Bradley S19-120P Bedienungsanleitung

Installation

P.O. Box 309

Menomonee Falls, WI 53052 USA

800 BRADLEY (800 272 3539)

+1 262 251 6000

bradleycorp.com

215-148P Rev. R; ECN 17-05-039

Page 1 of 4 7/18/2017

S19-120P

Drench Shower with Drench Hose

Table of Contents

Pre-Installation Information .............................................................2

Supplies Required...........................................................................3

Assemble components....................................................................3

Connect water supply......................................................................3

Assembly of Components ...............................................................4

Parts List .........................................................................................4

S19-120P Installation

7/18/2017 Bradley • 215-148P Rev. R; ECN 17-05-039

WARNING

Flush the water supply lines before beginning installation and after installation is complete. Test

the unit for leaks and adequate water flow. Main water supply to the eyewash should be “ON” at all

times. Provisions shall be made to prevent unauthorized shutoff.

CAUTION

Emergency equipment must be supplied with tepid water (60°F to 100°F/15.6°C to 37.8°C). Any

prolonged exposure to near freezing water affects the body's ability to maintain body temperature,

increasing the risk of hypothermia.

NOTICE

Before installing this product, ensure that there are adequate clearances around the product and

activation of the product does not interfere with other products or obstructions.

Avoid cleaners containing organic solvents, alcohols and hydrocarbons. Rinse with water after

cleaning.

IMPORTANT

The installation and location of all safety drench showers, eye and eye/face washes must comply

with the requirements of ANSI/ISEA Z358.1.

Read this installation manual completely to ensure proper installation, then file it with the owner or

maintenance department. Compliance and conformity to drain requirements and other local codes

and ordinances is the responsibility of the installer.

Separate parts from packaging and make sure all parts are accounted for before discarding any

packaging material. If any parts are missing, do not begin installation until you obtain the missing

parts.

The ANSI/ISEA Z358.1 standard requires an uninterrupted supply of flushing fluid. Bradley plumbed

emergency fixtures require a minimum of 30 PSI (0.21MPa) flowing pressure.

Self-closing spring-loaded valves are not UL classified to ANSI/ISEA Z358.1.

Weekly activation must be conducted on all plumbed emergency equipment to ensure a suitable

flushing fluid supply is present and any sediment build-up in the supply line is cleared. Emergency

equipment should be inspected monthly to address any maintenance issues ensuring the

equipment is in good operating condition and that there are no signs of wear.

Workers who may come in contact with potentially hazardous materials should be trained regarding

the placement and proper operation of emergency equipment per ANSI/ISEA Z358.1.

For questions regarding the operation or installation of this product, visit www.bradleycorp.com or

call 800-BRADLEY (272.3539).

Product warranties and parts information may also be found under ”Products” on our web site at

bradleycorp.com.

Installation S19-120P

Bradley • 215-148P Rev. R; ECN 17-05-039 7/18/2017

Supplies Required

• Pipe sealant and teflon tape

• Piping to 1" NPT water supply inlet

• Adequate supply pipe supports

• Minimum 4" (102 mm) drain to accommodate

30 gallons (115 liters) per minute discharge for

shower waste

• Sign-mounting hardware

• Backflow prevention device as required by

UPC, IPC and/or local plumbing codes

• OPTIONAL: Hardware to mount bracket to wall

Assemble components

1. Assemble components as shown on page 4.

2. Apply pipe sealant or tape (by installer) to all

male-threaded pipe joints.

3. Bottom edge of showerhead should be 84"

(2134 mm) from the floor.

Connect water supply

NOTICE! Do not rely on Bradley’s Drench Shower

to support supply piping.

1. Connect water supply piping to 1" NPT inlet

on unit (piping supplied by installer). Provide

adequate supports (supplied by installer)

for supply pipe using pipe hangers or other

means.

2. Mount the safety sign to the wall using sign-

mounting hardware supplied by installer.

4½"

(114mm)

(229mm)

Ø 3.1"

(78.7mm)

20"

(508mm)

84"

(2134mm)

Suggested

Height to

Floor

25½"

(648mm)

3⁵⁄₈"

(92mm)

(152mm)

S19-120P Installation

7/18/2017 Bradley • 215-148P Rev. R; ECN 17-05-039

Assembly of Components

P.O. BOX 309, MENOMONEE FALLS,WI 53052-0309 USA

TEL: 1-800-BRADLEY FAX: (262-251-5817)

http://www.bradleycorp.com

114-050

1.4

1.2

1.5

1.31

1.3

8.1

8.2

P.O. Box 309, Menomonee Falls,WI 53051

TESTTHIS UNIT EACH WEEK

Test-operatevalve(s) each week and sign below.

