AFe Power Magnum FORCE 54-13035D Bedienungsanleitung

advanced FLOW engineering Magnum FORCE Stage-2 Cold Air Intake System

Instruction Manual P/N: 54-13035D / 54-13035R

Make: Jeep Model: Grand Cherokee (WK2) Year: 2016-2019 Engine: V6-3.6L

Make: Dodge Model: Durango Year: 2016-2019 Engine: V6-3.6L

Label Qty. Description Part Number

A1 1 Air Filter (Pro DRY S) 21-91146

A2 1 Air Filter (Pro 5R) 24-91146

B 1 Tube 05-5413035B1

C 1 Housing 05-5413023B2

D 1 Plug, Silicone 05-01482

E 1 Fitting, Air Temp. Sensor 05-01454

F 1 Coupling, Silicone, Bellow Reducer 05-01400

G 1 Grommet 03-50167

H 2 Clamp, #052 03-50008

I 1 Seal, Trim: 7/16" (34" inches) 05-00072

J 1 Hose, Breather: 1/2"ID x 30"L 05-01422

Emissions Disclaimer: This product is not currently CARB exempt and is not available for purchase in

California or for use on any vehicle registered with the California Department of Motor Vehicles.

• Please read the entire instruction manual before proceeding.

• Ensure all components listed are present.

• If you are missing any of the components, call customer support at 951-493-7100.

• Ensure you have all necessary tools before proceeding.

• Do not attempt to work on your vehicle when the engine is hot.

• Disconnect the negative battery terminal before proceeding.

Page 2

Tools Required: Flat head screwdriver, 8mm & 10mm nut drivers.

Recommended: Panel popper.

Retain factory parts for future use.

aFepower.com

Page 3

A1/A2

Refer to Figure A for Steps 1-2

Step 1: Pull up on the cover. 1

Step 2: With the 10mm nut driver, remove the factory screw 2 , then carefully pull off the engine cover.

Page 4

REMOVAL

Figure A

Refer to Figure B for Steps 3-7

aFepower.com

Page 5

REMOVAL

Step 3: Disconnect the temperature sensor harness from the temperature sensor by pinching and ﬁrmly

pulling away 3 .

Step 4: Detach the temp sensor harness from the factory intake 4 .

Step 5: Remove the crank-case vent (CCV) hose from the factory airbox and tuck out of the way. 5

Step 6: With the 8mm nut driver, loosen the band clamp at the throttle body. 6

Step 7: If equipped, unclip the vent hose on the backside of the factory airbox.

Figure B

Refer to Figure C for Steps 8-9

Step 8: Carefully pull up and remove the trim seal on top of the factory intake scoop, along with 1-2 clips

on either side. This helps with removing the factory airbox and installation of the aFe POWER

housing. 7

Note: It may help to use a panel popper when pulling the clips.

Step 9: Pull the factory intake tube off the throttle body and pull up to remove the entire factory intake.

Figure C

Page 6

REMOVAL

aFepower.com

Page 7

Refer to Figure D for Steps 10-12

Step 10: Transfer the three factory rubber grommets from the factory airbox to the aFe POWER housing

as shown in Figure 1. 8

Step 11: Pre-assemble the aFe POWER housing by inserting the aFe POWER ﬁlter. 9

Step 12: Install the supplied trim seal on the aFe POWER housing. 10

Figure D

INSTALL

FIGURE 1

Step 13: If desired, install the supplied aFe POWER plug. 11

Step 14: Install the housing assembly into the vehicle.

NOTE: Without the plug installed, the aFe POWER intake will capture the maximum air available.

More airﬂow offers more power. Some of this air is picked up from inside the engine

compartment and could be warmer air. Warmer air will affect the performance of the

vehicle.

Refer to Figure E for Steps 13-14

Figure E

INSTALL

Page 8

Step 15: Pre-assemble the aFe POWER intake tube by inserting the supplied rubber grommet and temp

sensor ﬁtting. Transfer the temp sensor 12 from the factory tube to the ﬁtting on the aFe

POWER tube. Turn the temp sensor clockwise until it locks in place.

Refer to Figure F for Step 15

Page 9

Figure F

INSTALL

Page 10

Step 16: Follow the factory crankcase hose to the rear of the engine 13 .

Step 17: Disconnect the hose from its mounting location 14 as shown in Figure 2.

Step 18: Once the factory crankcase hose is disconnected, replace it with the supplied aFe POWER

hose by slipping the shorter end of the hose at the rear of the engine 15 as shown in Figure 3.

Refer to Figure G for Steps 16-18

Figure G

INSTALL

Figure G

Figure 2

Figure 3

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere aFe Power Autozubehör Handbücher

aFe Power

aFe Power Scorpion Bedienungsanleitung

aFe Power

aFe Power 77-46306 Bedienungsanleitung

aFe Power

aFe Power 77-83028 Bedienungsanleitung

aFe Power

aFe Power SCORCHER GT 77-47004 Bedienungsanleitung

aFe Power

aFe Power 77-83046 Bedienungsanleitung

aFe Power

aFe Power Scorpion 79-21002L Bedienungsanleitung

aFe Power

aFe Power dfs780 Bedienungsanleitung

aFe Power

aFe Power Takeda 56-10005D Bedienungsanleitung

aFe Power

aFe Power Quantum 2500 Bedienungsanleitung

aFe Power

aFe Power 46-20299-B Bedienungsanleitung

aFe Power

aFe Power 54-13053D Bedienungsanleitung

aFe Power

aFe Power advanced FLO engineering Bedienungsanleitung

aFe Power

aFe Power SCORCHER BLUE 77-83043 Bedienungsanleitung

aFe Power

aFe Power 46-70270 Bedienungsanleitung

aFe Power

aFe Power 46-71180A Bedienungsanleitung

aFe Power

aFe Power F1-03003 Bedienungsanleitung

aFe Power

aFe Power 46-70022 Bedienungsanleitung

aFe Power

aFe Power Magnum FORCE Bedienungsanleitung

aFe Power

aFe Power takeda 56-70043D Bedienungsanleitung

aFe Power

aFe Power 46-39102 Bedienungsanleitung

aFe Power

aFe Power QUANTUM 53-10005D Bedienungsanleitung

aFe Power

aFe Power Scorpion 79-21001L Bedienungsanleitung

aFe Power

aFe Power 05-01016 Bedienungsanleitung

aFe Power

aFe Power MOMENTUM GT 50-70034S Bedienungsanleitung

Beliebte Autozubehör Handbücher anderer Marken

James Baroud

James Baroud Odyssey Bedienungsanleitung

Motorola

Motorola i50sx Bedienungsanleitung

Yakima

Yakima 9MM STANDARD BIKE MOUNT Bedienungsanleitung

Feniex

Feniex T3 Bedienungsanleitung

Kia

Kia E8300-4D000 Bedienungsanleitung

Brink

Brink 756843 Bedienungsanleitung

Whispbar

Whispbar K085W Bedienungsanleitung

v.link

v.link CI-VL2-PC-HSD Bedienungsanleitung

Viking

Viking Stack-Rack Kurzanleitung zur Einrichtung

Aries

Aries 203015 Bedienungsanleitung

Choetech

Choetech AT0005 Bedienungsanleitung

ZZ2

ZZ2 ZZAIR-PRO Bedienungsanleitung

Holman

Holman 4A80L Bedienungsanleitung

Thule

Thule 2075 Bedienungsanleitung

Motorola

Motorola T325 Bedienungsanleitung

TAUBENREUTHER

TAUBENREUTHER 16-3950 Installationsanleitung

DV8

DV8 FBJL-02 Bedienungsanleitung

Prorack

Prorack K1163 Bedienungsanleitung

aFe Power Magnum FORCE 54-13035D Bedienungsanleitung

Beliebte Autozubehör Handbücher anderer Marken