Plug the Cam Lock Cover into the cross slot of the Cam Locks to conceal the cam.

You are now ready to assemble the KD unit.

Parts and Hardware List

Please read completely through the instructions and verify that all listed parts and hardware are present

before beginning assembly.

A- Top Panel (Qty. 1) B- Fixed Shelf (Qty. 1) C- Bottom Panel (Qty. 1)

D- Left Side Panel (Qty. 1) E- Right Side Panel (Qty. 1) F- Left Lower Partition (Qty.1)

G- Right Lower Partition (Qty. 1) H- Upper Partition (Qty. 1) I- Middle Crossbar Assembly (Qty. 1)

J- Middle Left Stile (Qty. 1) K- Middle Right Stile (Qty. 1) L- Base Front Molding (Qty. 1)

M- Left Bottom Molding (Qty. 1) N- Right Bottom Molding (Qty. 1) O- Base Rear Stretcher (Qty. 1)

P- Base Front Stretcher (Qty. 1) Q- Door (Qty. 2) R- Door Glass Insert (Qty. 2)

S- Adjustable Shelf (Qty. 2) T- Upper Back Panel (Qty. 1) U- Lower Back Panel (Qty. 2)

Parts and Hardware List

Please read completely through the instructions and verify that all listed parts and hardware are

present before beginning assembly.

V- Firebox Support (Qty. 1) Fireplace insert (Qty. 1) Remote control with battery (Qty. 1)

(1) Cam Lock (2) Cam Bolt (3) M8 x 30 mm Wood Dowel

(Qty. 39+1 extra) (Qty. 39+1 extra) (Qty. 46+2 extra)

(4) #8 x 1-1/2” Wood Screw (6) #8 x 1” Screw (7) #3 x 5/8” Black Screw

(Qty. 28+1 extra) (Qty. 2) (Qty. 4+1 extra)

(8) #3 x 5/8” Washer Head Screw (9) #4 x 5/8” Zinc Screw (10) 2” Self-tapping Screw

(Qty. 30+1 extra) (Qty. 24+1 extra) (Qty. 2)

(11) Metal Bracket (Qty. 2) (12) Cam Lock Cover (Qty. 20+1 extra) (13) Shelf Support (Qty. 8+1 extra)

(14) Knob (Qty. 2) (15) 28 mm Knob Bolt (Qty. 2) (16) Rubber Bumper (Qty. 4+1 extra)

(17) Hinge (Qty. 4) Glue (Qty. 1) Touch-up Pen (Qty. 1) Tipping Restraint Hardware Kit (Qty. 2)

(Included in plastic bag)

Tools required (not provided): Phillips screwdriver, stud finder, power drill and 1/8” drill bit.

Assembly Instructions

1. Unpack the unit and confirm that you have all the hardware and required parts. Assembly the unit on a

carpeted floor or the empty carton to avoid any scratch.

2. Secure screw the Cam Bolts (2) into the designated small holes on the Fixed Shelf (B), Bottom Panel

(C), Lower Partitions (F and G) by a Phillips screwdriver, as shown in the illustration.

3. Insert two Wood Dowels (3) into the inner holes of the Middle Crossbar Assembly (I). Tap in with a

rubber mallet, if necessary. Make sure that you use a small amount of glue with both ends of all dowels.

4. Align the drilled holes on the Fixed Shelf (B) with the inserted Wood Dowel (3) on the Middle Crossbar

Assembly (I), and then press them together. Attach the Middle Crossbar Assembly (I) in place by

engaging three Cam Locks (1) (Refer to page 3 on Cam Lock system operation supplement).

Assembly Instructions

5. Align and attach the Base Rear Stretcher (O) to the Bottom Panel (C) by using three wood dowels (3)

and four cam locks (1).

6. Align and attach the Middle Left Stringer (J) to the Left Lower Partition Panel (F) by using two Wood

Dowels (3) and three Cam Locks (1).

7. Repeat last step to combine the Middle Right Stringer (K) with the Right Lower Partition Panel (G)

together.

Assembly Instructions

8. Insert four Wood Dowels (3) into the inner holes of the Lower Partition Panels (F and G) and attach

them to the Fixed Shelf (B) by engaging four Cam Locks (1).

9. Insert four Wood Dowels (3) into the bottom holes of the Lower Partition Panels (F and G) and position

the Bottom Panel (C) onto the inserted Wood Dowels (3). Attach the Bottom Panel (C) in place by

using four 1-1/2” Wood Screws (4).

Assembly Instructions

10. Securely screw the Cam Bolts (2) into the designated small holes on the Left and Right Side Panels (D

and E) by a Phillips screwdriver.

11. Insert three Wood Dowels (3) into the inner holes on the Left Bottom Molding (M) and fasten it to the

Left Side Panel (D) with six 1-1/2” Wood Screws (4).

12. Repeat last step to combine the Right Bottom Molding (N) with the Right Side Panel (E) together.

Assembly Instructions

13. Insert ten Wood Dowels (3) into the large holes on Bottom Panel and Base Rear Stretcher (C and O)

and Fixed Shelf (B) at both ends.

14. Align the large holes on the Left Side Panel (D) with the inserted Wood Dowels (3). Firmly press them

together and fasten it in place by engaging five Cam Locks (1).

15. Repeat last step to attach Right Side Panel (E) at the other end.

16. Align and attach the Base Front Stretcher (P) to the Bottom Panel (C) by using three Wood Dowels (3)

and four Cam Locks (1). As shown.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Whalen Inneneinrichtung Handbücher

Whalen

Whalen Bayside CSC72BK-7 Bedienungsanleitung

Whalen

Whalen Bayside Furnishings CSC5430WD-4PC Bedienungsanleitung

Whalen

Whalen Bayside CSC9PD-9-T Bedienungsanleitung

Whalen

Whalen WSF60RV26DO Bedienungsanleitung

Whalen

Whalen Bayside Furnishings CSC72LBK-6 Bedienungsanleitung

Whalen

Whalen Tavia ECOM-TA30BK Bedienungsanleitung

Whalen

Whalen Bayside Furnishings MLTOFBB Bedienungsanleitung

Whalen

Whalen XLDEC54-NV Bedienungsanleitung

Whalen

Whalen Marilla OD-MA48PD Bedienungsanleitung

Whalen

Whalen XLCD-15 Bedienungsanleitung

Whalen

Whalen WF36EVB Bedienungsanleitung

Whalen

Whalen BBHC60DBC Bedienungsanleitung

Whalen

Whalen Belmont 2-in-1 Work Station Bedienungsanleitung

Whalen

Whalen WSC72-MW-E Bedienungsanleitung

Whalen

Whalen Bayside CSC72TC-10 Bedienungsanleitung

Whalen

Whalen WSLW30IFV Bedienungsanleitung

Whalen

Whalen AVCBEC60-SMB Bedienungsanleitung

Whalen

Whalen Kendal Chair Gray Bedienungsanleitung

Whalen

Whalen CCA4836AC-4 Bedienungsanleitung

Whalen

Whalen Huntingdon EC-HU48D Bedienungsanleitung

Whalen

Whalen WF60BVJ Bedienungsanleitung

Whalen

Whalen Bayside CSC7PD-5 Bedienungsanleitung

Whalen

Whalen WSCSC6172WB Bedienungsanleitung

Whalen

Whalen Fallbrook SPUS-FBSF-GM Bedienungsanleitung

Beliebte Inneneinrichtung Handbücher anderer Marken

Homelegance

Homelegance California 1662PEK-1CK Bedienungsanleitung

Osmond Ergonomics

Osmond Ergonomics FLO Bedienungsanleitung

OVE

OVE ELOISE 42 Bedienungsanleitung

overstock

overstock MF286255 Bedienungsanleitung

Sonoma

Sonoma 160-801 Bedienungsanleitung

BOLERO

BOLERO Wicker Side Chair CF158 Installationsanleitung

Coaster

Coaster 4799N Bedienungsanleitung

Stor-It-All

Stor-It-All WS39MP Programmierhandbuch

Lexicon

Lexicon 194840161868 Bedienungsanleitung

Next AMELIA NEW 462947 Bedienungsanleitung

impekk

impekk Manual II Bedienungsanleitung

Elements

Elements Ember Nightstand CEB700NSE Bedienungsanleitung

JWA

JWA CARY 68429 Bedienungsanleitung

VIPACK

VIPACK AMORI AMKB9014 Bedienungsanleitung

Rowico

Rowico SANNA Bedienungsanleitung

Southern Enterprises

Southern Enterprises CK556000TX Bedienungsanleitung

hygena

hygena 314/5041 Bedienungsanleitung

VINNOVA

VINNOVA Kinsley 536060S Bedienungsanleitung