Report any malfunctions immediately.

Ventil(e)wöchentlich im Testbetrieb prüfen, bestätigt

durch Unterschrift.Jegliche Störung sofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESES GERÄT 1STWÖCHENTLICH ZU PRÜFEN.

ESSAI HEBDOMADAIRE

Testle fonctionnement des valves chaque semaine et

signe en bas.S'il y à quelque chose qui ne va pas fait

un rapport immédiatement.

10.1

10.2

10.3

10.1

12.4

12.1

12.3

12.2

Parts List

1" NPT

Supply Inlet

Items 1.1–1.5 come preassembled as Item 1.

Items 12.1–12.4 come preassembled as Item 12.

NOTE: Use

teflon tape

only.

Item Part No. Qty. Description

1 S30-059 1 Stay-Open Ball Valve Assembly

1.2 124-048 1 Washer, Friction

1.3 S27-278 1 1" Ball Valve with Jam Nut

1.31 110-214 1 Jam Nut only

1.4 153-489 1 Adapter

1.5 128-201 1 Handle

2 113-006LK 1 Pipe 1" NPT x 12"

3 169-847 1 90° Elbow 1" NPT

4 S24-188 1 Plastic Showerhead Assembly

5 151-001 2 Curtain Hook

6 128-156A 1 Pull Rod

7 204-421 1 Emergency Tag

8 S45-317 1 Hose Fitting Prepack

8.1 113-OO6MJ 1 Pipe Nipple

Item Part No. Qty. Description

8.2 169-880 1 Pipe Tee Reducer

9 114-050 1 Safety Sign

10 S45-831 1 Clip Prepack

10.1 269-681 1 U-Bolt with Nuts

10.2 140-601 1 Bracket - Wall

10.3 142-002BS 2 Lockwasher

11 S89-002 1 Yellow Tube 3/8"

12 S39-817 1 Hand-Held Hose

12.1 S45-2453 1 Service Kit EFW - Black

Sprayheads

12.2 S27-332 1 Valve

12.3 128-182 1 Handle

12.4 S53-063 1 Dust Cover

Andere Bradley Sanitärprodukte Handbücher

Bradley

Bradley Aerada 900 Series Bedienungsanleitung

Bradley

Bradley S96-051 Bedienungsanleitung

Bradley

Bradley S19294 Series Bedienungsanleitung

Bradley

Bradley S19-210FW Bedienungsanleitung

Bradley

Bradley S53-325 Bedienungsanleitung

Bradley

Bradley Terreon TDWL22 Bedienungsanleitung

Bradley

Bradley S19-310PVC Bedienungsanleitung

Bradley

Bradley S96-050 Bedienungsanleitung

Bradley

Bradley Advocate AV Series Bedienungsanleitung

Bradley

Bradley Express ELX Series Bedienungsanleitung

Bradley

Bradley WS-1X Bedienungsanleitung

Bradley

Bradley S67-504 Bedienungsanleitung

Bradley

Bradley S19-430A Bedienungsanleitung

Bradley

Bradley S19-310BF Bedienungsanleitung

Bradley

Bradley Verge LVRD Series Bedienungsanleitung

Bradley

Bradley Sentry SN2004/IR Bedienungsanleitung

Bradley

Bradley S19-220DCSS Bedienungsanleitung

Bradley

Bradley HN-400 Bedienungsanleitung

Bradley

Bradley E19-120A Bedienungsanleitung

Bradley

Bradley S19-220FW Bedienungsanleitung

Bradley

Bradley TDB3108 Bedienungsanleitung

Bradley

Bradley S19-120SSBF Bedienungsanleitung

Bradley

Bradley S19-110SS Bedienungsanleitung

Bradley

Bradley Express EXD Series Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Kohler

Kohler K-6228 Montageanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Kohler

Kohler K-12183 Montageanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Kohler

Kohler Centerset K-15240 Montageanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

Kohler

Kohler Mira Eco Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema