Advantech PCA-684 Bedienungsanleitung

PCA-6184

Full-size socket 478

Intel® Pentium® 4

processor-based PCI/ISA

bus CPU card

User’s Manual

PCA-6184, ed. 1 User’s Manual ii

This document is copyrighted, 2002, by Advantech Co., Ltd. All rights

are reserved. Advantech Co., Ltd. reserves the right to make improve-

ments to the products described in this manual at any time. Specifications

are thus subject to change without notice.

No part of this manual may be reproduced, copied, translated, or transmit-

ted in any form or by any means without the prior written permission of

Advantech Co., Ltd. Information provided in this manual is intended to

be accurate and reliable. However, Advantech Co., Ltd., assumes no

responsibility for its use, nor for any infringements upon the rights of

third parties which may result from its use.

Acknowledgements

• AWARD is a trademark of AWARD Software, Inc.

• IBM and PC are trademarks of International Business Machines

Corporation.

• Intel® and Pentium® 4 are trademarks of Intel Corporation.

• WinBond is a trademark of Winbond Corporation.

• ATI is a registered trademark of ATI Technologies, Inc.

All other product names or trademarks are the properties of their respec-

tive owners.

Part No. 2006618400

1st Edition Printed in Taiwan July 2002

Contents

Chapter 1 Hardware Configuration .................................2

1.1 Introduction ....................................................................... 2

1.2 Features ............................................................................. 3

1.3 Specifications .................................................................... 4

1.3.1 System............................................................................. 4

1.3.2 Memory........................................................................... 4

1.3.3 Input/Output.................................................................... 4

1.3.4 VGA interface................................................................. 4

1.3.5 Ethernet LAN.................................................................. 5

1.3.6 Industrial features ........................................................... 5

1.3.7 Mechanical and environmental specifications................ 5

1.4 Jumpers and Connectors.................................................... 6

Table 1.1:Jumpers........................................................... 6

Table 1.2:Connectors ...................................................... 6

1.5 Board Layout: Jumper and Connector Locations.............. 8

Figure 1.1:Jumper and connecter locations .................... 8

Figure 1.2:Extension I/O daughter board ....................... 9

1.6 Safety Precautions ........................................................... 10

1.7 Jumper Settings ............................................................... 10

1.7.1 How to set jumpers ....................................................... 10

1.7.2 CMOS clear (J1) ........................................................... 10

Table 1.3:CMOS (J1).................................................... 11

1.7.3 Watchdog timer output (J2) .......................................... 11

Table 1.4:Watchdog timer output (J2).......................... 11

1.8 System Memory .............................................................. 11

Table 1.5:DIMM memory capacity

sample calculation......................................................... 12

1.8.1 Supplementary information about DIMMs................... 12

1.9 Memory Installation Procedures ..................................... 12

1.10 Cache Memory ................................................................ 12

1.11 CPU Installation .............................................................. 13

1.11.1 Power Supply................................................................ 13

Chapter 2 Connecting Peripherals .................................16

2.1 Primary (CN1) and Secondary (CN2) IDE Connectors .. 16

2.2 Floppy Drive Connector (CN3)....................................... 17

2.3 Parallel Port (CN4).......................................................... 17

2.4 USB Ports (CN6)............................................................. 18

2.5 VGA Connector (CN7) ................................................... 18

2.6 10/100Base-T Ethernet Connectors (CN8 and CN34).... 19

2.7 Serial Ports (CN9: COM1; CN10: COM2) ..................... 19

PCA-6184, ed. 1 User’s Manual 2

Table 2.1:Serial port connections (COM1, COM2)) .... 19

2.8 PS/2 Keyboard and Mouse Connectors (CN11 and 33).. 20

2.9 External Keyboard Connector (CN12)............................ 20

2.10 Infrared (IR) Connector (CN13) ..................................... 21

2.11 CPU Fan Connector (CN14) ........................................... 21

2.12 Front Panel Connectors (CN16, 17, 18, 19, 21&22)....... 22

2.12.1 Power LED and Keyboard Lock(CN16) ...................... 22

Table 2.2:PS/2 or ATX Power Supply LED Status...... 22

2.12.2 External speaker (CN17) .............................................. 22

2.12.3 Reset (CN18) ................................................................ 23

2.12.4 HDD LED (CN19)........................................................ 23

2.12.5 SM Bus Connector (CN29)........................................... 23

2.12.6 Connecting to SNMP-1000 remote manager................ 23

2.13 ATX Power Control Connectors (CN20 and 21) ............ 24

2.13.1 ATX feature (CN20)

and soft power switch (CN21) ................................................... 24

Chapter 3 Award BIOS Setup.........................................28

3.1 Introduction ..................................................................... 28

3.2 Entering Setup ................................................................. 28

Figure 3.1:Award BIOS Setup initial screen ................ 28

3.3 Standard CMOS Setup .................................................... 29

Figure 3.2:Standard CMOS features screen ................. 29

3.3.1 CMOS RAM backup .................................................... 29

3.4 Advanced BIOS Features ................................................ 30

Figure 3.3:Advanced BIOS features screen.................. 30

3.4.1 Virus Warning............................................................... 30

3.4.2 CPU L1 & L2 Cache..................................................... 30

3.4.3 Quick Power on Self Test ............................................. 30

3.4.4 First/Second/Third/Other Boot Device......................... 30

3.4.5 Swap Floppy Drive ....................................................... 31

3.4.6 Boot UP Floppy Seek ................................................... 31

3.4.7 Boot Up NumLock Status............................................. 31

3.4.8 Gate A20 Option........................................................... 31

3.4.9 Typematic Rate Setting................................................. 31

3.4.10 Typematic Rate (Chars/Sec) ......................................... 31

3.4.11 Typematic Delay (msec)............................................... 31

3.4.12 Security Option ............................................................. 31

3.5 Advanced Chipset Features............................................. 32

Figure 3.4:Advanced chipset features screen ............... 32

3.5.1 DRAM Timing Selectable ............................................ 32

3.5.2 CAS Letency Time ....................................................... 33

3.5.3 Active to Precharge Delay ............................................ 33

3.5.4 DRAM RAS#-to-CAS Delay........................................ 33

3.5.5 DRAM RAS# Precharge............................................... 33

3.5.6 DRAM DATA Integrity Mode ..................................... 33

3.5.7 Memory Frequency For Onboard UBS ........................ 33

3.5.8 DRAM Read Thermal Mgmt........................................ 33

3.5.9 System BIOS Cacheable............................................... 33

3.5.10 Video BIOS Cacheable................................................. 33

3.5.11 Memory Hole At 15M-16M ......................................... 34

3.5.12 Delay Transaction ......................................................... 34

3.5.13 Delay Prior to Thermal ................................................. 34

3.5.14 AGP Apecture Size (MB) ............................................. 34

3.6 Integrated Peripherals...................................................... 35

Figure 3.5:Integrated peripherals (1) ............................ 35

3.6.1 On-Chip Primary/Secondary PCI IDE.......................... 35

3.6.2 IDE Primary Master/Slave PIO/UDMA, and

IDE Secondary Master/Slave PIO/UDMA Modes (Auto)........ 35

3.6.3 USB Controller ............................................................. 35

3.6.4 USB Keyboard Support ................................................ 35

3.6.5 Onboard FDC Controller .............................................. 36

3.6.6 Onboard Serial Port 1 (3F8H/IRQ4)............................. 36

3.6.7 Onboard Serial Port 2 (2F8H/IRQ3)............................. 36

3.6.8 UART Mode Select ...................................................... 36

3.6.9 RxD, TxD Active.......................................................... 36

Figure 3.6:Integrated peripherals (2) ............................ 36

3.6.10 Onboard Parallel Port (378/IRQ7)................................ 37

3.6.11 Parallel Port Mode (ECP + EPP) .................................. 37

3.6.12 ECP Mode Use DMA ................................................... 37

3.7 Power Management Setup............................................... 37

Figure 3.7:Power management setup............................ 37

3.7.1 Power-supply Type ....................................................... 38

3.7.2 Power Management ...................................................... 38

3.7.3 Video Off In Suspend ................................................... 38

3.7.4 MODEM Use IRQ ........................................................ 38

3.7.5 Soft-Off by PWRBTN .................................................. 38

3.7.6 CPU THRM-Throttling................................................. 39

3.7.7 Power on by LAN ......................................................... 39

3.7.8 Power on by Ring ......................................................... 39

3.7.9 Power on by Alarm ....................................................... 39

Figure 3.8:PnP/PCI configurations screen.................... 39

3.8.1 PnP OS Installed ........................................................... 39

3.8.2 Reset Configuration Data.............................................. 40

3.8.3 Resources controlled by:............................................... 40

3.9 PC Health Status.............................................................. 40

Figure 3.9:PC health status screen................................ 40

3.9.1 CPU Warning Temperature .......................................... 40

3.9.2 Current System Temperature ........................................ 40

3.9.3 Current CPU Temperature ............................................ 40

PCA-6184, ed. 1 User’s Manual 4

3.9.4 VCORE......................................................................... 41

3.9.5 +5V/+12V/-5V/-12V .................................................... 41

3.10 Load Setup Defaults ........................................................ 41

3.11 Password Setting ............................................................. 41

3.12 Save & Exit Setup ........................................................... 42

3.13 Exit Without Saving ........................................................ 42

Chapter 4 Chipset Software Installation Utility............44

4.1 Before you begin ............................................................. 44

4.2 Introduction ..................................................................... 45

4.3 Installing the CSI Utility ................................................. 46

Chapter 5 AGP SVGA Setup ..........................................48

5.1 Before you begin ............................................................. 48

5.2 Features ........................................................................... 49

5.3 VGA Installation ............................................................. 49

Chapter 6 LAN Configuration ........................................54

6.1 Introduction ..................................................................... 54

6.2 Features ........................................................................... 54

6.3 Driver Installation ........................................................... 54

6.4 Windows NT Drivers (Intel 82559) Setup Procedure..... 55

6.5 Windows 2000 Drivers (Intel 82559) Setup Procedure .. 59

Chapter 7 Onboard Security Setup ................................66

7.1 Introduction ..................................................................... 66

7.2 Windows 9X Drivers Setup Procedure ........................... 66

7.3 Windows NT Drivers Setup Procedure........................... 68

7.4 Using the OBS Hardware Doctor Utility ........................ 71

Chapter 8 Ultra ATA Storage Driver Setup ..................74

8.1 Introduction ..................................................................... 74

8.2 Features ........................................................................... 74

8.3 Installation....................................................................... 75

8.4 Displaying Driver Information........................................ 79

Appendix A Programming the watchdog timer...............82

A.1 Programming the Watchdog Timer................................. 82

A.1.1 Watchdog timer overview............................................. 82

A.1.2 Reset/ Interrupt selection .............................................. 82

A.1.3 Programming the Watchdog Timer .............................. 82

Table A.1:Watchdog Timer Registers .......................... 84

A.1.4 Example Program ......................................................... 85

Appendix B Pin Assignments ............................................92

B.1 IDE Hard Drive Connector(CN1, CN2).......................... 92

Table B.1:IDE hard drive connector (CN1, CN2) ........ 92

B.2 Floppy Drive Connector (CN3)....................................... 93

Table B.2:Floppy Drive Connector (CN3) ................... 93

B.3 Parallel Port Connector (CN4) ........................................ 94

Table B.3:Parallel Port Connector (CN4)..................... 94

B.4 USB Connector (CN6) .................................................... 95

Table B.4:USB Connector (CN6)................................ 95

B.5 VGA Connector (CN7) ................................................... 95

Table B.5:VGA Connector (CN7) ................................ 95

B.6 Ethernet Base-T Connector (CN8, CN34) ...................... 96

Table B.6:Ethernet 10/100Base-T RJ-45

Connector (CN8, CN34) ............................................... 96

B.7 COM1/COM2 Serial Port (CN9, CN10)......................... 96

Table B.7:COM1/COM2 RS-232 serial port (CN9,

CN10) ............................................................... 96

B.8 Keyboard and Mouse Connnector (CN11)...................... 97

Table B.8:Keyboard and Mouse Connector (CN 11) ... 97

B.9 External Keyboard Connector (CN12)............................ 97

Table B.9:External Keyboard Connector (CN 12) ....... 97

B.10 IR Connector (CN13) ...................................................... 98

Table B.10:IR Connector (CN 13)................................ 98

B.11 CPU Fan Power Connector (CN14)................................ 98

Table B.11:CPU Fan Power Connector (CN 14).......... 98

B.12 Power LED and Keyboard Lock (CN16)........................ 99

Table B.12:Power LED and

Keyboard Lock (CN 16) .............................................. 99

B.13 External Speaker Connector (CN17)............................... 99

Table B.13:External Speaker Connector (CN 17) ........ 99

B.14 Reset Connector (CN18) ............................................... 100

Table B.14:Reset Connector (CN 18)......................... 100

B.15 HDD LED Connector (CN19)....................................... 100

Table B.15:HDD LED Connector (CN 19) ................ 100

B.16 ATX Feature Connector (CN20)................................... 101

Table B.16:ATX Feature Connector (CN 20) ............ 101

B.17 ATX Soft Power Switch (CN21) .................................. 101

Table B.17:ATX Soft Power Switch (CN 21) ............ 101

B.18 Extension I/O Board Connector (CN27)....................... 102

Table B.18:Extension I/O Board Connector (CN 27). 102

B.19 Extension I/O Board Connector (CN28)....................... 102

Table B.19:Extension I/O Board Connector (CN 28). 102

B.20 SM Bus Connector (CN29) ........................................... 103

Table B.20:SM Bus Connector (CN 29)..................... 103

B.21 System I/O Ports............................................................ 103

Table B.21:System I/O Ports ...................................... 103

B.22 DMA Channel Assignments.......................................... 104

PCA-6184, ed. 1 User’s Manual 6

Table B.22:DMA Channel Assignments .................... 104

B.23 Interrupt Assignments ................................................... 105

Table B.23:Interrupt Assignments.............................. 105

B.24 1st MB Memory Map.................................................... 105

Table B.24:1st MB memory map ............................... 105

B.25 PCI Bus Map ................................................................. 106

Table B.25:PCI bus map............................................. 106

CHAPTER

General Information

This chapter provides background

information on the PCA-6184. It shows

you how to configure the card to match

your application and installation into

your PC.

Sections include:

• Introduction

• Features

• Specifications

• Board Layout

• Jumpers and Connectors

• Safety Precautions

• Jumper Settings

• System Memory

• Memory Installation Procedures

• Cache Memory

• CPU Installation

PCA-6184, ed. 1 User’s Manual 2

Chapter 1 Hardware Configuration

1.1 Introduction

The PCA-6184 Series all-in-one industrial grade single board computer is

a high performance and full-featured computing engine. It meets most

industrial application requirements.

Advantech's PCA-6184 full-sized CPU card is designed with Intel 845

chipset and supports socket 478 Pentium® 4/Celeron™ processor (FSB

400MHz) up to 2GB and above. In addition to high-speed processor, the

PCA-6184 supports up to 2GHz DDR200/DDR266 SDRAM memory

with 2 onboard DIMM socket. Ideal for high-performance and demand-

ing applications, it provides maximum computing power and productiv-

ity. Moreover, the PCA-6184 is built-in with ATI Rage 128 Pro 4XL and

32MB onboard VGA SDRAM. It features superior 3D performance with

AGP 4X. Single or dual Intel 82559 10/100Base-T Ethernet controller are

available in the PCA-6184 series. The high reliability and excellent per-

formance provided by Intel 82559 Ethernet controller are crucial for vari-

ous network applications. Flexible I/O expansion ports allow customers

to optimize their need for four USB, dual LAN port, and additional PS/2

keyboard & mouse port

A CMOS data backup is stored in the Flash memory, which protects data

even after a battery failure. Also included is a 255-level watchdog timer,

which resets the CPU or generates an interrupt if a program cannot be

executed normally. This enables reliable operation in unattended environ-

ments. The remote management interface enables the PCA-6184 to be

managed through Ethernet when it is connected to the SNMP-1000

Remote HTTP/SNMP System Manager..

Note: Some of the features mentioned above are not

available with all models. For more information

about the specifications of a particular model,

see Section 1.3 Specifications.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Advantech PCI-Karte Handbücher

Advantech

Advantech PCI-1240 Bedienungsanleitung

Advantech

Advantech PCI-1751 Bedienungsanleitung

Advantech

Advantech PCI-1243U Bedienungsanleitung

Advantech

Advantech PCIE-1762H Bedienungsanleitung

Advantech

Advantech PCA-6005-B Bedienungsanleitung

Advantech

Advantech PCI-1724U Bedienungsanleitung

Advantech

Advantech PCI-1780 Bedienungsanleitung

Advantech

Advantech PCM-3614I Installations- und Betriebshandbuch

Advantech

Advantech PCIE-1824 Bedienungsanleitung

Advantech

Advantech MIO-5393 Bedienungsanleitung

Advantech

Advantech PCI-1752USO Installations- und Betriebshandbuch

Advantech

Advantech PCI-1712 Installations- und Betriebshandbuch

Advantech

Advantech PCI-1761 Bedienungsanleitung

Advantech

Advantech PCI-1671UP Installations- und Betriebshandbuch

Advantech

Advantech PCIE-1754 Bedienungsanleitung

Advantech

Advantech MOS-1110Y-0101E Bedienungsanleitung

Advantech

Advantech ECU-P1706 Installations- und Betriebshandbuch

Advantech

Advantech MIC-3758DIO Bedienungsanleitung

Advantech

Advantech MIC-3723 Bedienungsanleitung

Advantech

Advantech MIC-3451 Bedienungsanleitung

Advantech

Advantech MIC-3401 Bedienungsanleitung

Advantech

Advantech DVP-7010BE Bedienungsanleitung

Advantech

Advantech PCA-5610 Installations- und Betriebshandbuch

Advantech

Advantech PCI-1714 Bedienungsanleitung

Beliebte PCI-Karte Handbücher anderer Marken

ERMA

ERMA SSI 1417 Bedienungsanleitung

SIIG

SIIG CyberSerial Dual PCI Montageanleitung

Moxa Technologies

Moxa Technologies CP-102E Bedienungsanleitung

I-Bus

I-Bus IBC2602 Bedienungsanleitung

Exsys

Exsys EX-60102 Bedienungsanleitung

Chelsio Communications

Chelsio Communications T5 Series Bedienungsanleitung

Conrad Electronic

Conrad Electronic 97 46 71 Bedienungsanleitung

Micro Innovations

Micro Innovations USB650A Bedienungsanleitung

KTI Networks

KTI Networks KF-310 Bedienungsanleitung

Asus

Asus SpaceLink WL230 Bedienungsanleitung

SIIG

SIIG SC2475 Bedienungsanleitung

TRENDnet

TRENDnet TEW-703PI Bedienungsanleitung

Belkin

Belkin F5D7000F Bedienungsanleitung

Pericom

Pericom PI7C7100 Bedienungsanleitung

ADLINK Technology

ADLINK Technology cPCI-3548 Bedienungsanleitung

Digium

Digium TE200 Series Bedienungsanleitung

Allo.com

Allo.com 2nd Gen E1/T1/J1 Bedienungsanleitung

Western Digital

Western Digital FireWire PCI Adapter Bedienungsanleitung